Oregon State Shipping Regulations

Oregon State Shipping Regulations

2021 Oregon state shipping laws, regulations, and limitations for heavy-haul trucking and oversize loads.

Support visitors like yourself by sharing information at the bottom of this page.

Maximum legal limits without requiring a permit.

Maximum legal limits. Standard Metric
Length: Determined by trailer length: 53 feet max. 16.1 meters maximum trailer length.
Width: 8 feet, 6 inches. 2.6 meters.
Height: 14 feet. 4.2 meters.
Weight: 80,000 pounds. 36,287 kilograms.
Overhang: 5 feet from the rear, 4 feet from the front. 1.5 meters from the rear, 1.2 meters from the front.
Notes: Some roads require a permit for a 53 feet trailer. Overhangs must be day flagged or night illuminated.

Oregon legal maximum limit information in detail.

Routinely issued oversize/overweight permit maximums.

Oversize/overweight transport/trucking permits routinely issued by ODOT.

Maximum routine permit limits Standard Metric
Length: 80 feet overall depending on routing. 24.3 meters.
Width: 15 feet. 4.5 meters.
Height: 17 feet. 5.1 meters.
Weight: 98,000-105,000 lbs depending on the route. 44,452 kilograms.
Overhang: No set limit. Depends on the route.
Notes: Overhang can not exceed more than 1/3 of the total combined wheelbase length: first front to last rear axle.

Routinely issued oversize/overweight permit information in detail.

Oregon overhang in-depth clarification.

Oregon superload information.

Shipments in excess of the following weights/dimensions are classified as superloads in Oregon.

Superload size/weight classification Standard Metric
Length: 150+ feet. 45.7+ meters.
Width: 14 feet on 2 lane – 16+ feet on Interstate. 4.2+ and 4.8+ meters.
Height: 17+ feet. 5.1+ meters.
Weight: Over 105,000 lbs on some routes. 47,627+ kilograms.
Overhang: 4+ feet. 1.21+ meters.
Notes: Superloads have finely detailed instructions clearly printed on the official permit. Any discrepancies should be discussed with the issuing ODOT superload permit office official prior to commencing movement/transport.

Oregon superload information in-depth.

Permitted travel times and restrictions.

When pilot cars/escorts are required.

Pilot car/escort vehicle requirements.

Required shipment markings, signs, flags and lights.

Additional information.

Oregon DOT (ODOT) locations and contact information.

Oregon ODOT contact information and other helpful links.

Oregon Motor Carrier Transportation Division – Over-Dimensional Permit Unit.
Dept. of Transportation Permits Office
Motor Carrier Transport OS/OD Permit Unit
550 Capitol Street, NE
Salem, OR   97301
Telephone: 503-373-0000
Trip Permits: (503) 378-6699
Fuel Permits: (503) 373-1634
Hours: 7 am – 5 pm Monday – Friday (Wed. closed from 12-1 pm). PACIFIC DAYLIGHT TIME.

Note: When applying in Oregon for overweight permits you should know they have a strict bridge formula which may delay permit issuance depending on the route. Also, some counties require permits for travel as well so be sure to ask. Permits are valid for 10 days only.

See also:

ODOT oversize information website.
Oregon road closures and conditions.
Oregon pilot car and truck escorts.
Oregon heavy haul and oversize trucking companies
Oregon oversize and overweight trucking permits.

 

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Oregon State DOT Permits office before commencing movement.

 

oregon-state

 

 

Missouri State Shipping Regulations


2021 Missouri shipping laws, regulations, rules, and limitations for oversize and heavy-haul trucking permits.

Please share your knowledge of Missouri state shipping regulations with other visitors below.

 

Do I need a trucking permit? Legal load limits.

Missouri maximum load limits until and trucking permits are required.

Length: 53 feet maximum. If you overhang in either direction on a 53-foot trailer (even a 1/2 inch) you are required to obtain a permit.
Width:  8 feet  6 inches.
Height: 13 feet 6 inches.
Weight: 80,000 pounds GVW.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize and heavy-haul trucking permits in MO:

Length: 53 feet is the maximum. Over 90 feet combined overall requires 1 rear escort.  120 feet can be permitted. Anything over is a superload.
Width: Figure up to 14 feet as a routine permit. Some routes/distances may qualify as routine, see: state laws.
Height: 14 feet and 6 inches depending on routing/distance. To see if others qualify see the above “state laws” link.
Weight:  Single axle 20,000 pounds, 46,000 pounds on tandem axles, tridem axles 60,000 pounds (no more than 21,000 on any single in combination), quad axles 72,000 pounds (no more than 19,000 pounds on any single axle configurations), 5 axles 104,000 pounds, 6 axles 120,000 pounds, 7 axles (config. 1-2-4) 130,000 pounds, 8 axles 160,000 pounds, 9 axles (config. 1-4-4) 156,000 pounds.
Overhang: Anything over 53 feet in length requires a permit. If you overhang or are in excess of 53 feet by a 1/2 inch you are required to obtain a permit.

Missouri superloads.

Requirements for extra-heavy or over-dimensional (superloads in MO):

All superload shipments are required to have a minimum of 2 million dollars in single limit combined liability insurance. For simplicity, a superload in Missouri is any shipment in excess of the above dimensions or weights listed above in “routine”. For complete details of state laws.

Missouri load long and heavy.

When a pilot car or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanied by an escort vehicle or pilot car if:

QUICK REFERENCE

Length: 90 feet overall length requires 1 rear/ chase pilot car or escort vehicle if the highway is not divided.
Width:

  • 12 feet and under requires no escort.
  • 12 feet and 4 inches will require 1 rear/chase escort vehicle. 1 escort vehicle and 1 pilot car are required on non-designated roads.

Height:

  • 15 feet 6 inches on 2 lane undivided roads requires a high pole pilot car.
  • 15 feet on divided highways requires 1 pilot car with a height pole. May need route survey and bucket trucks.

Overhang:

  • Anytime the length of the load exceeds 53 feet 1 pilot car is required. Over 90 feet overall may require 1 pilot car and 1 escort.

Notes: If the shipment consists of 2 dimensions being over the legal limits 1 pilot car and 1 escort vehicle are required.

Pilot car and escort vehicle requirements, certifications.

In order to operate a pilot car or escort vehicle in the state of Missouri you are required to have a minimum of the following:

Missouri state laws say pilot car/escort vehicles must be a standard size and have unrestricted vision in the front and rear. The vehicle must be in safe operating condition. “Oversize Load” signs must be displayed towards the front or rear, whichever is applicable. Signs must not be visible when not in service. Signs must be a minimum of 5 feet in length and 1 foot in height. Signs must have a yellow background color with thick (1-inch minimum) black clear, professional print quality lettering. All escort vehicles must be equipped with safety-colored red or orange fluorescent flags that can be mounted on both sides of the front of lead pilot car vehicles or both rear sides of chase escort vehicles. All vehicles involved in shipment must have 2-way radio capabilities. Insurance requirements must be a minimum of $50,000 for personal injury per person. $200,000 for accident/property damage and/or combined single limit liability of $250,000.

Note: Flaggers or any person directing or altering traffic is required to have a “flaggers certification” and be flagger certified.

Travel Restrictions.

Travel is restricted if over 12’ 4” wide in most areas to 6:30 am (or a half-hour after sunrise) until 9:00 am then resume at 3:30 pm until 6:00 pm (or a half-hour before sunset). If over 14’ wide no movement on Saturday or Sunday at all.  You may move Monday thru Friday but only. For now, consider this info as a basic guideline for estimates only. Please call the State of Missouri for exact laws. And always be sure to read the instructions on your permit(s).

Missouri DOT contact information.

Physical address and MDOT contact information:
Missouri Department of Transportation, Motor Carriers, Special Permit Office
PO Box 270, Jefferson City, MO 65102
Phone: 573-751-2871
Permit office hours: Monday thru Friday 7:30 am until 3:45 pm.
Missouri legal guidelines: Missouri oversize and heavy-haul regulation laws printed by the state.

Missouri oversize and heavy-haul shipping regulations, permits.

Missouri cities serviced.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Missouri State DOT Permits office before commencing movement.
[codepeople-post-map]

missouri-state

Missouri oversize, heavy haul trucking companies, and pilot car for hire:

Missouri pilot cars and trucking escorts.
Missouri oversize and heavy-haul trucking companies.

 

Manitoba shipping regulations

2021 Manitoba DOT shipping laws, regulations, and limitations, for oversize and heavy-haul trucking over the roads and highways of Manitoba Canada.

Please share your expertise of knowledge with our other visitors below.

Legal limits.

Length: The overall maximum length without a permit is 23 meters.
Width: The maximum width allowed without a permit is 2.6 meters.
Height: 4.15 meters is the maximum height allowed by Manitoba DOT without a permit.
Weight: 9,100 kg on steer (seems high to us so NOT a confirmed number –  use reference link below), tandem axles: 17,000 kgs, tridem: 17,000 kgs,  or 3 axle combination with proper spacing of a 23,700, quadem: 31,600 kgs, 5 axle: 39,500 kgs and 6 axles: 46,500 kgs. Let me refer you to our reference on this for clarification from Manitoba DOT as there are different weight classes.
Overhang: 3′ 3″ (1 meter) in front or rear.

Routine heavy-haul and oversize trucking permits.

