Heavy haul and oversize trucking quotes from hundreds of trucking companies in one click. Permits.
Heavy Haul and Oversize Trucking Quotes. Post to our loadboard free. Permits and pilot cars.

Posts Tagged legal

State Certifications for Pilot Cars & Escort Vehicles.

2019 State Certifications for Pilot Cars & Escort Vehicles. Which states require pilot car certification?

Some states require pilot car and escort vehicle drivers to be certified operators before operating within their jurisdictions. If you are considering operating a oversize load truck escorting service you will be required to have certain “certifications” in each of the following states. For details on each of the states requirements as of 2019 this is a great place to start your research.

Oversize load.

Typical oversize load that does not require a pilot car vehicle. However, shipments slightly wider may required a pilot car in some locations.

Arizona – Colorado – Florida – Georgia – Louisiana – Minnesota – Nevada – New Mexico – New York – Oklahoma – Virginia – Washington

The American Association of State Highway Transportation Officials (AASTO) in conjunction with the United States Department of Transportation Federal Highway Administration released the National Manual on Uniform Traffic Control Devices,  specifically chapter 6(F) which applies to pilot cars and escort vehicles (also see; pilot car_and escort_best_practices_guidelines). Any escort vehicle or pilot car vehicle shall carry the following equipment items at all times when escorting a over dimensional, heavy haul or otherwise extra-legal shipment.

1. One two-way electronic communication device which enables the pilot car or escort to communicate directly with the driver of the extralegal shipment.
2. One 105 pound fire extinguisher or to 5 pound fire extinguishers.
3. One stop go paddle sign reflective for night movement no less than 18 inches across or tall with letters no less than 6 inches in height.
4. One night reflective safety orange vest shirt or jacket.
5. One handheld red flag no less than 18 inches square.
6. To oversize load banners that are yellow with black lettering (no minimum size specified. See below or state laws for state(s) working in.
7. One hardhat.
8. Three reflective triangles or 18 inch traffic cones.


We do strongly suggest any individual or company operating as a pilot car or escort vehicle be outfitted with the minimum requirements. For your convenience see the list below, or you may visit our pages on “Starting a new pilot car company“.

The basics:

  • 1 professional mileage book with room for notations and 1 journal book. Keep good logs and summary daily.
  • 5 – 36″ orange road cones with two strips of safety reflective tape at the top.
  • 5 – 12″ orange road cones (day use) with at least one safety reflective strip at top just in case (night use).
  • 1 – safety colored yellow or orange reflective safety jacket and 2 reflective safety vests.
  • 8 roadside reflective triangles no less than 16″ tall.
  • 1 dozen up to date flammable safety road flares. Write expire date in your journal book for later reference.
  • 4 red safety colored flags no less than 18″ square on 1/2″ wooden dowels.
  • 2 yellow signs reading “Oversize Load” no less than 12″ tall x 5′ wide with lettering 10″ tall and 1 5/8″ thick.
  • 1 – 2-way radio. We suggest a high quality CB radio with very high quality antenna.
  • 2 fire extinguishers. 1 – 2.5 lb and 1 – 5 lb dry chemical type or higher rating.
  • 1 safety colored red or fluorescent hard hat with reflective safety tape.
  • 1 very good all inclusive first aid kit. The more you spend the better. Familiarize yourself with everything.
  • Stop/Slow safety paddle sign no less that 24″ the same shape as a stop sign with a 5′ handle.
  • 2 flashlights that run on a minimum of 2 DC batteries with extra batteries.
  • 1 heavy duty set of jumper cables. The best pair you can buy.
  • 1 jump box with charge meter indicating level of charge. A jump box is an external battery used for starting vehicles.
  • Chains for all 4 wheels of your vehicle for snow covered passes or iced roads.
  • 2 two way radios fully charged with 2 fully charged batteries.
  • 1 GPS with good up to date quality mapping software that allows you to create way-points and also a good USA road atlas.

If you approach a state such as Louisiana, New Mexico or Utah which require pilot cars to stop and pay for a inspection at the port or entry (prior to leading or chasing a load) and you don’t have the minimum tools listed above, wave goodbye to your money and the permit as you’ll be denied and rightly so.  A pilot cars primary duty is to ensure the safety of the motorists. If you don’t have the basic tools required then you’re not deemed safe to operate in the capacity of a pilot car.  Below we will cover the specific details required by pilot car companies in order to become certified in the states that have certification requirements.

Details of State Certifications required for Pilot Cars. Which states require pilot car certification?

Oversize firetruck being shipped.

Firetruck being shipped with signs and flags.

If you are researching and looking for a list of the states that require specific pilot car certifications you have found it.  Below is the list of each state requiring special certification for pilot cars and escort vehicles as well as some details about the type of certifications that are required, where to obtain them, fees, etc. Please feel free to add any comments to share with others at the bottom of this page.

    1. Arizona.

      The state of Arizona does not observe daylight savings time. Arizona pilot car certification: the state of Arizona says that pilot car companies or escort vehicles must maintain a certificate of certification that verifies the pilot car and operator successfully completed a Commercial Vehicle Safety Alliance (CVSA) program. Arizona does recognize equivalency programs completed in other states however the pilot car or escort vehicle operator must file an application in order to operate within Arizona State jurisdictions. For more information contact the Arizona motor vehicles division at phone number: 602-771-2960 located at 1225 N. 25th Ave., Phoenix, AR 85009. Office hours are from 8 AM until 5 PM mountain time Monday through Friday. You can read more about the Arizona pilot car regulations, requirements, permits, etc. on our regulations pages.

    2. Colorado.

      The state of Colorado requires that pilot car or escort company operators have a Colorado State Certification card when working with in the Colorado state jurisdiction. Colorado does recognize certificates received from other states such as Florida, Oklahoma, Washington or Utah as well as the SC&RA. If you do not have any other state certificate endorsements you may contact RSA Network, Inc. by phone at: 801–838–8199 to inquire about testing for your Colorado State Certification. For more information about Colorado regulations, requirements, permits, etc. visit our regulations pages.

    3. Florida.

      The state of Florida requires that pilot car or escort companies operators have to have Florida State certification or FDOT authorization. The state of Florida does recognize programs completed bike pilot car drivers from the following states: Arizona, Colorado, Georgia, Minnesota, North Carolina, Oklahoma, Virginia, Washington and Wisconsin. In order to legally operate in the capacity of a pilot car or escort vehicle driver/company, you must obtain a certificate of completion by the Florida Department of Transportation pilot/escort training class. This class is offered by the Florida technology transfer Center. Inquiries by phone: 352-392-2371 or e-mail: 12assist@ce.ufl.edu. One portion of the Florida State Law requires successful completion of a National Safety Council 8 hour defensive driving course qualified by the state of Florida (or equivalent) by one of the above listed states as the same. So if you have already completed a similar course your credit may be transferable. Re-qualification is required every 4 years and this can also be done by contacting the University of Florida, PO Box 116587  Gainesville, FL  32611-6587.  You can read more about the Florida pilot car regulations, requirements, permits, etc. on our regulations pages.

    4. Georgia.

      The state of Georgia Department of Transportation (GDOT) requires pilot car or escort company operators to complete the Certified Escort Vehicle Program. In addition to this you are required to have a “amber light permit” when operating a pilot car or escort vehicle within Georgia state lines. If you obtain a “amber light permit” AND have completed a pilot car and/or escort vehicle certification program through any of the following states: Colorado, Washington, Oregon, Utah or Arizona you will more than likely be approved with proof of completion. The Georgia DOT also reciprocates directly with North Carolina, Florida and Oklahoma pilot car certification programs. If you have any questions for the Georgia Oversize Permit Unit you may contact them directly by phone: 888-262-8306.  You can also read more about the Georgia state pilot car regulations, requirements, permits, etc. on our regulations pages.

    5. Louisiana.

      All escort and pilot car operators who wish to travel through or work in the state of Louisiana are required to obtain a Louisiana Approved Escort Vehicle Permit. Escort vehicle operators and pilot car company operators can obtain a Louisiana state escort vehicle permit at Louisiana weigh stations. These permits can also be obtained online at www.dotd.la.gov. Look for the quick links section on the right-hand side of the webpage and click on truck permits. Once you’ve reached the permitting electronic routing bridge analysis selection then select submit application for annual permits and will get a list of annual permits on that page. The escort and pilot car vehicle permit portion will give you two options for submitting the application. You can submit it online or print the PDF form and fax the completed application to the truck permit office at: 225-377-7154. Any questions you may have pertaining to escort vehicle and/or pilot car driving permits and be addressed by calling: 800-654-1433 or 225-434-2345 and selecting option 1. You can also read more about the Lousiana state pilot car regulations, requirements, permits, etc. on our regulations pages.

