Search
Close this search box.
Shipping Quote in Sub Header

2024 Minnesota Oversize Permits And Regulations

Shipping Quote Minified - Header & Homepage

oversize load

Minnesota Oversize and Overweight Permits

Contact (877) 792-5056 for Oversize Permits in Minnesota.
Are you transporting a load that you think is oversize or overweight in Minnesota? Contact Wide Load Shipping to help you acquire the relevant shipping permits depending on the weight and dimensions. We have the experience and knowledge required to acquire shipping permits in Minnesota quickly. Below we have detailed information about the limits, pilot cars, superloads, and more. Shipping a mixer truck in Minnesota

Oversize Load Limits in Minnesota

Minnesota maximum load limits before a trucking permit are required.
  • Length: 53 feet.
  • Width:  8’6 feet.
  • Height: 13’6 feet.
  • Weight: 80,000 pounds GVW.
  • Overhang: 3 feet in the front and 4 feet in the rear.

When Pilot Cars or Escort Vehicles Are Required in Minnesota

Heavy-haul or oversize loads may require to be accompanied by an escort vehicle or pilot car if:
  • Length: 95 feet to 110 feet 1 pilot car or escort vehicle on the rear. Over 110 feet requires 1 front escort and 1 chase pilot car.
  • Width: Loads over 12 feet and 6 inches on most of the state roads requires one (but not all), 14 feet and 6 inches to 16 feet require 1 front pilot car and 1 rear escort on non-divided highways but only 1 rear on divided highways.  Over 16 feet wide and they will require 1 lead pilot car and a Police/LPA on the rear. On less than 4 lane roads 1 front pilot car is required and on 4 lanes 1 rear escort is required.  Up to 15 feet wide at which point a second escort is required. 18 feet or wider requires a police escort.
  • Height: If over 14 feet and 6 inches in height, you may be required to have a high pole depending on the route.
NOTE: Permits will state on them if they are valid for either 3 or 5 days.

What’s the Cost of Trucking Permits In Minnesota?

Here is the cost of oversize and overweight permits in Minnesota. Wide Load Shipping will help you acquire permits for your load. Call us today at (877) 792-5056.
  • Single trip oversize permits: $15
  • Single trip oversize permits for loads of between 14’6 to 16 feet during spring road restrictions: $135
  • Annual self-container compact truck permits: $85
  • Annual permits for hay, straw, or corn stalks of upto 12 feet wide, 14’6 feet high, and 75 feet long: $60
  • Job permit for overweight loads:$36
  • 10 feet wide snow plow seasonal permit: $60
  • 10% overweight and oversize annual permit: $200 – $900 (limited commodities)
  • Overweight sugar beet, potato, and carrot harvest seasonal permits: $60
  • 10% winter weight increase seasonal permit: $60
  • Livestock overweight annual permit: $200
  • Commercial boat annual permit: $120
  • Non-commercial boat annual permit: $60
  • Tow truck annual permit: $300
  • 6-axle raw or unprocessed agricultural products permit: $300
  • 7-axle raw or unprocessed agricultural products permit: $500
  • Forest product overweight annual permit: $300
We Offer Trucking Permits in the Following Cities in Minnesota; Minneapolis, MN; Saint Paul, MN; Rochester, MN; Bloomington, MN; Duluth, MN; Brooklyn Park, MN; Plymouth, MN; Woodbury, MN; Eagan, MN; Maple Grove, MN; St. Cloud, MN; Lakeville, MN; Blaine, MN; Eden Prairie, MN; Coon Rapids, MN; Burnsville, MN; Apple Valley, MN; Minnetonka, MN; Edina, MN; St. Louis Park, MN. Moorhead, MN; Mankato, MN; Shakopee, MN; Maplewood, MN; Cottage Grove, MN; We Offer Trucking Permits in the Following Counties in Minnesota; Hennepin County; Ramsey County; Dakota County; Anoka County ; Washington County; St. Louis County; Olmsted County; Stearns County; Scott County; Wright County; Carver County; Sherburne County; Blue Earth County; Rice County ; Crow Wing County; Clay County; Otter Tail County ; Chisago County; Winona County; Goodhue County; Beltrami County; Itasca County; Kandiyohi County; Benton County; Isanti County;