Length: 30 meters in length is about all you are going to get.
Width: 5 meters wide for routine permits depending on routing.
Height: Depending on routing as Manitoba DOT has designated routes the maximum height is 4.8 meters.
Weight: We were unable to get a solid figure. Manitoba DOT has different zones for weight restrictions so it all depends on which zone you need to travel in. See Manitoba DOT zone map.
Overhang: Manitoba is overhang laws with permits.

Travel times and restrictions.

Daylight travel times are defined as from sunrise to sunset in Manitoba. No travel is permitted after 3 PM on Fridays during the summer months for shipments in excess of 3.4 meters (11′ 2″) wide on seasonal restricted roads. In the spring shipments in excess of 4.6 meters (15′) in width are not allowed to travel on roads during the spring restriction times. On routes that are not seasonally restricted you may proceed (multiple lane roads) until 3 PM as long as you are no wider than 3.7 meters in width (12′ 2″) on Friday and resume travel on Saturday at sunrise however if you are in excess of 25 meters in length (82′) you are not permitted to travel after 3 PM on Fridays during the summer months if you are on a seasonally restricted highway and resume on Saturday at sunrise – you are allowed however to travel on holidays. Sunday travel is permitted for loads up to 3.85 meters (12′ 7″) in width on all roads that have no seasonal restrictions. On a single lane highway on holidays you can not exceed 3.4 meters (11′ 2″) in order to travel. On multiple lane roads, you can travel only if you are less than 3.7 meters (12′ 2″). This is very confusing so always refer to your permit for final verification but to help the matter lets go over the restricted routes:

  • Highway 1 from Falcon Lake to the Manitoba/Ontario border.
  • Highway 6, 8, 9, 15, 16, 44, 307, 313, 317.
  • Highway 10 from the US border to Riding Mountain National Park.
  • Highway 11 but only north of highway 44.
  • Highway 12 but only north of highway 15.
  • Highway 59 from the west boundary line of Brokenhead to Grand Beach and the South perimeter of St. Malo

Here is the Manitoba link for spring road restrictions with zones to help you with interpretation. Holidays observed are New years day, Provincial day, Good Friday, Victoria day, Canada day, Family day, Labor Day, Thanksgiving Day, Remembrance Day, Christmas Day, and Boxing day.

Superload information.

We will do more research on superloads in Manitoba in the future. The Manitoba DOT documentation does not cover or mention much about them so we will need to speak with someone on the phone. We are able to see that they are well versed in shipping superloads as they mention in their online documentation that there will make arrangements to remove roadside signs and replace them for shipments that are in excess of the road width. We will get back to this section soon but in the meantime appreciate any comments you may be able to leave for other visitors below.

Pilot car are escort vehicle information.

Manitoba DOT requires you to have a pilot car if your shipment is in excess of any of the following regulated limits:

Length: Shipments that are in excess of 30 meters (98′ 5″) long require 1 pilot car/escort vehicle on the rear of the shipment on all roads. For shipments that include a booster of a jeep that is over 31 meters (101′ 9″), you are required to have 1 rear pilot car vehicle on all roads.
Width: If your shipment is in excess of 4.6 meters (15′) wide then you are required to have 1 front pilot car on single lane roads and 1 rear pilot car/escort on multiple lane roads. If your load is in excess of 3.66 meters (12′) but less than 4.55 meters ( 14′ 7″) then you are permitted to travel at night as long as you have 1 front and 1 read pilot car/escort vehicle on all roads and highways. Mobile homes can travel at night on multiple lane roads as long as it does not exceed 5 meters wide (16′ 4″) but are required to have 1 pilot car on the rear.
Height: If you are approved for a shipment that is over the legal limits Manitoba DOT has designated routes and you are not required to have a pilot car.
Weight: As long as your shipment is able to maintain the minimum speed requirements you will more than likely not be required to have a pilot car as long as your shipment is overweight only.
Overhang: Overhang is approved on a case-by-case basis. Check with the Manitoba DOT for further information to see if your shipment will require a pilot car due to excessive overhang.

Pilot car and escort vehicle requirements.

Pilot car/escort vehicle operators are required to take a Manitoba DOT certification course in order to operate in this province. The certification program is recognized by all US jurisdictions that require PEVO except for New York state. Your vehicle is required to have a lighted sign box that is a minimum of 180 cm x 35 cm x 10 cm (72″ x 14″ x 4″), 2 – 175 mm (7″) diameter flashing lights mounted on the top of the sign-box on each side with 2 amber strobing or rotating lights a minimum of 203 mm (8″) mounted between the flashing lights on top of the box as well. The sign-box must light up and be visible from a minimum distance of 200 meters (656′). The sign-box must have either a red and white D sign or a yellow with black lettering stating “OVERSIZE LOAD”, “WIDE LOAD”,  OR “LONG LOAD”. If you have the “D” sign your letter must be no less than 20 cm (8″) in height with a 4 cm (1 5/8″) line thickness. If you have the yellow sign your lettering must be no less than 20 cm (8″) with a 4 cm (1 5/8″) line thickness. The sign-box must be mounted on the top of the vehicle and covered when not in operation. You are also expected to have the following items inside of the vehicle: CB radio or high powered 2-way radio, first aid kit, fire extinguisher type A, B & C of at least 2 liters, 3 reflective road triangles, 3 traffic cones, reflective vest (worn while working), slow/stop sign, 3 red or orange safety colored flags no less than 40 x 40 cm (16″ x 16″), nose cone flashlight and a hard hat.

To operate in Manitoba you must obtain a light permit. More information is available by calling: 204-985-0920

Shipment, truck, and trailer markings.

Truck, trailer, and shipment required signs, banners, and flags in Manitoba:

All trucks that are hauling oversize or overweight loads must have a strobing, flashing or rotating amber light mounted to the roof that is visible from 360 degrees at a minimum distance of 200 meters (656′). All 4 outermost corners of the overall shipment and any obtrusive points must have flags mounted to them that are safety red or orange in color no less than 40 cm x 40 cm (16″ x 16″) and have the flags exchanged for lighting if moving during the night. A sign stating the nature of the load; “OVERSIZE LOAD”, “WIDE LOAD” or “LONG LOAD” must be mounted to the front and rear of the overall shipment. Signs must be a minimum of 12′ in height and 6′ in width with a yellow background and black letting with lettering thickness no less than 4 cm (1 5/8″) thick.

Manitoba DOT contact and other information.

Manitoba DOT – Central Permit Office
Telephone help line, Winnipeg; 877-812-0009 or 204-945-3961 (compliance: 204-945-3890)
Fax line: 204-945-3961
Hours of service: 7:30 AM until 6 PM Monday thru Friday – CENTRAL TIME ZONE.
Manitoba DOT oversize and overweight trucking permits website.
Manitoba spring thaw road restrictions information.
Manitoba DOT axle and axle group weight definitions and restrictions.
Manitoba province current road conditions and closure information.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Manitoba Province DOT Permits office before commencing movement.
[codepeople-post-map]

See also:

Manitoba frost and thaw laws.
Frost law introduction.
Manitoba road closures and reports.
How to start a pilot car company.
Manitoba heavy-haul trucking companies.
Manitoba pilot cars and truck escorts.

manitobacoatofa

Montana state shipping regulations.

Montana state shipping regulations.

2021 Montana oversize and over-weight shipping laws and regulations.

Official 2021 Montana state over the road transport laws, regulations, and guidelines. Legal maximum dimensions and/or weight limits. Shipments in excess of the following weights/dimensions will require special permit approval from the state.

Maximum dimensions/weights allowed without a permit.

Any shipment exceeding any of the following dimensions or weights requires a special permit issued from the state.

Length: 75 feet maximum combined total overall.
Width: 8’6″.
Height: 14 feet.
Weight: 80,000 pounds. 20,000 pounds on any steer axle. Divisible loads may exceed 80,000 without an overweight permit as long as all axle group spacings and weights are legal. Truck drivers must have a special DMV endorsement for additional weight.

Maximum dimensions/weights of routinely permitted shipments.

If a proposed shipment is in excess of any of the following dimensions or weights it is considered a superload. Superloads require extensive review in order to be granted permits.

Length: 110 feet (33.528 meters).
Width: 18 feet (5.4864 meters).
Height:  17 feet (5.1816 meters) on most routes.
Weight: 100,000 pounds (45359.237 kilograms).

When pilot cars/escort vehicles are required.

If your shipment pertains to any of the following you will be required to have pilot cars or escorts.

Length: On two-lane roads over 105′ one pilot car or escort vehicle in the rear is required. Four lanes over 120’ only require one pilot car or escort vehicle in the rear.
Width: Two lanes over 12′ one pilot car or escort vehicle in front. Two lanes over 14′ one pilot car or escort vehicle in front and one pilot car or escort vehicle in the rear. Four lanes 14′ to 18′ one pilot car or escort in the rear.
Height: Not Specified; Up to the company because they are responsible for all structures.

Travel times and holiday restrictions.

Continuous travel is permitted for loads not exceeding 10′ wide, 15′-6″ high, or 110′ in length.  Daylight hours are 1/2 hour before sunrise to 1/2 hour after sunset. Saturday and Sunday travel is allowed for loads not exceeding 18′ wide, 18′ high, or 120′ in length except on designated highways – refer to your actual permit instructions.

Restricted travel routes should be documented on your permit. Restricted routes do not permit travel after 3:00 pm Friday thru Saturday, and from 12:00 PM on Sunday until sunrise on Monday if the dimensions exceed 10′ wide, 14′-6″ high or 110′ in length. No travel is permitted after 4:00 pm Friday until Monday morning if the dimensions exceed 18′ wide, 18′ high, or 120′ in length.