    6. Minnesota.

      All escort vehicle and pilot car operators who wish to travel or work in the state of Minnesota are required to be certified. The good old state of Minnesota has two different types of escorts. Civilian escorts and peace officers. Learn the difference between the two. The state of Minnesota recognizes escort vehicle and pilot car operator certifications from the following states Colorado, Florida, North Carolina, Oklahoma, Utah and Washington state. Currently Minnesota requires drivers of pilot cars and escort vehicles to hold a current Minnesota State patrol certification. When working within this state all pilot car companies and escort vehicle operators must travel with a copy of their certification. If you are a escort vehicle or pilot car operator with certification already in the state of Colorado Florida North Carolina Oklahoma Utah or Washington you will be allowed to escort over dimensional loads within the state of Minnesota however you must have Minnesota insurance for the vehicle the driver the signage delighting and all safety equipment requirements must be met. For more information you can contact Erik Gohl at: 952-995-1346 fax: 952-995-1331 or visit their website: www.hennepintech.edu/cts/pages/1233 who is the pilot car and escort driver class administrator at Hennepin Technical College,  customized training services located at: 13100 College View Dr., Eden Prairie, MN 55347. You can also read more about the Minnesota state pilot car regulations, requirements and permits on our regulations page.

    7. Nevada.

      All pilot car operators and escort vehicles who wish to work in the state of Nevada must be certified and also obtain a amber light permit. At the time of this writing (May 16, 2018) the state of Nevada Department of Transportation does not have any particular specific certification program for pilot cars. However they do have in place a rather lengthy amber light law. We would strongly suggest that anyone considering escorting loads through the state of Nevada obtain certification in another state with stringent laws such as Colorado, Washington, Oregon, Utah, Arizona, North Carolina, Florida or Oklahoma. You will still need a amber light permit to operate a escort vehicle or pilot car with in Nevada state jurisdiction. The amber light law basically states that it is unlawful for any person to mount a flashing amber warning light on the top of the vehicle without a permit from the Nevada Highway Patrol. The Nevada Highway Patrol will issue a permit to mount amber flashing lights on a vehicle upon written request. We suggest that readers such as yourself read our regulations page for the state of Nevada in order to research amber light specs such as how many times it flashes per minute and the distance its visible from. In addition to the amber light law if you anticipate stopping or slowing traffic you must comply to the stringent laws of Nevada state flagman. If it is necessary to warrant approaching traffic, each flagman must be wearing a solid florescent yellow or green material jacket or vest and equipped with a red flag and paddle readings stop in white letters with a red background. The sign must be a standard 18 inch two-sided stop and slow sign and be attached to a 5 foot pole. For further clarification on other items required please see our regulations page for trucks pilot cars and escort vehicles operating within Nevada state jurisdiction.

    8. New Mexico.

      All pilot car and escort vehicle operators working with in the state of New Mexico need to be inspected at the port of entry for a New Mexico certification inspection. You are required to approach the port of entry before any load you may be escorting reaches any scale house upon entry. Once pilot car or escort vehicle operators pull into the New Mexico port of entry you are subject to inspection. The officer conducting the inspection will require you to have two amber lights, oversize escort signs, a two-way radio, fire extinguisher, to outside rear view mirrors, the condition of the tires, three red flares and or reflectors, oversize escort signs and to florescent orange or red flags 12 inch in size or larger as well as a safety jacket and/or vest with a hardhat. The vehicle requirements are a minimum of 100 inch wheelbase, vehicle maximum capacity of 1 1/2 tons, a valid current drivers license and the terms of your insurance policy. Basically, you can expect a full on roadside intensive and thorough review of your vehicle and its equipment. For specific clarifications on vehicle specifications escort vehicle and pilot car operators should refer to our New Mexico state regulations page.

    9. New York.

      All pilot car and escort vehicle operators who intend to work within the state of New York must be New York State certified. To be certified as a escort or pilot car driver it is mandatory for all drivers as well as any persons acting as a flag person who intend on escorting oversize loads on the roads and highways within the state of New York regardless of where they reside obtain New York state certification. From the best of our knowledge no previous certification programs you may have completed will be accepted, credited or otherwise considered. For a list of New York Department of motor vehicle testing locations call 518-486-9748. For more information on getting certified or obtaining the New York certification manual you can call 418-457-1155 or 800-783-1685. We suggest also reading our New York state pilot car regulations, requirements, permits, etc. on our regulations pages.

    10. Oklahoma.

      All escort vehicles and pilot car operators who intend on working within the state of Oklahoma must be Oklahoma certified. The state of Oklahoma Department of Public Safety does recognize certifications and other states that do have a reciprocal agreement with the state of Oklahoma however if the operator of the pilot car or escort vehicle is a Oklahoma State resident they must have Oklahoma certification. The first order of business when operating a pilot car or escort vehicle within the state of Oklahoma is the certificate of insurance. Escort vehicle and pilot car vehicle operators must provide not less than $1 million of combined single limit or per occurrence or both of commercial liability coverage. Your insurance policy must protect the public against loss of life, bodily injury to persons and damage to property or bowls as a result of operating a escort vehicle or pilot car, or of the actions of the escort or pilot car vehicle operator or both. The state of Oklahoma will need to be listed as a certificate holder on your insurance certificate. In order to obtain your certificate from the department of public safety you will be required to take the course and the examination offered by the Oklahoma State University, phone 405-744-6049. The term of this certificate shall be for a maximum period of five years and will expire automatically after the date it was issued you can obtain more information on the certification training program by visiting: www.clgtokstate.com/escort.htm  or for more information about pilot car and  escort vehicle specifications please visit our Oklahoma state regulations page.

    11. Utah.

      All pilot car operators and escort vehicle drivers who intend on operating within the state of Utah must be certified and inspected at the Utah Port of Entry. Pilot car and escort vehicle operators who wish to obtain a authorized certification card may do so by participating in a authorized qualified certification program. A list of authorized instructors can be obtained by calling 801-965-4892. Pilot car and escort company drivers that live outside of Utah may operate as a certified pilot car or escort driver with another State certification credentials provided that the course meets the minimum requirements outlined in the Utah pilot car and escort vehicle training manual the department may decide to enter into a reciprocal agreement with other states provided these other states can demonstrate that their course materials are comprehensive and meet the minimum requirements outlined by the Utah Department of Transportation. Such agreements already exist with the Utah Department of Transportation recognizing the states of Washington, North Carolina, Colorado, Oklahoma and the state of Florida. Any pilot car or escort driver certifications expires four years from the date the certificate was issued and it is is the responsibility of the driver to maintain current certification as well as a minimum amount of insurance coverage of $750,000 for liability insurance.Upon entering the jurisdiction within the state of Utah it is strongly advised that you have a certificate of completion that is valid and current with any of the above mentioned states. You are required to stop at the port of entry when entering Utah state jurisdiction. For more detailed information about Utah state pilot car and escort vehicle requirements please visit our regulations page.

    12. Virginia.

      The state of Virginia does require that all pilot car and escort vehicle operators be certified prior to performing the duties of a oversize or overweight load pilot or escort vehicle operator within the Virginia state jurisdiction. The state or Virginia Department of Motor Vehicles (DMV) does recognize certification programs completed by applicants from the following states: Florida, Georgia, Minnesota, North Carolina, Oklahoma, Utah and Washington however you must still apply for escort/pilot car operator certification from the Virginia DMV. It is important for pilot car and escort vehicle operators to be aware they are required to carry their certification document from the state of Virginia with them while escorting any type of oversize or overweight vehicle configurations. You must have a valid drivers license as well. If you are requested by law enforcement or the Department of Transportation enforcement officials you must provide them with certificate program completion documentation. Failure to do so while escorting or piloting in oversize configuration will cause the shipment to be delayed until the appropriate documents are in place or another company with documentation replaces you. For more detailed information about Virginia state pilot car and escort vehicle requirements please visit our regulations page.

    13. Washington.

      And finally last but not the least of our 2018 State Certifications for Pilot Cars & Escort Vehicles update is the state of Washington. The state of Washington Department of Transportation does require pilot car and escort vehicle operators to be certified by them. They recognize programs and certificates from the states of Utah, Florida, North Carolina, Oklahoma and Colorado however pilot car and escort vehicle operators who desire to operate withing the state of Washington’s jurisdiction must be issued a official Washington state certificate. You can contact pilot/escort, flagging instructor Michael Blackman at: 509-684-7632 or contact the Washington state Pilot Escort official Jim Wright at: 360-704-6345 or you may visit the official state information page at: www.wsdot.wa.gov/commercialvehicle/ If you would like more detailed information about Washington state regulations, requirements, permits, etc visit our regulations page.

pilot_car_required

Pilot cars or escort vehicles will be required to move a shipment of this size. Some states may require special certification.

State requirements for pilot cars and escort vehicles change from time to time.

It should be noted that state requirements for pilot cars and escort vehicles do change from time to time. The purpose of this page is to provide you with updated information that includes the rules and regulations of the states that do require pilot car drivers and escort vehicle drivers to have special certifications. It should be noted this page was written as a basic guide for pilot car companies and escort vehicle operators to use when researching which states do require certification. We strongly suggest if you are considering operating and any state under the capacity of a pilot car or escort that each state you intend on working in be contacted directly by you before entering that state. Also, in addition to state certifications and requirements always refer to the instructions on the actual permit issued from the state for that particular over dimensional or heavy haul load. The permit should list all responsibilities and detail as well as clarify any additional questions you may have during transit. In closing, remember as a escort vehicle driver or pilot car operator your number one job is public safety.