Oversize and Overweight Permit Limits in Minnesota

Here’s the maximum weight your load can be, even with a permit in Minnesota:
  • Single Axle Weight Permits: 20,000 pounds
  • Tandem axles Weight Permits: 40,000 pounds
  • Tridem axles Weight Permits: 60,000 pounds
  • Quadem axles Weight Permits: 72,000 pounds
  • Five axle Weight Permits: 92,000 pounds
  • Six axle Weight Permits: 112,000 pounds
  • Seven axle Weight Permits: 132,000 pounds
  • Eight axle Weight Permits: 144,000 pounds
Below are the maximum dimensions a load can be even with a permit in the state of Minnesota:
  • Max Length With Permit: 130 feet
  • Maximum Width With Permit: 16 feet
  • Maximum Height With Permit: 16’6 feet
NOTES: Farm equipment operating at less than 30 miles per hour may be exempt. Utility poles may be exempt.

Legal Travel Times for Oversize and Heavy-haul Loads in Minnesota

Travel times and restrictions for heavy-haul and oversize loads: Travel times are primarily from 2 AM until 10 PM, except for holidays. Some areas have rush hour restrictions from 7:30 AM to 8:30 AM and 4:00 PM to 5:30 PM, so check your permit, as any applicable restrictions will be listed. Spring restrictions usually start late in February and end in May for heavy-haul loads. Night-time travel is simply defined as local times of sunrise and sunset. The state of Minnesota observes Central Standard Time.

Oversize Load Signs in Minnesota | Lights, Safety Flags, and Warning Signs

Required marking, safety flags, and warning signs for heavy haul and oversize loads in Minnesota: Signs: Oversize load signs will need to meet the following requirements: be constructed of a rigid material or mounted on a flat surface that ensures the sign will remain flat and legible to all approaching traffic. Warning signs must be a minimum size of 18 inches tall and 84 inches wide. The background of all signs must be yellow with the letters “OVERSIZE LOAD” printed on them with a clear font no less than 10 inches tall and 1 and 3/8ths of an inch thick and black. The sign panel shall be lighted whenever used during nighttime transport. Whenever lighting a sign, it must be in a manner that illuminates it well enough to be seen from no less than 500 feet. Any oversize load that is over 12 feet wide requires oversize load signs. Oversize load signs are required on all vehicles and shipments that exceed 95 feet in length. All signs will need to be legible, clean, and in good condition whenever used. The appropriate and applicable sign will need to be mounted on the roof of the escort vehicle (not on the bumpers) whenever an escort vehicle or pilot car is required. Oversize load signs will need to be mounted on the truck’s cab towing the shipment and on the rear of the trailer no less than 5 feet above the pavement. Signs will need to be displayed when escorting or moving an oversize load. The oversize load sign shall be required on any oversized loads with multiple dimensions. “WIDE LOAD” and “LONG LOAD” signs must be used on escort vehicles, whichever is applicable. Signs will not be permitted to extend beyond the width of the vehicle’s fenders more than 6 inches to the left or the right of pilot car vehicles. The Minnesota DOT may even require additional signs if they determine it necessary. Flags: Flags are required to be used on any projection(s) that extend more than 3 feet beyond the front bumper or 4 feet beyond the rear of the truck bed of any semi-trucks or when any loads exceed 9 feet wide and or 65 feet long. Flags must be either safety fluorescent red, yellow or orange and be no less than 18 inches square. They must be securely attached to all extremities of overhang, whether on the front, the rear, and at the corners at the widest point, so they are visible to approaching motorists. Warning lights: Warning lights are required when traveling during night hours and must be visible from a distance of no less than 500 feet on a clear day. Simultaneously flashing warning lights will need to be spaced as far apart as possible and are required on the front and rear of the shipment and have a flash rate somewhere between 60 and 90 flashes permit. Lenses on all warning lights must be a minimum of 4 inches in diameter or have a minimum lense surface area of 12 and 1/2 inches. Instead of a pair of warning lights that flash simultaneously, either one or more strobe lights or rotating lights may be permitted.