Holiday travel is usually permitted for loads that do not exceed: 10′ wide, 14′-6″ high or 110′ in length.

Superload information.

Superload (class 1) Loads exceeding 18 feet wide up to 34 feet wide, 17 feet high up to 24 feet high, and/or 150 feet long up to 200 feet long, must obtain the appropriate department district administrator or designee approval of a completed super-load permit application. The department’s decision on a complete super-load application for these dimensions must be issued within two working days of a properly completed application submittal. At the discretion of the MCS administrator or designee, any restricted travel may be waived.

Superload (class 2) Loads exceeding 34 feet wide, 24 feet high, and/or 200 feet long must obtain the appropriate department district administrator or designee approval of the super-load permit application. The department’s decision on a super-load application for these dimensions must be issued within five working days of a properly completed application submittal. At the discretion of the MCS administrator or designee, any restricted travel may be waived.

Truck & trailer. Required lights, signs, banners, flags, etc.

(1) Vehicles exceeding 10 feet in width must:

(a) Display a sign with the words “OVERSIZE LOAD” or similar wording which must be mounted at any visible height on the front and rear of the load. Letters shall not be less than 8 inches in height. The letters shall be black in color on a yellow colored background with the exception of digital signs.

(b) On the power unit, flashing amber lights, a minimum of five inches in diameter, 50 candlepower, 60 to 90 flashes per minute, shall be mounted at each end of the oversize load sign and visible 360 degrees. A single revolving light or strobe light may be substituted for flashing lights. Lights shall be flashing at all times when moving an oversize vehicle or load.

(2) Pilot vehicles may be required under ARM 18.8.511A in lieu of “oversize load” signs and flashing lights.

(3) Towing vehicles must be equipped with two-way radio communications if pilot vehicles are required under ARM 18.8.511A.

(4) Oversize load signs must be removed from the vehicle upon completion of the highway movement which necessitated the signs.

Reference credit: 18.8.510B Oversize load signs.

Pilot cars/escort vehicles. Required lights, signs, banners, flags, etc.

(1) A pilot vehicle may be any passenger car or two-axle truck a minimum of 60 inches wide. The maximum manufacturer’s rating for the pilot vehicle shall not exceed a gross vehicle weight rating of 14,000 pounds. Service or mechanic trucks owned or contracted by the permittee and used as a pilot vehicle shall not exceed a gross vehicle weight rating of 26,001 pounds. A pilot vehicle may not exceed legal limits of size and weight. Trucks used as pilot vehicles shall be clearly distinguished from and identifiable as the escort vehicle. A pilot vehicle may pull a trailer or carry any item or equipment which:

(a) is within legal limits of size and weight;

(b) allows an unobstructed view of the flashing lights and signs used by the pilot vehicle;

(c) complies with all state traffic laws; and

(d) possesses current registration and valid insurance.

(2) Service or mechanic trucks used as pilot vehicles must not have a utility box that extends above the cab more than 12 inches or beyond the width of the cab more than 6 inches on either side.

(3) A sign with the words “oversize load” or similar wording shall be visible from the front of the vehicle and rear of the vehicle at all times when piloting an oversize load. Letters shall not be less than 8 inches in height. The letters shall be black in color on a yellow colored background with the exception of digital signs. When not being operated as a pilot vehicle, signs must be removed.

(4) Flashing amber lights, visible 360 degrees, shall be mounted at each end of a sign with the words “oversize load” or similar wording, on the roof of the pilot vehicle. A revolving or strobe light may be substituted for flashing lights. Lights shall be flashing at all times when piloting an oversize load.

(5) All pilot vehicles shall be equipped with two-way communication.

(6) Pilot vehicles must remain within 1,000 feet of the permitted vehicle or load.

Reference credit: Regulations and equipment for pilot vehicles as defined in ARM 18.8.510(A).

How to apply for oversize/weight trucking permits.

Montana Motor Carrier Service Division
2701 Prospect Avenue
Helena, Montana 59620

Phone: 406-444-6130 or 406-444-7262
Permits are valid for 3 days.  The basic fee is $10.00
More information.

Mountain Time ZoneMontana DOT regulations

See also:
Montana frost/thaw restrictions.

Resource credits:
Montana permit restrictions.
Montana rule subchapter 18.8.6.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. Every effort is put into maintaining the accuracy of this information however you must verify it with the Montana State DOT Permits office before commencing movement.
montana-state

 

 

Nebraska State Shipping Regulations

Nebraska State Shipping Regulations

2021 Nebraska state shipping laws, rules, regulations, limitations for oversize and heavy-haul trucking permits.

Nebraska oversize, heavy-haul trucking permits.

Nebraska oversize and heavy-haul trucking companies for hire.
Nebraska pilot car companies for hire.
Nebraska oversize and heavy-haul permits.

Do I need a trucking permit? Legal load limits.

Nebraska maximum load limits until a trucking permit are required.

Length: Overall no longer than 85 feet on designated highways.  The trailer length maximum is 53 feet.
Weight: 80,000 pounds GVW, 20,000 pounds on a single axle, 34,000 pounds on tandem axles.
Width:  8 feet and 6 inches.
Height: 13 feet and 6 inches
Overhang: No set rules, case-by-case.  We figure 3 feet of front or rear should be safe but by no means is that policy. For clarification be sure to refer to your permit.
Notes: For documentation refer to Nebraska legal limitations for transport.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Texas:

Length: Up to 120 feet long is routine. Anything over will be assessed but limits are relaxed.
Weight: They do not use the federal bridge formula. 20,000 pounds per axle is the maximum. Anything over 110,000 pounds combined overall is going to be a superload. 20,000 pounds on a single axle, 40,000 pounds on tandem axles, 60,000 pounds on tridum axles, 80,000 pounds on quadem axles.  A Dummy axle must carry a minimum of 8,000 pounds or 8% of the gross total weight.
Width: Figure up to 14 feet as a routine permit.  They are strict on width and over 14 feet wide is going to be looked at as superload unless it’s a light load. Case-by-case but if you are heavy you may need approval from Lincoln, NE (up to 5 days processing times).
Height: Up to 14 feet and  6 inches is considered routine and some routes may require a high pole. If you are over 16’ feet a high pole is mandatory.

Nebraska superloads.

Requirements for extra-heavy or over-dimensional (superloads in NE):

For the purpose of this reading, you can figure superload dimensions are anything that is in excess of the dimensions or weights mentioned above in “routine”. If you are close then it will be up to the state to determine if you must file for your permit as a superload or not. See actual Nebraska state oversize and heavy haul trucking laws.

Legal travel times for oversize and heavy-haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

Travel time is a half-hour before sunrise and a half-hour after sunset leniency rule.  Weekend travel is permitted but they do have travel time restrictions around Lincoln, NE, and Omaha, NE during both weekdays and weekends.  Travel is prohibited on most all holidays and the day after Thanksgiving.

Lights, safety flags, and warning signs for heavy haul and oversize loads.

Required marking, safety flags, warning signs for heavy haul and oversize loads:

All loads being shipped in Nebraska must be marked with oversize load signs shipments are also required to have square red or orange fluorescent flags on all four corners to include the power unit and must be 18 inches. Pilot cars or escort vehicles that are used during the shipment must have flags in the front if leading or the rear if chasing. One revolving amber light must be on the top of the power unit as well as on the top of the pilot car. All signs must be yellow and background with black letters no less than 10 inches in height. For nighttime moves on shipments that are in excess of 12 feet wide a light bar attachment is required to be mounted on the rear of the load at a height that is clearly visible by motorists approaching from the rear.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanied by an escort vehicle or pilot car if:

Length: 90’ one on the rear. Over 100’ needs a rear and a chase pilot car.
Width: They can impose a required pilot car for anything over 8’ 6”.  In some cases, a lightbar can be used in lieu of a pilot car. Loads over 12 wide on 4 lanes are required one rear escort. A front is required for loads on 2 lane highway over 12’ wide. Front and rear are required for loads over 14’ wide. Front escort with a height pole is required for 14’ 6” and over.
Height: Over 14’ 6” needs a pilot car, may need height pole depending on the route.
Overhang: If over 15’ one rear escort is needed.
Note: Allow 1 to 10 days for permits to be approved. Maximum speeds of 45 MPH if 4 or more lanes, 35 MPH is under 4 lanes. Also, read travel restrictions below.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

All escort vehicles or pilot cars must be equipped with an amber light or light bar and must have a left and right side flashing or Rotary amber or yellow light of sufficient size that will be visible 360° from a distance of no less than 800 feet. Lights must be a minimum of 50 candle power bulbs. Lights must be no less than 6 inches in diameter.

Heavy lift being shipped in Nebraska.

Nebraska DOT contact information and notes.

Nebraska DOT office and permit contact information:

Physical and mailing address:
Nebraska Department of Roads
1400 NE Highway 2, Permit Office, Room 123
Lincoln, NE  68509
Telephone: 402-471-0034
Hours: Monday – Friday 7:30 AM – 5:00 PM

Central Daylight Time

Nebraska cities serviced.

 

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Nebraska State DOT Permits office before commencing movement.

 [codepeople-post-map]

nebraska-state

 

Illinois State Shipping Regulations for oversize and heavy haul.

2021 Shipping laws and regulations for shipping oversize and over-weight loads in the state of Illinois.

Illinois

The great state of Illinois official seal.

Please share your expertise or knowledge of Illinois state shipping regulations with other visitors below.

Locate specialized trucking companies in Illinois.
Locate pilot car companies in Illinois.
Order oversize trucking permits.