 

Other interesting information pertaining to pilot cars:

  • Illinois State Shipping Regulations for oversize and heavy haul.
    Illinois State Shipping Regulations for oversize and heavy haul.
    Shipping laws, regulations, limitations and rules for shipping oversize and over-weight loads over the roads and highways in the state of Illinois. Please share your expertise or knowledge of Illinois state shipping regulations with other visitors below. Trucking and pilot car location system: Locate trucking...
  • 2019 Georgia State Shipping Regulations
    2019 Georgia State Shipping Regulations
    2019 Georgia state DOT shipping laws, regulations, rules, limitations, for oversize and heavy-haul trucking permits.  Heavy-haul trucking and pilot cars. Locate oversize, heavy-haul trucking companies and pilot cars. Georgia pilot cars and truck escorts for hire. Georgia oversize and heavy-haul trucking companies for hire. Georgia...
  • pilot car truck equipped with a height pole.
    What is a height pole?
    WHAT IS A HEIGHT POLE OR HI-POLE? A height pole or high pole or hi-pole is a measuring device that is precisely attached to the front of a pilot car vehicle that is used to measure the height of overhead obstructions during the transport of...
  • How to start a pilot car company.
    How to start a pilot car company.
    How to realistically start a pilot car company. A-Z, current 2019. Put together by industry professionals in the industry for 30+ years. If you want to learn what you need to succeed this package is a must!

     

Alberta DOT Shipping Regulations

Province of Alberta DOT shipping regulations, limitations, rules and laws for the trucking of oversize and over weight loads over the roads and highways in the Province of Alberta.

Alberta Canada oversize and overweight shipping regulations.

Alberta Canada official coat of arms.

 Please share your expertise or knowledge with our other visitors below.

Trucking & pilot car directory.

Locate trucking companies and pilot car companies in Alberta:

Alberta trucking company directory.
Live pilot cars in Alberta.



Legal load limits.

Alberta DOT legal load limits:

Length: The overall maximum length allowed in Alberta without a permit is 23 meters (75′ 3″).
Width: The maximum width allowed is 2.6 meters (8′ 6″‘).
Height: The maximum height allowed in Alberta is 4.15 meters 13′ 7″.
Weight: 6,000 kg maximum on steer axle. Tandem axles: 17,000 kg. Tridum axels is 17,000 kilograms (37,478.6 lbs) as well. All axle weights are subject to the size of the tire.
Overhang: We have no information on allowable overhang in Alberta. Please share your knowledge with others below.
Notes:

* Super single tires require “New Generation, Wide Base” tires with a minimum tire width of 445 mm. Available by permit only. Super single tires do not apply to the steering axle.
** These weights for tridem axles apply to provincial highways only. The maximum weight for a tridem axle on a municipal road is 17,000 kg. Permits may be available to achieve heavier weights.
*** All axle weights are subject to minimum tire size. The maximum weight per tire shall not exceed the lesser of the tire manufacturer’s weight rating or the width of the tire stamped on the sidewall multiplied by 10 kg/mm.
Source: Alberta Transportation

Routine trucking permits.

Oversize and overweight trucking permits that are routinely issued by the Alberta DOT:

Length: 52 meters (170′ 8″) is about the maximum length you can get by with on a routine permit.
Width: 14′ 7″ wide depending on routing  for routine trucking permits.
Height: 5.3 meters (17′ 5″) in height is the cut off point for routine permits of course contingent on routing.
Weight: Weight is where you run into a problem. Alberta wants to know every single detail down to the size of tire you are running. Routing being a huge issue we can’t state a “routine” weight as it all depends on your axle spacings, combinations and tire sizes. Just for a safe number we’re going to say a routine permit caps out at 43,359.2 kilograms (100,000 lbs).
Overhang: 6.09 meters is about the most you can get on routine depending on routing.

Superload information.

Alberta superload information:

The maximum width normally allowed is 7.32 meters (24′) so anything over this width is a superload. We are researching information pertaining to shipping superloads in the province of Alberta Canada. If you happen to have expertise or knowledge of trucking superloads in this province please share your information for our other viewers below. Thank you.

Permitted travel times & restrictions.

Alberta DOT travel times and restrictions for oversize and overweight trucking:

The rule of 1/2 hour before sunrise until one full hour after sunset is observed in Alberta. Travel is allowed on Fridays until 3pm in the afternoon for loads that exceed 3.85 meters in width (12′ 7″) (WE WILL NEED TO DOUBLE CHECK THIS AS IT WAS LEFT AS A CORRECTION COMMENT BELOW). Travel is otherwise allowed and unrestricted on Saturdays unless stated on your permit.  Night travel is permitted for loads that are over length as long as you have 1 rear pilot car/escort vehicle and are on multiple lane roads. If your shipment is no longer than of 42 meters (137′ 10″) on a single lane road you will be required to have1 front pilot car/escort vehicle and 1 rear pilot car/escort vehicle. Weekend travel is permitted for loads that are over length only. If your shipment is in excess of 4.45 meters (14′ 7″) in width you will be permitted to travel only during daylight hours. If over 3.85 meters (12′ 7″) in width you may not travel on Sundays. There is not travel permitted on the following holidays: New Years day, Provincial day, Good Friday, Victoria day, Canada day, Family day, Labour day, Thanksgiving day, Remembrance day, Christmas day and on Boxing day.

Adverse weather conditions: If adverse weather conditions are reported you may not proceed with your shipment and are required to remain where ever you are. If adverse weather conditions interrupt your shipment you are required to pull over at the nearest suitable location even if it is on the side of the road unless you are over width. Over width loads must continue until they are able to completely turn off of the road and remain until adverse weather conditions stop. If your shipment is over 4.45 meters (14′ 7″) in width or 5.32 meters (17′ 5″) in height you are not permitted to travel with snow or fog visibility less than 150 meters (492′), if the road is covered with snow or ice or sleet or any other conditions that may effect the driver from proceeding with the absolute safety in mind first and foremost.

Frost laws: Alberta does have frost laws but when they are in effect changes every year based on testing with a heat flow model that measures to 30 cm below the surface. So, if you are shipping during the spring months you will need to call the number below for the exact frost law restriction dates. There are exemptions which include milk and bread trucks, farm machinery, water, fuel, fertilizer, mail and buses.

When pilot cars are required.

If your shipment is in excess of any of the following you will be required to have a pilot car escort you:

Length: If your shipment is in excess of 34 meters (111′) in overall length you are required to have 1 rear pilot car on single lane roads. For shipments in excess of 38 meters (124′ 8″) you are required to have 1 front pilot car/escort and 1 rear pilot car/escort.
Width: If your shipment is in excess of 3.85 meters (12′ 7″) wide you are required to have 1 front pilot car/escort on a single lane road or one rear pilot car/escort on multiple lane roads. For shipments over 4.45 meters (14′ 7″) wide require 1 front pilot car/escort and 1 rear pilot car/escort on single lane roads. If your shipment is in excess of 5.5 meters (18′) you are required to have 1 front and 1 rear pilot car/escort vehicle on all roads.
Height: Alberta does not normally use pilot cars with high poles as they have designated routes for shipments that are over height. You can view the routes on the Alberta DOT high load corridor page located here.
Weight: As long as your shipment can maintain the minimum required speed limit you will probably not be required to have a pilot car/escort by the Alberta DOT.
Overhang: If you have overhang that is over 6.5 meters (21′ 4″) you will be required to have 1 rear pilot car/escort vehicle. If your shipment overhang is in excess of 9 meters (29′ 6″) you will be required to have 1 front and 1 rear pilot car/escort vehicle.

Pilot car requirements.

Pilot car (escort vehicle) requirements for operating in Alberta province are as follows:

Pilot car/escort vehicle operators are NOT required to take any sort of DOT certification course in order to operate in Canada. Your vehicle is required however to have a lighted sign box that is a minimum of 180 cm x 35 cm x 10 cm (72″ x 14″ x 4″), 2 – 175 mm (7″) diameter flashing lights mounted on the top of the sign box on each side with 2 amber strobing or rotating lights a minimum of 203 mm (8″) mounted between the flashing lights on top of the box as well. The sign box must light up and be visible from a minimum distance of 200 meters (656′). The sign box must have either a red and white D sign or a yellow with black lettering stating “OVERSIZE LOAD”, “WIDE LOAD”,  OR “LONG LOAD”. If you have the “D” sign your letter must be no less than 20 cm (8″) in height with a 4 cm (1 5/8″) line thickness. If you have the yellow sign your lettering must be no less than 20 cm (8″) with a 4 cm (1 5/8″) line thickness. The sign box must be mounted on the top of the vehicle and covered when not in operation. You are also expected to have the following items inside of the vehicle: CB radio or high powered 2-way radio, first aid kit, fire extinguisher type A, B & C of at least a 2 liters, 3 reflective road triangles, 3 traffic cones, reflective vest (worn while working), slow/stop sign, 3 red or orange safety colored flags no less than 40 x 40 cm (16″ x 16″), nose cone flashlight and a hard hat.

Shipment, truck & trailer markings.

Truck, trailer and shipment required signs, banners and flags:

All trucks that are hauling oversize or overweight loads must have a strobing, flashing or rotating amber light mounted to the roof that is visible from 360 degrees at a minimum distance of 200 meters (656′). All 4 outermost corners corners of the overall shipment and any obtrusive points must have flags mounted to them that are safety red or orange in color no less than 40 cm x 40 cm (16″ x 16″) and have the flags exchanged for lighting if moving during the night. A sign stating the nature of the load; “OVERSIZE LOAD”, “WIDE LOAD” or “LONG LOAD” must be mounted to the front and rear of the overall shipment. Signs must be a minimum of 12′ in height and 6′ in width with a yellow background and black letting with lettering thickness no less than 4 cm (1 5/8″) thick.