Pilot Cars/Escort Vehicle Certifications and Requirements in Minnesota

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements in Minnesota: The state of Minnesota has two different types of pilot cars/escorts; 
  1. Civilian escorts/pilot cars
  2. Peace officer escorts/pilot cars.
Let’s learn about the two types first.
  1. Civilian escorts/pilot cars:
A civilian escort is an individual with a valid driver’s license and valid certification from Minnesota state DOT which has a reciprocal agreement (MVCSHTO) with the following states: Colorado, Florida, North Carolina, Oklahoma, Utah, and Washington state. Operators must be 18 years old and in a properly equipped automobile or pickup truck. This agreement allows other civilian escorts (pilot car operators) certified in participating states to operate independently. Pilot car and escort vehicles can be pickup trucks, SUVs, vans, or passenger vehicles in good operating condition and properly equipped. The driver of a pilot car or escort vehicle must be a minimum of 18 years of age and have a valid driver’s license. No pilot car or escort vehicle is permitted to tow any type of trailer or other vehicles when operating in the capacity of an escort or pilot car driver. A pilot car or escort vehicle operator is not permitted to perform other duties other than operating the vehicle. For example, suppose a rear steer is needed or a remote is utilized. In that case, the pilot car or escort vehicle operator is not permitted to participate in any of these operations. All escort vehicles and pilot cars must be equipped with a wide load or long load sign that shall be displayed on the top of the vehicle. This sign must be clean, clear, and visible to all traffic. In addition, rotating strobe or flashing amber lights must be installed in the center of the vehicle’s roof and not be obstructed by any other signage. Multiple lights may be used provided they are not obstructed by anything and should be placed on the far right and left-hand sides of the upper portion of the vehicle. A pilot car operating in the capacity of a lead vehicle will need to proceed with the shipment by a minimum distance of 300 feet and no more than 700 feet. Rear escort vehicles or chase vehicles must follow the shipment at a close, safe distance that identifies it as part of the escorted shipment. Convoys are not permitted unless specifically authorized by the Minnesota state DOT.   2. Peace officer escorts: A peace officer escort is a Minnesota state-licensed peace officer using a state-authorized emergency vehicle displaying red and/or blue lights. A peace officer escort is the only type of escort permitted that has the ability to require on-coming traffic to yield to the right of way whenever an oncoming wide load encroaches over a 2 lane road center-line. A peace officer escort or pilot car will be required whenever a loaded truck’s width extends over the roadway center-line and into on-coming traffic or whenever the loaded truck’s dimensions require the truck to travel in the wrong lane of the roadway. The Minnesota DOT has determined if extreme hazards exist a peace officer escort or pilot car is the most reasonable solution to maintain road safety for motorists. The carrier must arrange for peace officer escorts or pilot cars whenever they are required whether it is specified on the permit or not. Any time a shipment may potentially cross over the center line a peace officer escort or pilot car is required.

Recent Load Hauled in Minnesota

  • Freight: Cat D8N DOZER
  • Origin: Sumrall, MS 39482
  • Destination: Rochester, MN 14602
  • Specs: 20L x 13W x 11.30H
  • Weight: 85,000lbs

Call Us For a Free Shipping Estimate

(877) 792-5056
Oversize permit company MORE USEFUL RESOURCES  Minnesota Road Closures

5 Responses

  1. Hello there, I’m looking at purchasing a tri axle hopper bottom to haul soybeans and corn. Is that considered a unprocessed agriculture product? With a 7 axle setup curious on what I can legally haul

    1. Tri axle hopper bottoms are ideal for transporting bulk goods like grains and corn. Therefore, you can transport any loose agricultural products.

  2. Ever since Minnesota had the bridge fall, their permit issuing is slow, even for 6 & 7 axle traffic with minimal dimension.

Leave a Reply

Your email address will not be published. Required fields are marked *