Legal load limits in Illinois.
Illinois DOT legal load size & weight limitations.

Legal Loads.
Length:  65’ overall length maximum.
Width: 8’6” on the interstate and other designated highways, 8’ on non-designated highways.
Weight:  GVW 80,000,  Single 20,000, Tandem 34,000,   Tridem 42,000
Height:  13’6” is the maximum allowed height for legal loads.
Overhang:  3’ front in the front and 3’ off of the rear of the trailer.

Routine oversize shipping, trucking and transport permits.
Oversize and overweight trucking permits that are routinely issued by the state of Illinois.

Length:  Up to 145’ long. Anything longer refer to the superload section below.
Weight:  Single 24,000, tandem: 48,000, tridum: 60,000, Quadem: 60,00 gross, 5 Axles 100,000 lbs., 6 Axles 120,000 lbs., 7 axels: 120,000, 8 axles: 120,000 lbs.
Width: 14’6” (any load over 16′ will require special admin approval before a permit is issued).
Height: 15’ (any load over 16′ tall requires a route survey).

Superload information:
Illinois DOT superload information.

Length: Any load that is longer than 145′ is considered a superload.
Width: Any load that is in excess of 14′ 6″ in width is considered a superload.
Height: Any load that is in excess of 15′ 6″ in height is considered a superload.
Weight: Any load that exceeds 120,000 lbs on any standard axle configuration whether it’s a 6,7 or 8 axle configuration or not is considered a superload.
Overhang: Contact them as this varies depending on the route.
Notes: Spacing between steer and first tandem must be more than 8′ 1″. The spacing before the first axle and the trailer must not exceed 18′ 6″.  All axle spacings combined must not be less than 43′ 6″. Superload permit processing times vary. Expect delays. Before requesting a route you are expected to do as much research on your own as possible. They will refer you to GettingAroundIllinois for construction zones and other closures. 

Permitted travel times and restrictions in Illinois:
Illinois travel times and restrictions for oversize loads.

Travel is permitted from ½ hour before sunrise to ½ hour after sunset  Monday thru Friday and ½ hour before sunrise until 12PM on Saturdays. Loads that are overweight only may travel 24/7 on all days of the week (make certain it is not documented otherwise on your permit before doing so). No travel is permitted on Sundays unless you are below the routine permit standards of no more than 115′ in length, 12′ in width, 13′ 6″ in height (sunrise to sunset rules apply).  No movement is permitted on the major holidays: New Years Day, Memorial Day, Independence Day, Labor Day, Thanksgiving Day, and Christmas Day. Travel stops at 12PM on the day before any of these holidays. The Illinois oversize load permit office is closed on MLK Day, Lincoln’s birthday, Washington’s birthday, Columbus Day, Election Day, Veterans Day, and on the day after Thanksgiving. However, travel is not restricted on these days. Always refer to your permit for approved travel times.

Required shipment, truck and trailer markings:
Truck, trailer, and shipment required signs, banners, and flags.

A rotating amber light must remain on at all times mounted on top of the cab and be visible from 360 degrees from a minimum of 500′ in direct sunlight. If your overall length is more than 80′ in length you are required to have one amber light over the cab of the truck and one amber light no more than 10′ from the rear of end or trailer/load at the highest point that is practical. Oversize load signs must be a minimum of 7′ in width x 18″ in height, have a yellow background color with black lettering no less than 10″ in height x 1″ thick – we have recently heard 12″ tall x 2″ thick so please clarify and comment below if you know which is correct. Flags are required at all 4 corners of the load and front of the truck and are to be safety red in color and no less than 18″ square. Shipments over 75′ in length, 10′ in width, or 14′ 6″ in height are required to have signs. Signs must be placed on the front and rear extremities of the truck, trailer, or load.

When pilot cars are required:

Length: If over 110′ in length you are required to have a minimum of 1 pilot car and in some places 2 pilot cars (higher traffic density or certain times of year). If over 145′ (150′ in some very rural areas) in length you are required to have 3 pilot cars –  yes 3. If over 175′ in length a police escort will be required.
Width: Up to 14’6” requires 1 pilot/escort vehicle. Over 16’ requires 2 pilot/escort vehicles. Over 18′ in width will require a police escort. 
Height: Up to 14’ 6” 1 pilot/escort vehicle, over 16’ requires 2 pilot/escort vehicles. Over 18′ in height will require a police escort.
Weight: No requirements as long as you can maintain minimum speeds. However, on bridge moves that require all other vehicle traffic to be removed will require an appropriate number of pilot cars which is a minimum of 2 and possibly 3 with police escort. All areas are different and require evaluation.
Note: If you exceed any two dimensions, then you are required to have an additional pilot car. So if you’re over 14′ 6″ tall and 14′ 6″ wide you would be required to have 2 pilot cars.  

Required pilot car certifications:

Cars, vans, or trucks may be used as long as the gross weight of the pilot car vehicle is rated at no more than 8,000 lbs. Pilot car driver must be 18 years of age minimum with a valid regular driver’s license. Pilot cars must have a rotating or flashing amber light mounted on the top of the vehicle. Must display a red flag at all 4 outermost points of the vehicle and have “OVERSIZE LOAD” signs that are a minimum size of 5′ wide x 12″ tall and have black lettering no less than 8″ in height. Must have radio and be in constant communication with the driver transporting the shipment at all times. Must have $500,000 per occurrence combined insurance that covers property and body.

How to apply for trucking permits:

Illinois Department of Transportation – DOT
Bureau of Traffic, 2300 S Dirksen Parkway
Springfield, IL  62764

Email: dot.permitoffice “at” illinois.gov
General inquiry phone: 217-782-6273
Phone: 217-785-1477 or 800-252-8636 within the state.
Fax: 217-728-3572

Note: Fee varies depending on dimensions and miles traveled. A permit is valid for 5 days.

Hours: from 8 AM until 4:30 PM

Central Time Zone

 

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Illinois State DOT Permits office before commencing movement.

illinois-state

Alaska Shipping Regulations. Heavy-haul and oversize trucking.

2021 Alaska DOT shipping laws, rules, regulations for oversize and heavy-haul trucking.

Alaska shipping regulations for oversize and overweight trucking and DOT permit information.

The great state of Alaska official seal.

Share your knowledge with others below.!

Heavy haul trucking, pilot cars and permits.

Locate heavy haul, oversize equipment shipping companies, pilot cars and ordering trucking permits in Alaska:

 

Legal load limits.

Length:  53’ Trailer Length
Width:  8’6”
Height: 14’
Weight: Depending on route 80,000 lbs GVW.
Overhang: 3’ in the front, 4’ in the rear.

Kenworth double trailers in compliance with 80,000 pounds GVW laws.

Alaska requires any shipment over the weight of 80,000 pounds to have a special trip permit.

Routine trucking permits.

Trucking oversize and overweight permit limits:

Length: Shipping varies due to routing and season.
Width: Shipping rules vary depending on route and seaason.
Height: Over 14′ and once again everything varies depending on routing and season.
Weight: Single; 30,000 lbs, tandem; 56,000 lbs, tridem; 70,000 lbs, quadem 80,000 lbs, gross weight; 150,000 lbs. Depends on the route you wish to travel, distance and the bridges you intend on crossing.
Overhang:  20′ is a safe number but once again everything up here is seasonal as roads are closed or combined with weight frost laws may be in effect and limit you.  For the most part there is no such thing as a “routing” shipment in Alaska.

Notes:  When between the months of October 1 and March 31 for 1, 2 & 3 drive axle groups on truck tractors intending to travel the Dalton, Elliott or Steese highways between Fairbanks and Prudhoe Bay you can shift your legal axle weights to make them legal. The following weights on these routes apply: single; 22,000 lbs with 8′ 1″ minimum spacing between axles, tandem; 42,000 lbs, tridem; 48,000 lbs maximum.

When a pilot car is required.

Pilot car (escort vehicle) requirements:

Length: if overall length exceeds 85′ you are required to have 1 pilot car (escort). If overall length exceeds 100′ you are required to have 1 front and 1 read pilot car (escort).

Width: If 10′ to 12′ wide you will be required to have 1 pilot car (escort vehicle). If width exceeds 12′ and up to 14′ you are required to have 1 front and 1 rear pilot car (escort vehicle). From 14′ to 18′ in width you will be required to have 3 pilot cars. 2 front on 4 lane and 2 rear on 2 lane roads with the additional at either end. 18′ up to 22′ in width will require 4 pilot cars (escorts); 2 in front and 2 on the rear. If over 22′ in width you will be required to “close and roll” (closing the road as you move) requiring you to have 5 pilot cars as well as a minimum of 1 police escort.

Weight: You may be required to have a pilot car/cars if you are not able to maintain the minimum speed limit and on some designated bridge crossings depending on your weight class.

Overhang: If overhang is greater than 20′ you will be required to have 1 pilot car vehicle. If over 35′ you will be required to have 1 front and 1 rear pilot car.

Required shipment markings & flags.

Truck, trailer and shipment required signs, banners & flags:

For loads that are over 8′ 6″ in width you will be required to have a “OVERSIZE LOAD” banner on the front or your truck and on the rear of your truck or load, whichever is most practical. Flags must be a minimum length of 16″ and be safety orange or red in color.

Pilot car certifications & requirements.