Alberta DOT and other information.

Alberta DOT contact  and other information:

Alberta DOT & Central Permit Office
Telephone help line: 403-342-7138 toll free (all of North America): 800-662-7138
Fax: 403-340-5278
Road ban information: Current road bans. Toll free (all of North America): 855-762-3226
6 AM until 12 Midnight Monday – Friday
7 Am until 10 PM on weekends and holidays – MOUNTAIN TIME ZONE

Alberta current road restrictions from construction maintenance and spring thaw law. Excellent resource!
Alberta Canada truck driver hours of service.
Alberta Canada road and weather conditions.
Alberta DOT permit office website.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Alberta Province DOT Permits office before commencing movement.


 

2019 Vermont State Shipping Regulations

2019 Vermont state shipping laws, regulations, rules and limitations for oversize and overweight trucking on state highways and roads.

Vermont State seal.

The Great state of Vermont official seal.

Please share your expertise of Vermont state DOT trucking regulations with other visitors below.

Vermont oversize permits, heavy-haul trucking companies and pilot cars.

Locate Vermont oversize, heavy-haul trucking companies and pilot cars:

Vermont pilot car drivers and truck escorts for hire.
Vermont oversize and heavy-haul trucking companies for hire.
Vermont oversize and heavy haul trucking permits.

Do I need a trucking permit? Legal load limits.

Vermont maximum load limits until a trucking permit is required:

Length: Trailer length maximum is 53 feet.
Width: 8 feet and 6 inches wide.
Height: 13 feet and 6 inches tall.
Weight: 80,000 pounds gross (GVW), 20,000 single axles or 34,000 pounds on tandem axles.
Overhang: Overhang in the rear may not exceed 1/3 of the item being shipped length.

Routine heavy haul and oversize trucking permits in Vermont.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Vermont:

Length: 100 feet in overall length.
Width: 15 feet wide.
Height: 15 feet is about the most you can get away with on routine permits and main roads.  14 feet on many local roads.
Weight:  Under 150,000 pounds over all in weight.  Anything over 150,000 pounds in weight will require an individual study.  They will need all steer tandem, tridem, quadem axle length spacing and weights data with routing ideas submitted.  Here is a road weight limit search tool.  Also crane routes.
Overhang: If you are over the 1/3 mark on your over all length you are going to have trouble.

Pilot cars/escort vehicle certifications and requirements in Vermont (more).

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements (more):

One half hour before sunset and one half hour after sunset rule applies.  You may travel on the weekend and holidays however some restrictions do apply.  If over 100′ in length, 10′ 6″ in width or 108,000 lbs in weight,  you may NOT travel on Saturday or Sunday or on holidays if between July 1 and Labor day on state roads.   If a holiday is on a weekend day then you many NOT travel on Friday of Monday as well.  The state of Vermont observes the following holidays:  New Years day, Memorial day, Columbus day, Martin Luther King day, Independence day, Veterans day, Labor day, Thanksgiving day, Christmas day and Presidents day.  The state permit office is closed on these days as well.  If a shipment is over length, over width or over height it may only travel during day light hours.  Over weight shipments may travel 24 hours a day.  There are travel restriction times during peak hours in high traffic areas being closed from the approximate hours between 7-9 am and 2-5 pm as well.  Please refer to your permit for exact travel restrictions and times.

Legal travel times for oversize and heavy haul loads in Vermont.

Vermont travel times and restrictions for heavy-haul and oversize loads:

Length: 80′ in length.
Width: 12′ wide requires at least 1 rear pilot car on 4 lane or front on 2 lane roads (escort) and possibly 2 depending on routing.
Height: If height of load exceeds 14′ a front high pole card is required.
Weight: No pilot cars of escort vehicles are mentioned in re; to overweight or heavy haul shipments.
Overhang: If front over hang is over 15′.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

For a vehicle to qualify; all pilot car/escort vehicles must have a manufacturers gross weight rating not to exceed over over 20,000 pounds. All pilot cars/escort vehicles must display a bumper or roof mounted “OVERSIZE LOAD” sign visible from both the front and rear of the vehicle.  Sign must be at least 6 feet long and 12 inches in height, yellow in color with black letters no less than 5 inches tall and 1 inch in width. Vehicle must have 4 safety flags displayed in red or orange in color and be a minimum of 12 inches in length quare and/or height mounted at a 40 to 70 degree angle on all 4 corners of the vehicle.   Vehicle must be equipped with a  CB radio or 2-way communication device, 8 ignitable road flares and have a first-aid kit. All pilot cars/escort vehicles must be at least of a “reasonable” size.  All pilot cars (escort vehicles) must have  a CB radio or 2-way communication device and be in contact with their shipment at ALL times.  Pilot cars vehicles that are leading must have an appropriate sign visible from the front and when chasing must have an appropriate sign visible from the rear.   All signs must be a minimum of 5′ in length and 12″ in height and have a yellow background with black letting of no less than 1″ 5/8″ in width.  Headlights must be turned on when in operation on the job.

It is our opinion that pilot cars (escort vehicles) should have the minimum requirements as well which include the following;

  • 1 – 5 pound fire extinguishers type A, B and C.
  • A paddle sign with the word “STOP” on one side and “SLOW” on the other with dimensions of no less than 18″ in diameter with a minimum of 6″ letters.
  • A red safety colored flag with handle no less than 18″ square.
  • 3 reflective emergency road triangles or 18″ traffic cones.
  • At least 1 extra OVERSIZE LOAD and  WIDELOAD banners (yellow with black lettering).
  • A safety colored (red, orange, yellow or lime green) vest, jacket or shirt (used while directing traffic).

Vermont DOT office and permit contact information.

Vermont DOT contact information and notes:
Vermont Agency of Transportation Commercial Vehicle Operation.
120 State Street
Montplier, VT  05603
Help telephone line: 802-828-2064
Hours: Monday – Friday 7:45 AM – 4:30 PM
Eastern Time Zone
Vermont is a member of NASHTO

Vermont State DOT Website for oversize and over-weight hauling permit rules. Permit application.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Vermont State DOT Permits office before commencing movement.

Vermont and other cool stuff.

2019 Arizona State Shipping Regulations

2019 Arizona state shipping laws, regulations, rules and limitations for oversize and overweight trucking on state highways and roads.

Arizona

The great state of Arizona official seal.

Please share your expertise of Arizona state DOT trucking regulations with other visitors below.

As per the state of Arizona please read the following:

“The Arizona Department of Transportation in cooperation with state representatives, industry, the Department of Public Safety  and local law enforcement personnel work in collaboration to update and amend oversize and overweight special permit rules containing special permit requirements, restrictions and allowances for transporting oversize and overweight vehicles and loads on highways under the jurisdiction of the Department. This is a council established in statute and makes up the Over-dimensional Permit Council.

These rules detail the eligibility, application and use requirements for a variety of permits the Department currently issues to commercial motor carriers for transporting vehicles or vehicle and load combinations exceeding the maximum size or weight limitations provided by statute.

Each special permit provided by the Department under these rules is specifically authorized by statute.  The oversize and overweight special permits issued under these rules are that each permittee issued a particular class of permit is subject to the same activities, practices, requirements and restrictions applicable to that permit type. The statutes additionally provide authority for issuance, conditions, restrictions, approvals and fees.”


Arizona oversize permits, heavy-haul trucking companies and pilot cars.

Locate oversize, heavy-haul trucking companies and pilot cars:

Arizona pilot cars and truck escorts for hire.
Arizona oversize and heavy-haul trucking companies for hire.
Arizona oversize and heavy-haul trucking permits.

Do I need a trucking permit? Legal load limits.

Arizona maximum load limits until a trucking permit is required:

Length: Anything over 65 feet in length overall requires a permit on non-designated highways.
Overhang: 3 feet in the front and 6 feet off of the rear of trailer maximum (make sure your route is approved for overhang as there are location variations).
Weight: 80,000 pounds overall (GVW), 12,000 pounds on steer axle.
Width: 8 feet and 6 inches wide maximum.
Height: 14 feet maximum on interstates and 13 feet and 6 inches in height on secondary roads.

Routine heavy haul and oversize trucking permits in Arizona.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Arizona:

Length: 120 feet maximum or proceed to super load section.
Weight: 250,000 pounds maximum (Class C if over or see superloads). Single axle is 28,000 pounds maximum. All tandem, tridum, trunnion and quadem axle configurations depend on axle spacings and tire sizes. Gross weight maximums: 5 axles is 104,000 pounds, 6 axles is 108,000 pounds, 7 axles is 117,000 pounds. The permissible maximum weights depend on the number of tires combined with the overall distance between each of the axles. Spacings on axles are a little bit tricky in this state. The Arizona DOT permits office will consider a number or factors but it’s primarily about the bridges which could require a route survey if extreme weights are involved. If weights are excessive and trailer capabilities are even close to short of maxing out, forget it! Pavement, structural and stress testing results will govern your overall permissible capabilities.
Width: 14 feet wide maximum or file under super load.
Height: 16 tall maximum or file under super load.
Overhang:  3 feet of front or 6 feet off of the rear or any configuration that is in excess of 75 feet. They could require you to use a stretch trailer before allowing you to proceed under super load provisions.
Notes: These above routinely permitted shipments will need to be filed as class “A” permits. Class A permits are anything under 120 feet in length, 14 feet in width, 16 feet in height or under 250,000 pounds overall. Maximum speed is set at 55 mph for all oversize/overweight shipments.

