California State Shipping Regulations

California State Shipping Regulations

2021 California state shipping laws, regulations, and limitations for heavy-haul trucking and oversize loads. 

Support visitors like yourself by sharing information at the bottom of this page.

Maximum legal limits without requiring a permit. 

Maximum legal limits. Standard Metric
Length: 65 feet. 19.8 meters.
Width: 8 feet, 6 inches. 2.6 meters.
Height: 13 feet, 6 inches. 4.1 meters.
Weight: 80,000 pounds. 36,287 kilograms.
Overhang: 4 feet from the rear, 3 feet from the front. 1.21 meters from the rear, 1 meter from the front.
Notes: Always verify any discrepancies with CalTrans prior to movement/transport if you are ever uncertain.

These rules pertain to personal vehicles (towed or otherwise), commercial motor vehicles including semi-tractors, trailers, buses, boats, or anything else on California roads. Some local roads may have additional restrictions. For clarification of any discrepancies consult CalTrans (see contact information below).

California legal maximum limit information in detail.

Routinely issued oversize/overweight permit maximums.

Oversize/overweight transport/trucking permits routinely issued by CALTRANS.

Maximum routine permit limits Standard Metric
Length: 135 feet. 41.1 meters.
Width: 15 feet. 4.5 meters.
Height: 17 feet. 5.1 meters.
Weight: 250,000 pounds. 36,287 kilograms.
Overhang: 4 feet from rear, 3 feet from front. 1.21 meters from rear, 1 meter from front.
Notes: Detailed instructions should be clearly printed on your official permit. Any discrepancies should be discussed with issuing CALTRANS office official prior to movement/transport for clarification.

Routinely issued oversize/overweight permit information in detail.

California overhang in-depth clarification.

California superload information.

Shipments in excess of the following weights/dimensions are classified as superloads in California.

Superload size/weight classification Standard Metric
Length: 135+ feet. 41.1+ meters.
Width: 15 + feet. 4.5+ meters.
Height: 17+ feet. 5.1+ meters.
Weight: 250,000+ pounds. 36,287+ kilograms.
Overhang: 4 + feet. 1.21+ meters from rear, 1+ meters from front.
Notes: Superloads have finely detailed instructions clearly printed on the official permit. Any discrepancies should be discussed with the issuing CALTRANS superload permit office official prior to commencing movement/transport.

California superload information in-depth.

Travel times and restrictions.

Pilot car/escort vehicle requirements.

Required shipment markings, signs, flags and lights.

Additional information.

California DOT locations and contact information.

California DOT (CalTrans) contact information and other helpful links.

Northern region:
California Department of Transportation – CalTrans
PO Box 942874, room 4105
Sacramento, CA 94274-0001
Telephone helpline:
916-322-1297
Fax line:
916-322-4966
Permit office hours:
8 AM until 5 PM – PACIFIC TIME ZONE

Southern region:
California Department of Transportation – CalTrans
464 West 4th Street, MS #618
San Bernadino, CA  92401
Telephone helpline:
909-383-4637
Fax line: 909-388-7001
Permit office hours: 8 AM until 5 PM – PACIFIC TIME ZONE

⚠️TrafficAlert HWY 99 is NOW CLOSED between 47th Ave and the HWY 50 connector in @TheCityofSac for bridge deck replacement work. Scheduled reopening 4am Wednesday 6/16. Please be safe, plan accordingly and use alternate routes. Thanks for your patience. https://t.co/V4wzy3RLOs

#ICYMI Highway 99 CLOSED from 47th Ave. to US-50 Connector in @TheCityofSac starting TONIGHT @ 8 PM - 4 AM, Wed. (6/16) for bridge deck replacement. For info. visit https://t.co/8uH69qiYFH #AVOID99FOR99HRS #FixSac99inRecordTime @CHP_HQ @CaltransHQ @AMARJEETBENIPAL @CaltransDist3

Load More...

 

See also:

California heavy haul trucking company directory.
California pilot car company directory.
Order California heavy haul and oversize trucking permits.
CalTrans pilot car maps – Pilot cars look!
CalTrans oversize and overweight shipping manuals.
Loads of contacts at the Caltrans oversize permit offices.
California traffic and road conditions reports.

California state shipping regulations.

California DOT and Caltrans regulations for oversize trucking and heavy haul.

California state flag.

Cities we service in California:

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, pilot car companies, and private individuals. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the California DOT (CalTrans) Permits office before commencing movement.