Pilot car (escort vehicle) certifications & requirements:

A pilot car must be manufactured  as a passenger vehicle (car, truck, van, etc.) with a manufacturers weight of less than 10,000 lbs. All pilot car drivers must be wearing a safety colored vest, jacket or shirt. All pilot cars must be equipped with a rotating, strobe or flashing amber light visible from 360 degrees from a distance of no less than 500′. Vehicle must have a regulations sized hand help SLOW – STOP sign, safety colored flags of no less than 18″ in either direction, 8 road safety flares, 3 reflective road triangles, a 2-way communication device capable of transmitting at least 10 miles and a type A, B and C fire extinguisher.

Travel times and restrictions.

Travel times and restrictions:

Approved permits are valid for 3-5 days unless otherwise stated. Travel times are from Monday through Saturday at noon during daylight hours – the one half hour before sunrise to one half hour after sunset rule applies. However, vehicles not exceeding 85′ in length, 16’in width or 16′ in height can travel Monday through Sunday during daylight hours only. Travel is NOT permitted on the following holiday weekends: New Year’s Day, Memorial Day, Fourth of July, Labor Day, Thanksgiving Day and Christmas Day.

Areas of high traffic densities are restricted from 7:00-8 AM and 4:30-6:00 PM in certain areas (refer to your permit for documentation). Movement is NOT permitted on Kalifornsky Beach Rd, Kenai Spur highway or the Sterling highway from 6:45-9:00 AM and 2:15-4:30 PM during the school months for shipments in excess of 14′ in width. Ketchikan has restricted movement from 7:00 AM to 8:00 AM and from 12 noon – 1 PM and from 4:30 PM to 6:00 PM.  Glenn and Parks Highways to Palmer and Wasilla between the hours of 6:00-8:00 AM and from 11:30-1:00 PM and from 4:30 until 6:00 PM if over 14′ in width.

Frost and thaw laws.

Frost and thaw laws:

Frost and thaw laws are in effect usually from March 1 until mid June on major routes, southern central and the interior. There are so many roads that have different regulations on thaw laws and frost laws. You absolutely will want to call the Alaska State DOT office at the number below for more information. Example: A particular highway may have a set of regulations until you reach a certain mile post, then after that has a whole different set of regulations. There are hundreds of them similar.

Alaska DOT & information.

Alaska state DOT trucking permit contact information:

Division of Measurement Standards Phones:  907-365-1200 or below within Alaska.
Commercial Vehicle Customer Service Center: 800-478-7636
Huffman Business Park
11900 Industrial Way
Anchorage, AK  99515

Phone help line: 907-365-1200
Toll free within Alaska: 800-478-7636
Fax: 907-365-1204
Permit office hours: 8 AM – 5 PM
PACIFIC STANDARD TIME

Alaska state DOT website with all kinds of permit info, forms, manuals, etc here. Alaska heavy-haul and oversize trucking laws.
Road closures and highway conditions here.
Alaska road closure information.

Cities in Alaska: Adak, Akhiok, Akiachak, Akiak, Akutan, Alakanuk, Alatna, Alcan Border, Aleknagik, Aleneva, Allakaket, Alpine, Ambler, Anaktuvuk Pass, Anchorage municipality, Anchor Point, Anderson, Angoon, Aniak, Anvik, Arctic Village, Atka, Atmautluak, Atqasuk, Attu Station, Barrow, Bear Creek, Beaver, Beluga, Bethel, Bettles, Big Delta, Big Lake, Birch Creek, Brevig Mission, Buckland, Buffalo Soapstone, Butte, Cantwell, Central, Chalkyitsik, Chase, Chefornak, Chenega, Chevak, Chickaloon, Chicken, Chignik, Chignik Lagoon, Chignik Lake, Chiniak, Chisana, Chistochina, Chitina, Chuathbaluk, Circle, Clam Gulch, Clark’s Point, Coffman Cove, Cohoe, Cold Bay, Coldfoot, College, Cooper Landing, Copper Center, Copperville, Cordova, Covenant Life, Craig, Crooked Creek, Crown Point, Cube Cove, Deering, Delta Junction, Deltana, Diamond Ridge, Dillingham, Diomede, Dot Lake, Dot Lake Village, Dry Creek, Eagle, Eagle Village, Edna Bay, Eek, Egegik, Eielson AFB, Ekwok, Elfin Cove, Elim, Emmonak, Ester, Evansville, Excursion Inlet, Fairbanks, False Pass, Farm Loop, Ferry, Fishhook, Flat, Fort Greely, Fort Yukon, Four Mile Road, Fox, Fox River, Fritz Creek, Funny River, Gakona, Galena, Gambell, Game Creek, Gateway, Glacier View, Glennallen, Golovin, Goodnews Bay, Grayling, Gulkana, Gustavus, Haines, Halibut Cove, Happy Valley, Harding-Birch Lakes, Healy, Healy Lake, Hobart Bay, Hollis, Holy Cross, Homer, Hoonah, Hooper Bay, Hope, Houston, Hughes, Huslia, Hydaburg, Hyder, Igiugig, Iliamna, Ivanof Bay, Juneau city and borough, Kachemak, Kake, Kaktovik, Kalifornsky, Kaltag, Karluk, Kasaan, Kasigluk, Kasilof, Kenai, Kenny Lake, Ketchikan, Kiana, King Cove, King Salmon, Kipnuk, Kivalina, Klawock, Klukwan, Knik-Fairview, Knik River, Kobuk, Kodiak, Kodiak Station, Kokhanok, Koliganek, Kongiganak, Kotlik, Kotzebue, Koyuk, Koyukuk, Kupreanof, Kwethluk, Kwigillingok, Lake Louise, Lake Minchumina, Lakes, Larsen Bay, Lazy Mountain, Levelock, Lime Village, Livengood, Lowell Point, Lower Kalskag, Lutak, McCarthy, McGrath, McKinley Park, Manley Hot Springs, Manokotak, Marshall, Meadow Lakes, Mekoryuk, Mendeltna, Mentasta Lake, Metlakatla, Meyers Chuck, Miller Landing, Minto, Moose Creek, Moose Pass, Mosquito Lake, Mountain Village, Mud Bay, Naknek, Nanwalek, Napakiak, Napaskiak, Naukati Bay, Nelchina, Nelson Lagoon, Nenana, New Allakaket, Newhalen, New Stuyahok, Newtok, Nightmute, Nikiski, Nikolaevsk, Nikolai, Nikolski, Ninilchik, Noatak, Nome, Nondalton, Noorvik, North Pole, Northway, Northway Junction, Northway Village, Nuiqsut, Nulato, Nunapitchuk, Old Harbor, Oscarville, Ouzinkie, Palmer, Paxson, Pedro Bay, Pelican, Perryville, Petersburg, Petersville, Pilot Point, Pilot Station, Pitkas Point, Platinum, Pleasant Valley, Point Baker, Point Hope, Point Lay, Point MacKenzie, Pope-Vannoy Landing, Portage Creek, Port Alexander, Port Alsworth, Port Clarence, Port Graham, Port Heiden, Port Lions, Port Protection, Primrose, Prudhoe Bay, Quinhagak, Rampart, Red Devil, Red Dog Mine, Ridgeway, Ruby, Russian Mission, St. George, St. Mary’s, St. Michael, St. Paul, Salamatof, Salcha, Sand Point, Savoonga, Saxman, Scammon Bay, Selawik, Seldovia, Seldovia Village, Seward, Shageluk, Shaktoolik, Sheldon Point (Nunam Iqua), Shishmaref, Shungnak, Silver Springs, Sitka city and borough, Skagway, Skwentna, Slana, Sleetmute, Soldotna, South Naknek, Stebbins, Sterling, Stevens Village, Stony River, Sunrise, Susitna, Sutton-Alpine, Takotna, Talkeetna, Tanacross, Tanaina, Tanana, Tatitlek, Tazlina, Teller, Tenakee Springs, Tetlin, Thoms Place, Thorne Bay, Togiak, Tok, Toksook Bay, Tolsona, Tonsina, Trapper Creek, Tuluksak, Tuntutuliak, Tununak, Twin Hills, Two Rivers, Tyonek, Ugashik, Unalakleet, Unalaska, Upper Kalskag, Valdez, Venetie, Wainwright, Wales, Wasilla, Whale Pass, White Mountain, Whitestone Logging Camp, Whittier, Willow, Willow Creek, Wiseman, Womens Bay, Wrangell, Y, Yakutat.

Additional information:

Heavy haul and oversize trucking permit limitations.

Maximum weights; on a single axle with dual tires 30,000 pounds. With tandem axles 56,000 pounds, with tridem axles 70,000 pounds, with quadem axles 80,000 pounds. Gross maximum is 150,000 pounds. All of this depends entirely on the route you choose to travel as well as distance and any bridges that you intend to cross. It also depends upon the length, height and width of the shipment. Between the months of October 1st and March 31st for one, two and three drive axle groupings on trucks and truck tractors traveling the Elliott, Steese and Dalton highways between Fairbanks and Prudhoe Bay you can shift legal axle weights in the following weights on these routes in applicable: single axles 22,000 pounds (with 8’1″ minimum axle spacing). Tandem axles 42,000 pounds, tridem axles 48,000 pounds. The maximum height allowed is 15’3″. Shipments over 14 feet wide or 150 feet long or 16’6″ in height must supply to the permitting department the exact route they wish to travel.

Heavy haul and oversize truck signs and flags.