Super load information for Arizona.

Arizona state DOT will classify your shipment as a super load if you are in excess of any of the following:

If a shipment exceeds any of the following it is classified as a superload and will require a class C permit. Class C permits are “super load permits”. If any shipment is in excess of 120 feet in length or 14 feet in width or 16 feet in height or 250,000 pounds in weight it is classified as a super load.
Notes: For mobile home shipments and more class C permit information expand the file just below.

Arizona class C permits.

Lights, safety flags and warning signs for heavy haul and oversize loads.

Required safety markings, safety flags, warning lights for heavy haul and oversize loads:

If shipment is over 102″ in width it must be flagged on the 4 outtermost corners of the entire combined shipment. Flags must be red in color and be not less than 12″ in either direction. Proper “OVERSIZE LOAD” or “WIDELOAD” banner/sign bust be displayed on both the upper most front of overall shipment (front of truck) no less than 5′ from the pavement line. Banner/sign must be no less than 6′ in length and 12′ in height with reasonable and size letting thickness and height. If you are seeking or awarded night movement reflective or illuminated banners/signs are required.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanies by a escort vehicle or pilot car if:

Length: On 2 Lanes:Over 120’ requires 1 pilot car in front of truck and 1 rear of truck.
Width: On 2 lanes over 14’ requires 1 pilot car or escort vehicle in front of truck and 1 the rear of truck. On Interstates over 15’ wide you are required to have 1 pilot car in front of truck.
Height: Over 17 feet requires 1 pilot car equipped with a height pole in front of truck.
On Interstates: Over 120’ requires 1 pilot car in front of truck.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

For a vehicle to qualify; all pilot car/escort vehicles must have a manufacturers gross weight rating not to exceed over over 20,000 pounds. All pilot cars/escort vehicles must display a bumper or roof mounted “OVERSIZE LOAD” sign visible from both the front and rear of the vehicle.  Sign must be at least 6 feet long and 12 inches in height, yellow in color with black letters no less than 5 inches tall and 1 inch in width. Vehicle must have 4 safety flags displayed in red or orange in color and be a minimum of 12 inches in length quare and/or height mounted at a 40 to 70 degree angle on all 4 corners of the vehicle.   Vehicle must be equipped with a  CB radio or 2-way communication device, 8 ignitable road flares and have a first-aid kit.

Legal travel times for oversize and heavy haul loads in Arizona.

Travel times and restrictions for heavy-haul and oversize loads:

The one half hour before sunrise to one half hour after sunset rule applies.  Travel on weekends and holidays is permitted. Night time travel applies to any shipment that does not exceed 120 feet in length or 16 feet wide or 16 feet tall or less than 250,000 pounds. If your are empty but over weight you’ll be allowed to travel continuously more than likely. If overweight only you will probably be allowed continuous travel. Under 10 feet of overhang, 10 feet in width or 14 feet in height will more than likely be granted continuous travel. Some loads will NOT be granted travel on weekends. Always refer to the documentation on your permit to verify travel times.

Arizona DOT office and permit contact information:

Arizona DOT contact information and notes:

Arizona Motor Vehicle Division (ADOT)
1225 N 25th Avenue
Phoenix, AZ 85009
Telephone: 602-771-2960
Office hours: 8 AM until 5PM Monday – Friday.
Arizona observes Mountain Time.
Website:
 Arizona DOT permits.
Notes: For class C permits: 602-712-8176 or 8280. All laws, regulations, rules and limitations are now set fourth in: Arizona transportation-permit laws.

Arizona cities serviced.

Additional info.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Arizona State DOT Permits office before commencing movement.
Arizona state flag. Arizona DOT oversize and overweight trucking regulations.

Arizona state flag.

Maximum legal load sizes.

What are the maximum legal load sizes of a shipment before it’s classified as oversize or over weight?

Maximum legal dimensions/weights.

Google maximum dimensions

Maximum dimensions and weights for transport.

  • Length: Combined overall is 65 feet or 19.812 meters.
  • Trailer length: 48 feet or 14.6304 meters. Some 53 feet or 16.1544 meters.
  • Width: 8 feet and 6 inches or 2.5908 meters.
  • Height: 13 feet and 6 inches or 4.1148 meters*.
  • Weight: Combined overall is 80,000 pounds or 36287.39 kilograms.
  • Shipment weight: 47,000 pounds or 21318.841 kilograms at most.

*Note: For US states maximum height varies. East of Missouri river is 13 feet and 6 inches or 4.1148 meters and west of the Missouri river is 14 feet or 4.2672 meters. Alaska maximum height is 15 feet or 4.572 meters. This is only a rule of thumb and not exact. For example Oklahoma is 13′ 6″ or Colorado and Nebraska are 14′ 6″. Also some designated routes are approved for additional heights. Be sure to research any/all laws before attempting to ship oversize or heavy items. Shipping it legally can be tricky.

Google maximum weights

Maximum weight restrictions for trucking.

Learn more about oversize trucking and transport.

Each state or province has different regulations. The above is a North American average. Regulations for heavy haul and oversize trucking can be very complex once a shipment has been determined “heavy” or “oversize” and there is a classification system within each state that can even qualify a shipment as a “super load”. Once dimensions or weights exceed the legal maximums transport permits are required. Some shipments may require pilot cars or even pilot cars equipped with height poles or the trucking company may be required to have a route survey performed. It’s important to consult a professional before attempting to transport any objects, machinery or equipment that is oversize or over weight.

 

Know the legal limits anytime you transport a load.

Whether you are a professional truck driver or a novice with a pick up truck it’s always smart to know the laws. Public safety a big factor to consider when transporting large or heavy items. Public property should also be factored in as damages could crush you financially. Fines and possibly getting your vehicle towed and impounded are other factors to consider. Always consult a professional as well as local laws when considering transporting over dimensional or over weight shipments.

 

 

Michigan State Shipping Regulations

2018 Michigan state DOT shipping laws, rules, regulations and limitations for oversize and heavy-haul trucking permits. Pilot car requirements.

Michigan

The great state of Michigan official seal.

Help others by sharing your knowledge of Michigan state regulations below.

Michigan oversize permits, heavy-haul trucking companies and pilot cars.

Locate oversize, heavy-haul trucking companies and pilot cars:

Michigan oversize, heavy-haul and pilot car companies for hire.
Michigan oversize and heavy-haul trucking companies for hire.
Michigan oversize and heavy-haul trucking permits.

Do I need a trucking permit? Legal load limits.

Michigan maximum load limits until a trucking permit is required:

Length: Overall no longer than 75 feet on designated highways.  Trailer length maximum is 50 feet on non-designated and 53 feet on designated.
Width:  96 inches on non designated highways and 102 inches (8 feet 6 inches.) on designated.
Height: 13 feet 6 inches tall.
Weight: 80,000 pounds GVW, 20,000 pounds on single axles (not steer), 34,000 pounds on tandem axles.
Overhang: 3 feet in the front and anything over 4 feet in the rear must be red flagged in the day and have a red light at night.
Notes: There’s no restriction on maximum length of combination of truck-tractor and semitrailer with or without load

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Michigan:

Length: Under 150 feet in length.  Anything over 150 feet is classified as a superload (105 feet maximum for mobile homes).
Width: Figure up to 16 feet as a routine permit.  Anything over is going to looked at seriously and they may even classify you as superload.
Height: Up to 15 feet is routine.  If you are over 15 feet high count on needing a route survey.
Weight:  All weights in excess of 80,000 pounds over all are decided on a case by case basis. Anything over 150,000 lbs is subject to a bridge weight study.
Overhang: Any shipment in excess of 4 feet of overhang is permitted on a case by case basis only.
Notes: Maximum speed for any permitted shipment is 45 MPH. Permits for heavy shipments may take more than 10 days to process.

Michigan superloads.

Information about shipping superloads in the state of Michigan.

If your shipment is in excess of any of the following weights or dimensions it may be classified as a superload.

Length: Anything over 150 feet.
Width: 16 feet or over.
Height: 15 feet and over is classified as a superload. Some limited routes may vary.
Notes: We have no weight maximums to report. Height may be on a case by case basis.

Lights, safety flags and warning signs for heavy haul and oversize loads.