A standard oversize load sign is required on the front of the tractor and the rear of the shipment if it exceeds 8’6″ and width. The sign must be yellow and have a minimum of 48 inches in width with black letters that are 10 inches tall and 2 inches wide. Acceptable signs when specified shall read “oversize”, “oversize load” or “wide load” for over width vehicles and/or shipments “oversize”, “oversize load” or “long load” for over length vehicles must be affixed to the rear of shipment when overall load exceeds 60 feet in length. Vehicles and loads with rear overhang exceeding 10 feet are subject to the following: must have “oversize” or “oversize load” signs and a amber high intensity rotating, flashing, oscillating or strobe type beacon which must be visible for a minimum of 500 feet from the end of the shipment. You must have either an extended light-bar or a rear pilot car or escort vehicle. All flags must be a minimum of 16” square and must be red. Flags are required to be on vehicles with loads wider than 10 feet and if overhang exceeds the legal limits in any direction.

Pilot car and escort vehicle requirements.

If the width of the shipment is over 10’6″ and up to 12 feet one pilot car or escort vehicle is required. For lengths over 85 feet and up to 100 feet one pilot car is required. If overhang is greater than 10 feet but less than 20 feet one pilot car or escort vehicle may be used. It is possible to use an extended lightbar and place of a rear pilot car. Heavy haul or overweight shipments with special bridge conditions are required to have two pilot cars if the width is 12 feet up to 14 feet to pilot cars or escort vehicles are required if the length is greater than 100 feet to escort vehicles or pilot cars are required. If the overhang exceeds 20 feet unless the rear is greater than 35 feet or the front greater than 60 feet one pilot car is required. For widths over 14 feet three pilot car vehicles or escort’s are required: two in the front and one in the rear. If you have overhang from the rear that is greater than 35 feet to pilot cars are required and for widths up to 18 feet but not more than 22 feet 4 pilot cars or escort vehicles are required. If road closures exist and you are an excess of 22 feet wide then you will be required to have 5 escorts or pilot cars. You may be permitted to use an extended light-bar when up to 20 feet of rear overhang and lieu of a rear pilot car.

Pilot car and escort vehicle requirements.

Pilot cars and escort vehicles may be passenger trucks and cars as long is they are under 10,000 pounds in total weight. Pilot cars and escort vehicles must carry commercial vehicle insurance. Pilot cars and escort vehicles will not carry any passengers. Pilot cars and escort vehicles will not act as a steer man or a tiller man for any load. Oversize load signs and beacons: all escort vehicles and pilot cars are required to be equipped with the appropriate signage. Depending upon the shipment you are working with this might be oversize, wide load or long load and the sign must be roof mounted with a high intensity rotating flashing oscillating or strobe type amber beacon light which must be visible from a minimum of 500 feet in any direction. When a pilot car or in escort vehicle is required to lead any oversize load the appropriate sign must be faced towards the front of the pilot car or escort vehicle when the pilot car or escort is chasing a load the appropriate sign must be faced towards the rear of the vehicle. Pilot car companies and escort vehicle drivers shall carry the following items and equipment at all times when escorting heavy haul and oversize loads: a 24 inch stop slow paddle sign, three bidirectional emergency reflective triangles, 15 pound rated B and C fire extinguisher, a reflector rise orange vest shirt or jacket, a first aid kit, a flashlight with extra batteries, a red cone and be equipped with a red hand flag.

Flag men or flag persons.

The state of Alaska does not require a pilot car or escort vehicle operator to have certification to perform flagging functions flaggers and or pilot car or escort vehicles operators shall complete the state approved flagging test as well is any necessary training prior to working in the capacity of a flagger. There is a fee for the online class. Flag persons shall not be less than 18 years of age and must be capable of carrying out flagging responsibilities in accordance with the Alaska state traffic manual regulations flaggers must be wearing high visibility or florescent orange jackets and vest as well as equipped with a slow stop paddle and a red hand flag these items must be utilized by the pilot car company or escort vehicle operator in the event that it becomes necessary. If required pilot car and escort vehicle operators will need to pull over and Park in order to stop or control Highway traffic. At no time shall the slow stop paddle or red flags be displayed out of the window of a moving vehicle.

Travel time for heavy haul and oversize loads.

Heavy haul permits and oversize trucking permits are valid for 3 to 5 days unless otherwise specified. Travel is permitted from Monday through Saturday at noon during daylight hours. One half hour before sunrise to one half hour after sunset. However, vehicles that are not exceeding 10’6″ wide or 16 feet tall or 85 feet and linked total may travel Monday through Saturday during daylight hours. Oversize vehicles are allowed to operate during hours of darkness under special lighting and taping requirements. Travel is permitted on the following holiday weekends memorial day for for July and Labor Day. Urban areas do restrict travel during peak hours be sure to refer to your permit for specific travel times especially in urban areas.

Spring weight and frost laws.

Weight restrictions and frost laws usually occur on all major routes in South, Central as well as interior Alaska. Typical months are from March 1st until the 1st July.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Alaska State DOT Permits office before commencing movement.
Alaska DOT

Alaska DOT

 

Alaska state rules and regulations.

2019 Alaska state shipping regulations.

 

2021 British Columbia shipping regulations



2021 British Columbia DOT shipping regulations. Laws, regulations, rules and limitations for oversize or heavy-haul trucking.

British Columbia DOT regulations for oversize shipping.

British Columbia. The official Coat of Arms.

Please share your knowledge with our other visitors below.

Heavy-haul trucking & pilot car directory.
Locate trucking companies and pilot cars in British Columbia:

British Columbia heavy-haul trucking company directory.
British Columbia pilot car/truck escort company directory.

 

Legal load limits.
British Columbia legal load limits:

Length:  14.65 meters (48.06′) from the kingpin to the rear most portion of the trailer. No combinations in length over 23 meters (75.45′) overall without a permit. A 53 foot semi-trailer is allowed provided the lift axle is raised.
Width: No shipment may travel if in excess of 2.6 meters in width (without a permit) unless it is a shipment of hay which is limited to 3.1 meters (122″) or rear view mirrors which are limited to 30 cm (11.81 inches)on each side, additional auxiliary devices are allowed 30 cm (11.81 inches) and tires are allowed an additional 10 cm.
Height: No shipment may travel if larger than 4.15 meters (163″) in height without a permit.
Weight: Single axle: 9,100 kg (20,062 lbs) and the same for tandem and tridum axles. A tridem pole trailer: gross weight on any two adjacent axles in a tridum axle group must not exceed 17,000 kg (37,478 lbs). The maximum licensed gross vehicle weight of a vehicle or combination of vehicles must not exceed 63,500 kg* (139,994 lbs) without a permit (see; en B.C Regulation 95/2006, s. 3.)* THIS AMOUNT SEEMS EXCESSIVE. THIS IS THE NUMBER OUR RESEARCH PRODUCED. See; reference link below in “notes” under “maximum gross weight”. See also “comments” at bottom.
Notes: Not matter what a permit states if there is a sign posted on a highway or road that contradicts your permit the sign will take precedence over the permit so you must immediately stop traveling and get clarification. Section reference: Copyright Queens Printer Victoria, British Columbia, Canada.
Overhang: 1m in front and .061 – which seems a little odd to us as the rear maximum seems short. Please contact the BC DOT to verify.

Routine trucking permits.
Oversize and overweight trucking permits that are routinely issued by the British Columbia DOT routinely:

Length: 27.5 meters (90 feet, 2 and 43/64 fourths on an inch) in the maximum length for a routine permit in B. C.
Width: 4.4 meters (14 feet, 5 and 15/64 fourths of an inch) is the maximum with you will get from BC DOT on a routine permit.
Height: There is no number provided. The British Columbia DOT permit office wants to assess every load that is over height based on intended routing.
Weight: This is the same as height. They will not give you a solid number for routine. We are going to suggest 63,500 kg (134,994 lbs) since we had trouble locating what we feel was a reasonable maximum limit above for “legal loads limits”. we sure welcome your comments below.
Overhang: 6.5 meters (21 feet, 3 and 29/32 seconds of an inch) for routine permits for overhang.

NOTES: If your shipment is oversize AND overweight you will be required to have two separate permits. Oversize loads are required to have safety flags no less than 16″ x 16″ (46.64 cm) square and be red in color.

Superload information- extraordinary loads.
British Columbia superload information:

Superloads in British Columbia or “extraordinary loads” are defined by the DOT any shipment that is in excess of 85,000 kilograms GVW in weight, 4.4 meters (14 feet, 5 and 15/64ths of an inch) in width, 4.88 meters (16 feet and 1/8th inches) in overall height. Depending on your route you may not be classified as a “Superload” as the British Columbia DOT has  pre-approved designated routes. You can find more (limited) information on super or extraordinary loads here.

Permitted travel times & restrictions.
British Columbia DOT travel times and restrictions for oversize and overweight trucking:

The rule of daylight is defined as 1/2 hour before sunrise to 1/2 hour after sunset in B. C. No travel is allowed after 2 PM on Friday until 12:01 AM on Monday for any load in excess of 3.8 meters (12′ 6″) in width. If your shipment is over 3.5 meters (11′ 6″) in width you are only allowed to travel during daylight hours only with the exception of the Peace River region. For holiday travel restrictions you may not travel after 2 PM on the day before the holiday and after 12:01 on the day after the holiday. Holidays are New Years day, Provincial day, Good Friday, Victoria day, Canada day, Family day, Labour day, Thanksgiving day, Remembrance day, Christmas day and Boxing day.

When pilot cars are required.
British Columbia DOT requires a pilot car (escort vehicle) to accompany your shipment if you are in excess of any of the following dimensions or weights:

Length: For shipments in excess of 27.5 meters (90′) in length you will be required to have 1 rear pilot car (escort vehicle) on all roads. For shipments over 27.5 meters (90′) in length 1 front pilot car/escort and 1 rear pilot car/escort is required.
Width: Shipments in excess of 3.5 meters (11′ 6″) wide you will be required to have 1 front pilot car on two lane roads or 1 rear pilot car/escort on multiple lane roads. In some cases a beacon light may be substituted. In many cases night travel is granted at 304.8 cm (10′ wide). If granted night travel you may be required to have 1 pilot car/escort in the front if your shipment is over 3.2 meters (10′ 5 and 63/64 fourths of an inch”) in width. Shipments that are over 3.5 meters (11′ 5 and 51/64 fourths of an inch”) wide up to 4.4 meters (14′ 5 and 15/64 fourths of an inch) require 1 front pilot car/escort vehicle. Shipments that are over 3.5 meters (11′ 5 and 51/64 fourths of an inch”) wide are permitted to travel at night only.
Height: Depending on your route the BC DOT permit office will determine if you are required to have a pilot car/escort vehicle.
Weight: Weight is on a case by case basis. As long as your shipment can maintain the minimum required speed limit you will probably not be required to have a pilot car/escort by the British Columbia DOT permits office.
Overhang: If you are have more than 6.5 meters (21′ 3 and 29/32 seconds of an inch) of overhang you will be required to have 1 rear pilot car/escort.

Pilot car certifications.
Pilot car (escort vehicle) certifications and requirements for operating in British Columbia:

Pilot car/escort vehicle operators at this time are only required to: 1.) have a valid drivers license and 2.) be over 18 years of age.  We are getting reports that a certification program is in the works but at the time of this update (March 2, 2014) these above 3 requirements are all that is needed to operate a “pilot car” or “escort vehicle” within the Province of British Columbia (see comments below for more information). Also see; British Columbia Pilot Cars laws. Your vehicle is required to have a lighted sign box that is a minimum of 180 cm x 35 cm x 10 cm (72″ x 14″ x 4″),  have 2 – flashing lights mounted on the top of the sign box on each side with 2 amber strobe or rotating lights a minimum of 203 mm (8″) mounted between the flashing lights on top of the box as well.

The minimum acceptable size for a rotating amber light is 15 cm in diameter and for strobe lights 11 cm in diameter. Either type of lamp must emit light flashes in 360 degrees.

The sign box must light up and be visible from a minimum distance of 200 meters. The sign box must have either a red and white D sign or a yellow with black lettering stating “OVERSIZE LOAD”, “WIDE LOAD”,  OR “LONG LOAD”. If you have the “D” sign your letter must be no less than 20 cm (8″) in height with a 4 cm (1 5/8″) line thickness. If you have the yellow sign your lettering must be no less than 20 cm (8″) with a 4 cm (1 5/8″) line thickness. The sign box must be mounted on the top of the vehicle and covered when not in operation. You are also expected to have the following items inside of the vehicle: CB radio or high powered 2-way radio, first aid kit, fire extinguisher type A, B & C of at least a 2 liters, 3 reflective road triangles, 3 traffic cones, reflective vest (worn while working), slow/stop sign, 3 red or orange safety colored flags no less than 40 x 40 cm (16″ x 16″), nose cone flashlight and a hard hat.

Shipment, truck & trailer markings.
Truck, trailer and shipment required signs, banners and flags:

All trucks that are hauling oversize or overweight loads must have a strobe, flashing or rotating amber light mounted to the roof that is visible from 360 degrees at a minimum distance of 200 meters (656′). All 4 outermost corners of the overall shipment and any obtrusive points must have flags mounted to them that are safety red or orange in color no less than 40 cm x 40 cm (16″ x 16″) and have the flags exchanged for lighting if moving during the night. A sign stating the nature of the load; “OVERSIZE LOAD”, “WIDE LOAD” or “LONG LOAD” must be mounted to the front and rear of the overall shipment. Signs must be a minimum of 12″ in height and 6″ in width with a yellow background and black letting with lettering thickness no less than 4 cm (1 5/8″) thick.

British Columbia DOT & other information.
British Columbia DOT contact and other useful information:

British Columbia DOT – Central Permit Office
Telephone help line: 800-559-9688 or the have districts so click on area for phone and info.
Hours: 6 AM until 10 PM including (MOUNTAIN TIME ZONE). These offices are closed on Christmas, News Years Day and Boxing Day.

British Columbia DOT oversize and overweight permit applications online.
British Columbia DOT oversize and overweight permits manuals.
British Columbia Province road conditions and closures.
British Columbia HOS or hours of service rules and regulations
 -.pdf document.
British Columbia DOT spring thaw and frost laws.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the British Columbia Province DOT Permits office before commencing movement.
[codepeople-post-map]

See also:

Frost and thaw law introduction.
British Columbia frost laws.
How to start a pilot car company.
Pilot car company certification.
British Columbia road closures – traffic reports.

Alberta DOT Shipping Regulations



Province of Alberta DOT shipping regulations, limitations, rules and laws for the trucking of oversize and over weight loads over the roads and highways in the Province of Alberta.

Alberta Canada oversize and overweight shipping regulations.

Alberta Canada official coat of arms.

 Please share your expertise or knowledge with our other visitors below.

Trucking & pilot car directory.

Locate trucking companies and pilot car companies in Alberta:

Alberta trucking company directory.
Live pilot cars in Alberta.



Legal load limits.

Alberta DOT legal load limits:

Length: The overall maximum length allowed in Alberta without a permit is 23 meters (75′ 3″).
Width: The maximum width allowed is 2.6 meters (8′ 6″‘).
Height: The maximum height allowed in Alberta is 4.15 meters 13′ 7″.
Weight: 6,000 kg maximum on steer axle. Tandem axles: 17,000 kg. Tridum axels is 17,000 kilograms (37,478.6 lbs) as well. All axle weights are subject to the size of the tire.
Overhang: We have no information on allowable overhang in Alberta. Please share your knowledge with others below.
Notes:

* Super single tires require “New Generation, Wide Base” tires with a minimum tire width of 445 mm. Available by permit only. Super single tires do not apply to the steering axle.
** These weights for tridem axles apply to provincial highways only. The maximum weight for a tridem axle on a municipal road is 17,000 kg. Permits may be available to achieve heavier weights.
*** All axle weights are subject to minimum tire size. The maximum weight per tire shall not exceed the lesser of the tire manufacturer’s weight rating or the width of the tire stamped on the sidewall multiplied by 10 kg/mm.
Source: Alberta Transportation

Routine trucking permits.

Oversize and overweight trucking permits that are routinely issued by the Alberta DOT:

Length: 52 meters (170′ 8″) is about the maximum length you can get by with on a routine permit.
Width: 14′ 7″ wide depending on routing  for routine trucking permits.
Height: 5.3 meters (17′ 5″) in height is the cut off point for routine permits of course contingent on routing.
Weight: Weight is where you run into a problem. Alberta wants to know every single detail down to the size of tire you are running. Routing being a huge issue we can’t state a “routine” weight as it all depends on your axle spacings, combinations and tire sizes. Just for a safe number we’re going to say a routine permit caps out at 43,359.2 kilograms (100,000 lbs).
Overhang: 6.09 meters is about the most you can get on routine depending on routing.

Superload information.

Alberta superload information:

The maximum width normally allowed is 7.32 meters (24′) so anything over this width is a superload. We are researching information pertaining to shipping superloads in the province of Alberta Canada. If you happen to have expertise or knowledge of trucking superloads in this province please share your information for our other viewers below. Thank you.

Permitted travel times & restrictions.

Alberta DOT travel times and restrictions for oversize and overweight trucking:

The rule of 1/2 hour before sunrise until one full hour after sunset is observed in Alberta. Travel is allowed on Fridays until 3pm in the afternoon for loads that exceed 3.85 meters in width (12′ 7″) (WE WILL NEED TO DOUBLE CHECK THIS AS IT WAS LEFT AS A CORRECTION COMMENT BELOW). Travel is otherwise allowed and unrestricted on Saturdays unless stated on your permit.  Night travel is permitted for loads that are over length as long as you have 1 rear pilot car/escort vehicle and are on multiple lane roads. If your shipment is no longer than of 42 meters (137′ 10″) on a single lane road you will be required to have1 front pilot car/escort vehicle and 1 rear pilot car/escort vehicle. Weekend travel is permitted for loads that are over length only. If your shipment is in excess of 4.45 meters (14′ 7″) in width you will be permitted to travel only during daylight hours. If over 3.85 meters (12′ 7″) in width you may not travel on Sundays. There is not travel permitted on the following holidays: New Years day, Provincial day, Good Friday, Victoria day, Canada day, Family day, Labour day, Thanksgiving day, Remembrance day, Christmas day and on Boxing day.

Adverse weather conditions: If adverse weather conditions are reported you may not proceed with your shipment and are required to remain where ever you are. If adverse weather conditions interrupt your shipment you are required to pull over at the nearest suitable location even if it is on the side of the road unless you are over width. Over width loads must continue until they are able to completely turn off of the road and remain until adverse weather conditions stop. If your shipment is over 4.45 meters (14′ 7″) in width or 5.32 meters (17′ 5″) in height you are not permitted to travel with snow or fog visibility less than 150 meters (492′), if the road is covered with snow or ice or sleet or any other conditions that may effect the driver from proceeding with the absolute safety in mind first and foremost.