Required safety markings, safety flags, warning lights for heavy haul and oversize loads:

All oversize load shipments will be required to display 2 “Oversize Load” signs. On must be mounted to the bumper of the truck and the other to the rear of the trailer. Signs must be a minimum of 7 feet in width and 18 inches in height with 10 inch black letters on a yellow background. Flags are required on all 4 corners of the combination and be safety red or orange in color and be 18 inches square. If the item being shipped has dimensions extending beyond the trailer then the extremities must be flagged as well. Headlights must be on at all times. A minimum of 2 flashing of strobing lights must be mounted to the rear portion of the load.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanies by a escort vehicle or pilot car if:

Length: 90 feet to 100 feet one on the rear. Over 100 feet requires a rear pilot car or “chase” escort vehicle.
Width: Loads over 12 wide on 4 lane is required one rear escort/pilot car. A lead or front pilot car is required for loads on 2 lane highway over 12 feet wide.  Front and rear pilot cars/escorts are required for loads over 14 feet wide.
Height: Over 14 feet and 5 inches is required to have a pilot car equipped with a height pole. Over 15 feet in height will require a rear chase escort vehicle in addition to 1 lead pilot car equipped with a height pole.
Overhang: If over 15 feet 1 rear escort is required.
Weight: If truck can maintain minimum speeds no pilot cars are required unless excessive or superload.
Note: Allow 1 to 10 days for permits to be approved. Distance for pilot car to lead/chase load 500′ unless otherwise stated on permit. This is the distance between lead/chase and the truck/trailer. Maximum speeds of 45 MPH if 4 or more lanes, 35 MPH is under 4 lanes. Also read travel restrictions below.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

In order to qualify as a pilot car vehicle in the state of Michigan you must either have a pickup truck or a passenger car with at least one rotating or flashing amber light mounted on the top of the vehicle. Pilot cars and escort vehicles must also display one oversize load sign that is 5′ x 1′ tall and have black letters no less than 8 inches tall on a yellow background. All flashing, stroking or rotating amber lights must be visible from a distance of no less than 500 feet. In addition to this we strongly suggest pilot cars and escort vehicles have the minimum of federally suggested equipment.

See: Pilot_Car_Escort_Best_Practices_Guidelines_508CLN

Legal travel times for oversize and heavy haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

Travel time is sunrise to sunset daylight only with the half hour before sunrise and a half hour after sunset leniency rule.  No weekend travel.  No holiday travel or the day after Christmas or Thanksgiving. They have rush hours rules from 7:00 AM to 9:00 AM and 3:00 PM to 6:00 PM in a whole list of counties (look on permit). Wind restrictions if over 24 MPH you can’t run. Frost and thaw laws in effect from Feb. until April on weight. You can view holiday restrictions.Lindemeyer, Transport, LLC.


Michigan DOT contact information, notes and resources.

Michigan DOT contact information:

Physical address:
Michigan Department of Transportation – DOT, Permits Unit
425 West Ottowa Street
Lansing, MI  48909
Email: click here for e-mail contact form on state website.
Telephone: 517-241-8999
Hours: Monday thru Friday 7:30 AM – 4:30 PM (closed from 12 until 1:00 PM)
Eastern Standard Time
Michigan is a member of MVCSHTO.

Very helpful documents:
Michigan Farmer’s Transportation Guide
Shipping mobile homes in Michigan
Michigan superloads – route surveys
Oversize-weight-permits-maximums
Michigan maximum dimensions

Michigan full breakdown of laws:

Michigan cities we service:

Helpful information

  • Illinois State Shipping Regulations for oversize and heavy haul.
    Illinois State Shipping Regulations for oversize and heavy haul.
    Shipping laws, regulations, limitations and rules for shipping oversize and over-weight loads over the roads and highways in the state of Illinois. Please share your expertise or knowledge of Illinois state shipping regulations with other visitors below. Trucking and pilot car location system: Locate trucking companies and pilot cars in...
  • 2019 Georgia State Shipping Regulations
    2019 Georgia State Shipping Regulations
    2019 Georgia state DOT shipping laws, regulations, rules, limitations, for oversize and heavy-haul trucking permits.  Heavy-haul trucking and pilot cars. Locate oversize, heavy-haul trucking companies and pilot cars. Georgia pilot cars and truck escorts for hire. Georgia oversize and heavy-haul trucking companies for hire. Georgia state oversize and heavy haul...
  • pilot car truck equipped with a height pole.
    What is a height pole?
    WHAT IS A HEIGHT POLE OR HI-POLE? A height pole or high pole or hi-pole is a measuring device that is precisely attached to the front of a pilot car vehicle that is used to measure the height of overhead obstructions during the transport of over-dimensional (tall) shipments by oversize...
  • How to start a pilot car company.
    How to start a pilot car company.
    How to realistically start a pilot car company. A-Z, current 2019. Put together by industry professionals in the industry for 30+ years. If you want to learn what you need to succeed this package is a must!
    The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Michigan State DOT Permits office before commencing movement.
    Michigan state DOT regulations for heavy haul and oversize loads.

    Michigan state flag.

2018 Mississippi State Shipping Regulations

2018 Mississippi state DOT shipping laws, rules, regulations and limitations for oversize and heavy-haul trucking permits. Pilot car requirements.

Mississippi

The great state of Mississippi official seal.

Please share your knowledge with other visitors below.

Pilot car, oversize and heavy-haul trucking permit quick links.

Locate oversize, heavy-haul trucking companies, pilot cars and permit providers:

Mississippi oversize, heavy-haul and pilot car companies for hire.
Mississippi pilot cars and truck escorts for hire.
Mississippi oversize and heavy-haul trucking permits.

Do I need a trucking permit? Legal load limits.

Mississippi maximum load limits until a trucking permit is required:

Length: The maximum length permitted by the Mississippi DOT is 53 feet for trailers and 99 feet overall including the power unit.
Width: The maximum allowed width is 8 feet 6 inch wide.
Height: The maximum height permitted to travel on Mississippi roads and highways is 13 feet 6 inches.
Weight: 80,000 pounds overall (GVW) and nor more than 12,000 pounds on your steer. Single axle limit is 20,000 pounds, tandem axle limit is 34,000 pounds, tridem axle limit is 42,000 pounds.
Overhang: You are permitted to have a maximum front overhang of 3 feet and a rear maximum overhang of 14 feet and 11 inches legally.
Notes:

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Mississippi:

Length: Overall trucking permit limits for length are up to 120 feet.
Width: You can now get routinely approved for up to 20 feet wide for some routes.
Height: 17 feet is the maximum routine limit for permits.
Weight: Steer: 12,000 pounds, single axle: 20,000 pounds, tandem axles: 48,000 pounds, tridum axle: 57,000 pounds, and up to 63,000 pounds if interstate only. Quadem axles: 64,000 or up to 72,000 pounds if on interstates only. Maximum gross weights on 5 axles: 113,000 pounds, 6 axles: 123,000 pounds, 7 axles: 128,000 pounds, 8 axles: 141,000 pounds. Over-weight dozers in most cases are allowed to be permitted with blade detached and included on trailer. IN many cases you for over-weight shipment a comprehensive, detailed review including drawings of the product, trailer and axle spacings as well as the route you prefer to travel will be required when filing for Mississippi heavy-haul trucking permits.

Overhang: Mississippi DOT has no set limitation for overhang for routine permits should not be a problem unless you intend on exceeding the law of 1/3 (no more than 1/3 of item being shipped overhangs).
Notes: If you are not sure about any routes in Mississippi you can use their route checker here to look up your limits. For more documentation see; Mississippi oversize and heavy-haul permit regulations.

Mississippi superloads.

Mississippi superload information: 

Length: When over 120 feet in length overall combined a superload permit will need to be filled.
Width: If the shipment is in excess of 20 feet in width a superload permit will be required.
Height: When in excess of 15 feet and 7 inches in height if you have a second dimension that is over the legal limit or depending on your desired route you may be required to file as a superload. 15 feet and 7 inches in height will require a route survey. Over 16 feet in height will reguire a route survey, letters from all pertinent utility companies and special approval from the MS DOT permitting department which may result in superload permit applications.
Weight: Whenever a shipment is in excess of 141,000 pounds it will qualify as a superload and must be permitted as a superload in order to ship.
Overhang: Overhang alone will more than likely not be a determining factor if superload permits are required.
Notes: Always work with Mississippi state DOT proactively. They’ll do their best to get the shipment in the proper category and correct permit issued. Excessive weights must meet bridge analysis specifications in order to be safely transported.

Lights, safety flags and warning signs for heavy haul and oversize loads.

Required safety markings, safety flags, warning lights for heavy haul and oversize loads:

All shipments that are oversize (and over 12 feet wide) being transported within the state of Mississippi are required to have signs. Sign dimensions will need to be at least 84 inches wide and 18 inches in height. All signs should have the words “OVERSIZE LOAD” on them and black letters that are at least 10 inches in height and 1 and 5/8 inches thick. All signs should have a yellow background with black letters. Red or orange fluorescent safety flags are required as well as and should be used on all four of the outer most extremities of the combination (front to rear) and mounted a minimum of 6 feet above pavement level. All safety flags should be minimum of 18 inches square in shape. If the shipment is in excess of 12 feet wide it is required to have flashing amber lights mounted on both sides of the rear extremities in all cases.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanies by a escort vehicle or pilot car if:

QUICK REFERENCE

Length:

  • If in excess of 95 feet overall; 1 pilot car/escort vehicle will be required. Some routes will require 2.
  • If in excess of 105 feet overall: 1 pilot car and 1 escort vehicle will be required..

Width:

  • If permitted to travel during night hours 1 escort vehicle will be required when 10 feet or more wide.
  • If in excess of 12 feet and 11 inches 1 pilot car or escort vehicle is required.
  • If in excess of 16 feet wide 1 pilot car and 1 escort vehicle will be required.

Height: Mississippi state DOT may require 1 pilot car vehicle equipped with a height pole on some routes if over 14 feet in height. A route survey may be mandatory for shipments in excess of 15 feet and 7 inches in height depending on desired route..
Overhang: If in excess of 15 feet in the front will require 1 front lead pilot car is required.  chase escort vehicle is required. Some routes require 1 lead pilot car rather than chase.

 DETAILED REFERENCE

Length:

Pilot cars or escort vehicles (front of rear depends on route and lanes) will be required whenever the overall combined length of the shipment exceeds 95 feet. If the shipment is in excess of 105 feet overall you may be required to have 1 front lead pilot car and 1 rear chase escort vehicle depending on route.
Width: Over 10 feet wide anytime night travel is permitted requires 1 pilot car or escort vehicle. Over 12 feet and 11 inches requires 1 pilot car/escort vehicle. Over 13 feet wide requires 1 front lead pilot car on 2-lane roads or 1 rear chase escort vehicle on 4-lane roads.
Height: 15 feet and 6 inches (over 15 feet and 7 inches requires a route survey) may require 1 lead pilot car depending on desired route. A lead pilot car equipped with a height pole will be required for shipments in excess of 16 feet in height.
Notes: In some cases a rear escort can be eliminated by attaching 2 (5 inch) amber lights mounted on the rear of the shipment. If you plan to implement this option note that you are also required to have a monitoring device in the truck cab that confirms both amber light bulbs are in operation.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

Mississippi law for pilot cars is very basic. We suggest you follow the federal pilot car and escort vehicle requirement guidelines but as of 2018 the requirements are as follows: A single motor vehicle equipped with a amber rotating or strobing light mounted at the top of the vehicle. Two red or range fluorescent safety flags mounted on the vehicle. A “OVERSIZE LOAD” mounted at either the top of the vehicle that does not obstruct view of the strobe/rotating amber light of a “OVERSIZE LOAD” sign mounted to the front when leading or rear when chasing (following) a oversized load. Signs must be covered when not in operation.

 

Legal travel times for oversize and heavy haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

Daylight hours are define as 1/2 hour after sunrise and 1/2 hour before sunset. Travel is permitted on Saturdays with no travel at all permitted on Sunday. If your shipment is in excess of 12′ wide you may not travel on Saturday. You may not travel on the following holidays: New Years day, Memorial day, Independence day, labor day, Thanksgiving day and Christmas day. You may not move any later than 12 noon on any day that comes before one of these holidays. For shipments that are in excess of 12′ in width you are strongly encouraged to route your shipment around high traffic density areas and may not travel in areas of high traffic from 7 AM – 8:30 AM and again from 4:30 – 5: 30 PM with the exception of I-10 ( travel during these hours is permitted).

747 in transport via CRS Pilot Car


DOT contact information and notes.

Mississippi state DOT office permit contact information:

Mississippi Department of Transportation Permit Division
Post office box: 1850
Jackson, MS 39215
Telephone: 601-359-1717 or Permits: 888-737-0061
Office hours: 7:30 AM until 4:30 PM
Website: https://www.expresspass.ms.gov/trucking/
E-mail: msdotpermits@mdot.ms.gov
Central Daylight Time
Notes:
To file for oversize or heavy-haul trucking permits online you must have a account already set up with MS state DOT. MS is a member of SASHTO.




Mississippi cities serviced.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Mississippi DOT Permits office before commencing movement.
Mississippi state regulations for oversize and overweight shipping.

Mississippi state flag.

2018 Maine State Shipping Regulations

2018 Maine DOT regulations for shipping oversize and overweight loads. Trucking company and pilot car reference.

Maine oversize shipping regulations.

The great state of Maine official seal.

 Please share your knowledge with other visitors below.

Trucking company & pilot car directory.

Locate trucking companies and pilot cars in Maine:

Maine trucking company directory.
Maine pilot cars and truck escorts.



 

Legal load limits.

Maine DOT legal size and weight limitations:

Length: 69 feet combined overall and the maximum length of your trailer can not exceed 48 feet.
Width: 8 feet and 6 inches in the maximum width allowed by Maine DOT.
Height: 14 feet is the maximum height allowed to travel in Maine legally.
Weight: 80,000 pounds GVW is the maximum weight allowed without a permit.

Routine trucking permits.

Oversize and overweight trucking permits that are routinely issued by the Maine state DOT office:

Length: 125 feet in length is the maximum for a routine trucking permit.
Width: 16 feet wide is the maximum for a routine permit and anything wider than this will require a police escort. If over 18 feet wide you will not be allowed to travel on the turnpike.
Height: 16 feet high in the most on a routine permit (13 feet and 6 inches is the limit on the Maine turnpike) and this depends on your routing. If you are close to this or over you will possibly have to have a route survey done and you will be required to notify all utility companies that have obstructions along your route.
Weight: Tandem axles: 52,000 pounds, tridum axles: 75,000 pounds, quadem axles: 100,000 pounds. Gross weight for 5 axles is: 130,000 pounds, for 6 axles: 140,000 pounds, and for 7 axles is the maximum gross weight allowed is: 167,000 pounds maximum.

Maine DOT superload information:

Anything that is over 125 feet long, 16 feet wide, 16 feet tall or over 125,000 pounds in weight is considered a superload by the Maine DOT. Permit approval could take 30 days depending on your proposed route and how far you want to exceed legal limits. You may wish to see: Maine state oversize and heavy haul trucking laws.

Permitted travel times and restrictions.

Maine DOT permitted travel times and travel restrictions:

One 1/2 before and 1/2 hour after sunset rule applies. With the exception of during the months of July and August you may travel on Saturdays and Sundays but may not during these 2 months. There is no holiday travel on the following holidays: New Years day, Memorial day, Independence day, Labor day, Columbus day, Veterans day, Thanksgiving day, Black Friday and on Christmas day.

NOTES: Turnpike travel: you may travel on the Maine turnpike  during the daylight hours from Monday until Friday at 12 noon. You may not travel on the weekends. Max width if 14 feet 6 inches and for height see “Routine permits” above. You can reach the Maine turnpike office at 207-871-7771. Mobile home shipments can only travel on Monday, Tuesday, Wednesday and on Thursdays – after that you may not travel. Night shipments may be approved but have to clear the Maine state police for permission first.

When pilot cars are required.

If your shipment is over any of the following you will be required to have a pilot car or escort vehicle by the Maine DOT office.

If highway is divided, a single pilot car or escort vehicle is to be positioned at the rear of the vehicle. If the highway is undivided, a single pilot car or escort vehicle is to be positioned at the front of the truck and trailer.

Width: 12 feet to 14 inches requires 1 pilot car or escort vehicle., 14 feet and 6 inches to 15 feet and 11 inches requires 2 pilot cars or escort vehicles.
Height: Over 16 feet requires a state police escort.
Length: Over 79 feet and 11 inches requires 1 pilot car or escort vehicle. Over 110 feet requires 2 pilot cars (escort vehicles).  Over 125 feet requires a state police escort.

NOTES: Signs must say “oversize load” in 10 inch high black letters on a yellow background.
They must be at least 7 feet wide by 18 inches high and posted on both the front and rear.
18 inch by 18 inch flags must be posted on all four corners of load. Pilot cars must have 2-way radio that has contact with at least a ½ mile range. The truck must have a flashing amber light on top of the cab.

How to apply for trucking permits.

Maine Department of State Bureau of Motor Vehicles, overlimit Permit Unit
29 State House Station
Augusta, ME  04333
Phone: 207-622-5332
E-mail: overpermits@maine.gov
Office hours: Monday thru Friday 7:30 Am until 5 PM
Eastern Time

NOTES: The Maine turnpike requires a separate permit and has its own size/weight limits.  (800) 698-7747 or 207-871-7771. Permits can be purchased
at Maine Turnpike toll plazas. Cost is $10. Signs must say “oversize load” in 10 inch high black letters on a yellow background. They must be at least 7 feet wide by 18 inches in height and posted on both the front and rear. 18 inch by 18 inch flags must be posted on all four corners of load. Pilot cars must have 2-way radio that has contact with at least a ½ mile range. The truck must have a flashing amber light on top of the cab.


 Required shipment truck and trailer markings.

#####Coder notes>bring it:

Permit valid for.
DOT links.
Map shot.
Contact info.
Road closures.
Thaw law.
MDOT for juicy info that is hard to find.

Maine cities serviced.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Maine State DOT Permits office before commencing movement.

 

 

maine-state

2018 Nebraska State Shipping Regulations

2018 Nebraska state shipping laws, rules, regulations and limitations for oversize and heavy-haul trucking permits. Pilot car requirements.

Nebraska oversize, heavy-haul trucking permits and pilot cars.

Nebraska oversize and heavy-haul trucking companies for hire.
Nebraska pilot car companies for hire.
Nebraska oversize and heavy-haul permits.



Do I need a trucking permit? Legal load limits.

Nebraska maximum load limits until a trucking permit is required.