Frost laws: Alberta does have frost laws but when they are in effect changes every year based on testing with a heat flow model that measures to 30 cm below the surface. So, if you are shipping during the spring months you will need to call the number below for the exact frost law restriction dates. There are exemptions which include milk and bread trucks, farm machinery, water, fuel, fertilizer, mail and buses.

When pilot cars are required.

If your shipment is in excess of any of the following you will be required to have a pilot car escort you:

Length: If your shipment is in excess of 34 meters (111′) in overall length you are required to have 1 rear pilot car on single lane roads. For shipments in excess of 38 meters (124′ 8″) you are required to have 1 front pilot car/escort and 1 rear pilot car/escort.
Width: If your shipment is in excess of 3.85 meters (12′ 7″) wide you are required to have 1 front pilot car/escort on a single lane road or one rear pilot car/escort on multiple lane roads. For shipments over 4.45 meters (14′ 7″) wide require 1 front pilot car/escort and 1 rear pilot car/escort on single lane roads. If your shipment is in excess of 5.5 meters (18′) you are required to have 1 front and 1 rear pilot car/escort vehicle on all roads.
Height: Alberta does not normally use pilot cars with high poles as they have designated routes for shipments that are over height. You can view the routes on the Alberta DOT high load corridor page located here.
Weight: As long as your shipment can maintain the minimum required speed limit you will probably not be required to have a pilot car/escort by the Alberta DOT.
Overhang: If you have overhang that is over 6.5 meters (21′ 4″) you will be required to have 1 rear pilot car/escort vehicle. If your shipment overhang is in excess of 9 meters (29′ 6″) you will be required to have 1 front and 1 rear pilot car/escort vehicle.

Pilot car requirements.

Pilot car (escort vehicle) requirements for operating in Alberta province are as follows:

Pilot car/escort vehicle operators are NOT required to take any sort of DOT certification course in order to operate in Canada. Your vehicle is required however to have a lighted sign box that is a minimum of 180 cm x 35 cm x 10 cm (72″ x 14″ x 4″), 2 – 175 mm (7″) diameter flashing lights mounted on the top of the sign box on each side with 2 amber strobing or rotating lights a minimum of 203 mm (8″) mounted between the flashing lights on top of the box as well. The sign box must light up and be visible from a minimum distance of 200 meters (656′). The sign box must have either a red and white D sign or a yellow with black lettering stating “OVERSIZE LOAD”, “WIDE LOAD”,  OR “LONG LOAD”. If you have the “D” sign your letter must be no less than 20 cm (8″) in height with a 4 cm (1 5/8″) line thickness. If you have the yellow sign your lettering must be no less than 20 cm (8″) with a 4 cm (1 5/8″) line thickness. The sign box must be mounted on the top of the vehicle and covered when not in operation. You are also expected to have the following items inside of the vehicle: CB radio or high powered 2-way radio, first aid kit, fire extinguisher type A, B & C of at least a 2 liters, 3 reflective road triangles, 3 traffic cones, reflective vest (worn while working), slow/stop sign, 3 red or orange safety colored flags no less than 40 x 40 cm (16″ x 16″), nose cone flashlight and a hard hat.

Shipment, truck & trailer markings.

Truck, trailer and shipment required signs, banners and flags:

All trucks that are hauling oversize or overweight loads must have a strobing, flashing or rotating amber light mounted to the roof that is visible from 360 degrees at a minimum distance of 200 meters (656′). All 4 outermost corners corners of the overall shipment and any obtrusive points must have flags mounted to them that are safety red or orange in color no less than 40 cm x 40 cm (16″ x 16″) and have the flags exchanged for lighting if moving during the night. A sign stating the nature of the load; “OVERSIZE LOAD”, “WIDE LOAD” or “LONG LOAD” must be mounted to the front and rear of the overall shipment. Signs must be a minimum of 12′ in height and 6′ in width with a yellow background and black letting with lettering thickness no less than 4 cm (1 5/8″) thick.

Alberta DOT and other information.

Alberta DOT contact  and other information:

Alberta DOT & Central Permit Office
Telephone help line: 403-342-7138 toll free (all of North America): 800-662-7138
Fax: 403-340-5278
Road ban information: Current road bans. Toll free (all of North America): 855-762-3226
6 AM until 12 Midnight Monday – Friday
7 Am until 10 PM on weekends and holidays – MOUNTAIN TIME ZONE

Alberta current road restrictions from construction maintenance and spring thaw law. Excellent resource!
Alberta Canada truck driver hours of service.
Alberta Canada road and weather conditions.
Alberta DOT permit office website.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Alberta Province DOT Permits office before commencing movement.


[codepeople-post-map]

 

Maine State Shipping Regulations 2021



2021 Maine DOT regulations for shipping oversize and overweight loads. Trucking company and pilot car reference.

Maine oversize shipping regulations.

The great state of Maine official seal.

Please share your knowledge with other visitors below.

Trucking company & pilot car directory.

Locate trucking companies and pilot cars in Maine:

Maine trucking company directory.
Maine pilot cars and truck escorts.

Legal load limits.

Maine DOT legal size and weight limitations:

Length: 69 feet combined overall and the maximum length of your trailer can not exceed 48 feet.
Width: 8 feet and 6 inches in the maximum width allowed by Maine DOT.
Height: 14 feet is the maximum height allowed to travel in Maine legally.
Weight: 80,000 pounds GVW is the maximum weight allowed without a permit.

Routine trucking permits.

Oversize and overweight trucking permits that are routinely issued by the Maine state DOT office:

Length: 125 feet in length is the maximum for a routine trucking permit.
Width: 16 feet wide is the maximum for a routine permit and anything wider than this will require a police escort. If over 18 feet wide you will not be allowed to travel on the turnpike.
Height: 16 feet high in the most on a routine permit (13 feet and 6 inches is the limit on the Maine turnpike) and this depends on your routing. If you are close to this or over you will possibly have to have a route survey done and you will be required to notify all utility companies that have obstructions along your route.
Weight: Tandem axles: 52,000 pounds, tridum axles: 75,000 pounds, quadem axles: 100,000 pounds. Gross weight for 5 axles is: 130,000 pounds, for 6 axles: 140,000 pounds, and for 7 axles is the maximum gross weight allowed is: 167,000 pounds maximum.

Maine DOT superload information:

Anything that is over 125 feet long, 16 feet wide, 16 feet tall or over 125,000 pounds in weight is considered a superload by the Maine DOT. Permit approval could take 30 days depending on your proposed route and how far you want to exceed legal limits. You may wish to see: Maine state oversize and heavy haul trucking laws.

Permitted travel times and restrictions.

Maine DOT permitted travel times and travel restrictions:

One 1/2 before and 1/2 hour after sunset rule applies. With the exception of during the months of July and August you may travel on Saturdays and Sundays but may not during these 2 months. There is no holiday travel on the following holidays: New Years day, Memorial day, Independence day, Labor day, Columbus day, Veterans day, Thanksgiving day, Black Friday and on Christmas day.

NOTES: Turnpike travel: you may travel on the Maine turnpike  during the daylight hours from Monday until Friday at 12 noon. You may not travel on the weekends. Max width if 14 feet 6 inches and for height see “Routine permits” above. You can reach the Maine turnpike office at 207-871-7771. Mobile home shipments can only travel on Monday, Tuesday, Wednesday and on Thursdays – after that you may not travel. Night shipments may be approved but have to clear the Maine state police for permission first.

When pilot cars are required.

If your shipment is over any of the following you will be required to have a pilot car or escort vehicle by the Maine DOT office.

If highway is divided, a single pilot car or escort vehicle is to be positioned at the rear of the vehicle. If the highway is undivided, a single pilot car or escort vehicle is to be positioned at the front of the truck and trailer.

Width: 12 feet to 14 inches requires 1 pilot car or escort vehicle., 14 feet and 6 inches to 15 feet and 11 inches requires 2 pilot cars or escort vehicles.
Height: Over 16 feet requires a state police escort.
Length: Over 79 feet and 11 inches requires 1 pilot car or escort vehicle. Over 110 feet requires 2 pilot cars (escort vehicles).  Over 125 feet requires a state police escort.

NOTES: Signs must say “oversize load” in 10 inch high black letters on a yellow background.
They must be at least 7 feet wide by 18 inches high and posted on both the front and rear.
18 inch by 18 inch flags must be posted on all four corners of load. Pilot cars must have 2-way radio that has contact with at least a ½ mile range. The truck must have a flashing amber light on top of the cab.

How to apply for trucking permits.

Maine Department of State Bureau of Motor Vehicles, overlimit Permit Unit
29 State House Station
Augusta, ME  04333
Phone: 207-622-5332
E-mail: overpermits@maine.gov
Office hours: Monday thru Friday 7:30 Am until 5 PM
Eastern Time

NOTES: The Maine turnpike requires a separate permit and has its own size/weight limits.  (800) 698-7747 or 207-871-7771. Permits can be purchased
at Maine Turnpike toll plazas. Cost is $10. Signs must say “oversize load” in 10 inch high black letters on a yellow background. They must be at least 7 feet wide by 18 inches in height and posted on both the front and rear. 18 inch by 18 inch flags must be posted on all four corners of load. Pilot cars must have 2-way radio that has contact with at least a ½ mile range. The truck must have a flashing amber light on top of the cab.

 Required shipment truck and trailer markings.

#####Coder notes>bring it:

Permit valid for.
DOT links.
Map shot.
Contact info.
Road closures.
Thaw law.
MDOT for juicy info that is hard to find.

Maine cities serviced.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Maine State DOT Permits office before commencing movement.

[codepeople-post-map]

maine-state