Length: Overall no longer than 85 feet on designated highways.  Trailer length maximum is 53 feet.
Weight: 80,000 pounds GVW, 20,000 pounds on a single axle, 34,000 pounds on tandem axles.
Width: 8 feet and 6 inches.
Height: 13 feet and 6 inches
Overhang: No set rules, case-by-case.  We figure 3 feet of front or rear should be safe but by no means is that policy. For clarification be sure refer to your permit.
Notes: For documentation refer to: Nebraska legal limitations for transport.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Texas:

Length: Up to 120 feet long is routine. Anything over will be assessed but limits are relaxed.
Weight: They do not use the federal bridge formula. 20,000 pounds per axle is the maximum. Anything over 110,000 pounds combined overall is going to be a superload. 20,000 pounds on a single axle, 40,000 pounds on tandem axles, 60,000 pounds on tridum axles, 80,000 pounds on quadem axles.  Dummy axle must carry minimum of 8,000 pounds or 8% of the gross total weight.
Width: Figure up to 14 feet as a routine permit.  They are strict on width and over 14 feet wide is going to be looked at as superload unless it’s a light load. Case-by-case but if you are heavy you may need approval from Lincoln, NE (up to 5 days processing times).
Height: Up to 14 feet and  6 inches is considered routine and some routes may require a high pole. If you are over 16’ feet a high pole is mandatory.

Nebraska superloads.

Requirements for extra-heavy or over-dimensional (superloads in NE):

For the purpose of this reading you can figure superload dimensions are anything that is in excess of the dimensions or weights mentioned above in “routine”. If you are close then it will be up to the state to determine if you must file for your permit as a superload or not. See actual Nebraska state oversize and heavy haul trucking laws.

Legal travel times for oversize and heavy-haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

Travel time is half hour before sunrise and a half hour after sunset leniency rule.  Weekend travel is permitted but they do have travel time restrictions around Lincoln, NE and Omaha, NE during both weekdays and weekends.  Travel is prohibited on most all holidays and the day after Thanksgiving.

Lights, safety flags and warning signs for heavy haul and oversize loads.

Required marking, safety flags, warning signs for heavy haul and oversize loads:

All loads being shipped in Nebraska must be marked with oversize load signs shipments are also required to have square red or orange florescent flags on all four corners to include the power unit and must be 18 inches. Pilot cars or escort vehicles that are used during the shipment must have flags in the front if leading or the rear if chasing. One revolving amber light must be on the top of the power unit as well as on the top of the pilot car. All signs must be yellow and background with black letters no less than 10 inches in height. For night time moves on shipments that are in excess of 12 feet wide a light bar attachment is required to be mounted on the rear of the load at a height that is clearly visible by motorists approaching from the rear.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanies by a escort vehicle or pilot car if:

Length: 90’ one on the rear. Over 100’ needs a rear and a chase pilot car.
Width: They can impose a required pilot car for anything over 8’ 6”.  In some cases a lightbar can be used in lieu of a pilot car. Loads over 12 wide on 4 lane is required one rear. Front is required for loads on 2 lane highway over 12’ wide. Front and rear is required for loads over 14’ wide. Front escort with height pole is required for 14’ 6” and over.
Height: Over 14’ 6” needs pilot car, may need height pole depending on route.
Overhang: If over 15’ one rear escort is needed.
Note: Allow 1 to 10 days for permits to be approved. Maximum speeds of 45 MPH if 4 or more lanes, 35 MPH is under 4 lanes. Also read travel restrictions below.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

All escort vehicles or pilot cars must be equipped with a amber light or light bar and must have a left and right side flashing or Rotary amber or yellow light of sufficient size that will be visible 360° from a distance of no less than 800 feet. Lights must be a minimum of 50 candle power bulbs. Lights must be no less than 6 inches in diameter.

Heavy lift being shipped in Nebraska.


Nebraska DOT contact information and notes.

Nebraska DOT office and permit contact information:

Physical and mailing address:
Nebraska Department of Roads
1400 NE Highway 2, Permit Office, Room 123
Lincoln, NE  68509
Telephone: 402-471-0034
Hours: Monday – Friday 7:30 AM – 5:00 PM
Central Daylight Time

Nebraska cities serviced.

 

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Nebraska State DOT Permits office before commencing movement.

nebraska-state

Missouri State Shipping Regulations

2018 Missouri shipping laws, regulations, rules and limitations for oversize and heavy-haul trucking permits.

Missouri oversize and heavy-haul shipping regulations, permits.Please share your knowledge of Missouri state shipping regulations with other visitors below.

Locate oversize, heavy-haul trucking companies and pilot cars.

Missouri oversize, heavy haul trucking companies and pilot car for hire:

Missouri pilot cars and trucking escorts.
Missouri oversize and heavy-haul trucking companies.



Do I need a trucking permit? Legal load limits.

Missouri maximum load limits until and trucking permit is required.

Length: 53 feet maximum. If you overhang in either direction on a 53 foot trailer (even a 1/2 inch) you are required to obtain a permit.
Width: 8 feet  6 inches.
Height: 13 feet 6 inches.
Weight: 80,000 pounds GVW.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize and heavy-haul trucking permits in MO:

Length: 53 foot is the maximum. Over 90 feet combined overall requires 1 rear escort.  120 feet can be permitted. Anything over is a superload.
Width: Figure up to 14 feet as a routine permit. Some routes/distances may qualify as routine, see: state laws.
Height: 14 feet and 6 inches depending on routing/distance. To see if others qualify see above “state laws” link.
Weight: Single axle 20,000 pounds, 46,000 pounds on tandem axles, tridem axles 60,000 pounds (no more than 21,000 on any single in combination), quad axles 72,000 pounds (no more than 19,000 pounds on any single axle configurations), 5 axles 104,000 pounds, 6 axles 120,000 pounds, 7 axles (config. 1-2-4) 130,000 pounds, 8 axles 160,000 pounds, 9 axles (config. 1-4-4) 156,000 pounds.
Overhang: Anything over 53 feet in length requires a permit. If you overhang or are in excess of 53 feet by a 1/2 inch you are required to obtain a permit.

Missouri superloads.

Requirements for extra-heavy or over-dimensional (superloads in MO):

All superload shipments are required to have a minimum of 2 million dollars in single limit combined liability insurance. For simplicity a superload in Missouri is any shipment in excess of the above dimensions or weights listed above in “routine”. For complete details of state laws.

Missouri load long and heavy.

When pilot car or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanied by a escort vehicle or pilot car if:

QUICK REFERENCE

Length: 90 feet overall length requires 1 rear/ chase pilot car or escort vehicle if highway is not divided.
Width:

  • 12 feet and under requires no escort.
  • 12 feet and 4 inches will require 1 rear/chase escort vehicle. 1 escort vehicle and 1 pilot car are required on non-designated roads.

Height:

  • 15 feet 6 inches on 2 lane undivided roads requires a high pole pilot car.
  • 15 feet on divided highways requires 1 pilot car with height pole. May need route survey and bucket trucks.

Overhang:

  • Anytime lenght of load exceeds 53 feet 1 pilot car is required. Over 90 feet overall may require 1 pilot car and 1 escort.

Notes: If the shipment consists of 2 dimensions being over the legal limits 1 pilot car and 1 escort vehicle are required.

DETAILED REFERENCE – #####updating live June 25th #####

Length: Anything over 90’ requires one rear/chase vehicle.
Width: Two lanes total over 12” 4”’ wide needs one front up to 14’. Four lanes total over 12’ 4” wide requires one rear.
Height: If over 15’ 6” you need a high pole and a rear/chase vehicle and can only move from 6:30 -9:00 am and 3:30 – 6:00 pm on all routes. Over 17’ 5” needs route survey and bucket truck.
Overhang: Anytime load is in excess of 53 feet.

Pilot car and escort vehicle requirements, certifications.

In order to operate a pilot car or escort vehicle in the state of Missouri you are required to have a minimum of the following:

Missouri state laws says pilot car/escort vehicles must be a standard size and have unrestricted vision in the front and rear. Vehicle must be in safe operating condition. “Oversize Load” signs must be displayed towards the front or rear, whichever is applicable. Signs must not be visible when not in service. Signs must be a minimum of 5 feet in length and 1 foot in height. Signs must have a yellow background color with thick (1 inch minimum) black clear, professional print quality lettering. All escort vehicles must be equipped with safety colored red or orange florescent flags that can be mounted on both sides of the front of lead pilot car vehicles or both rear sides of chase escort vehicles. All vehicles involved in shipment must have 2-way radio capabilites. Insurance requirements must be a minimum of $50,000 for personal injury per person. $200,000 for accident/property damage and/or combined single limit liability of $250,000.

Note: Flaggers or any person directing or altering traffic is required to have a “flaggers certification” and be flagger certified.

 

 

Travel Restrictions

Travel is restricted if over 12’ 4” wide in most areas to 6:30 am (or a half hour after sunrise) until 9:00 am then resume at 3:30 pm until 6:00 pm (or a half hour before sunset). If over 14’ wide no movement on Saturday or Sunday at all.  You may move Monday thru Friday but only. For now, consider this info as a basic guideline for estimates only. Please call the State of Missouri for exact laws. And always be sure to read the instructions on your permit(s).

Missouri DOT and permit contact information.

Physical address and MDOT contact information:
Missouri Department of Transportation, Motor Carriers, Special Permit Office
PO Box 270, Jefferson City, MO 65102
Phone: 573-751-2871
Permit office hours: Monday thru Friday 7:30 am until 3:45 pm.
Missouri legal guidelines: Missouri oversize and heavy-haul regulation laws printed by the state.

Missouri cities serviced.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Missouri State DOT Permits office before commencing movement.

missouri-state