Oregon State Shipping Regulations

Oregon State Shipping Regulations

2021 Oregon state shipping laws, regulations, and limitations for heavy-haul trucking and oversize loads.

Support visitors like yourself by sharing information at the bottom of this page.

Maximum legal limits without requiring a permit.

Maximum legal limits. Standard Metric
Length: Determined by trailer length: 53 feet max. 16.1 meters maximum trailer length.
Width: 8 feet, 6 inches. 2.6 meters.
Height: 14 feet. 4.2 meters.
Weight: 80,000 pounds. 36,287 kilograms.
Overhang: 5 feet from the rear, 4 feet from the front. 1.5 meters from the rear, 1.2 meters from the front.
Notes: Some roads require a permit for a 53 feet trailer. Overhangs must be day flagged or night illuminated.

Oregon legal maximum limit information in detail.

Routinely issued oversize/overweight permit maximums.

Oversize/overweight transport/trucking permits routinely issued by ODOT.

Maximum routine permit limits Standard Metric
Length: 80 feet overall depending on routing. 24.3 meters.
Width: 15 feet. 4.5 meters.
Height: 17 feet. 5.1 meters.
Weight: 98,000-105,000 lbs depending on the route. 44,452 kilograms.
Overhang: No set limit. Depends on the route.
Notes: Overhang can not exceed more than 1/3 of the total combined wheelbase length: first front to last rear axle.

Routinely issued oversize/overweight permit information in detail.

Oregon overhang in-depth clarification.

Oregon superload information.

Shipments in excess of the following weights/dimensions are classified as superloads in Oregon.

Superload size/weight classification Standard Metric
Length: 150+ feet. 45.7+ meters.
Width: 14 feet on 2 lane – 16+ feet on Interstate. 4.2+ and 4.8+ meters.
Height: 17+ feet. 5.1+ meters.
Weight: Over 105,000 lbs on some routes. 47,627+ kilograms.
Overhang: 4+ feet. 1.21+ meters.
Notes: Superloads have finely detailed instructions clearly printed on the official permit. Any discrepancies should be discussed with the issuing ODOT superload permit office official prior to commencing movement/transport.

Oregon superload information in-depth.

Permitted travel times and restrictions.

When pilot cars/escorts are required.

Pilot car/escort vehicle requirements.

Required shipment markings, signs, flags and lights.

Additional information.

Oregon DOT (ODOT) locations and contact information.

Oregon ODOT contact information and other helpful links.

Oregon Motor Carrier Transportation Division – Over-Dimensional Permit Unit.
Dept. of Transportation Permits Office
Motor Carrier Transport OS/OD Permit Unit
550 Capitol Street, NE
Salem, OR   97301
Telephone: 503-373-0000
Trip Permits: (503) 378-6699
Fuel Permits: (503) 373-1634
Hours: 7 am – 5 pm Monday – Friday (Wed. closed from 12-1 pm). PACIFIC DAYLIGHT TIME.

Note: When applying in Oregon for overweight permits you should know they have a strict bridge formula which may delay permit issuance depending on the route. Also, some counties require permits for travel as well so be sure to ask. Permits are valid for 10 days only.

See also:

ODOT oversize information website.
Oregon road closures and conditions.
Oregon pilot car and truck escorts.
Oregon heavy haul and oversize trucking companies
Oregon oversize and overweight trucking permits.

 

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Oregon State DOT Permits office before commencing movement.

 

oregon-state

 

 

Missouri State Shipping Regulations


2021 Missouri shipping laws, regulations, rules, and limitations for oversize and heavy-haul trucking permits.

Please share your knowledge of Missouri state shipping regulations with other visitors below.

 

Do I need a trucking permit? Legal load limits.

Missouri maximum load limits until and trucking permits are required.

Length: 53 feet maximum. If you overhang in either direction on a 53-foot trailer (even a 1/2 inch) you are required to obtain a permit.
Width:  8 feet  6 inches.
Height: 13 feet 6 inches.
Weight: 80,000 pounds GVW.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize and heavy-haul trucking permits in MO:

Length: 53 feet is the maximum. Over 90 feet combined overall requires 1 rear escort.  120 feet can be permitted. Anything over is a superload.
Width: Figure up to 14 feet as a routine permit. Some routes/distances may qualify as routine, see: state laws.
Height: 14 feet and 6 inches depending on routing/distance. To see if others qualify see the above “state laws” link.
Weight:  Single axle 20,000 pounds, 46,000 pounds on tandem axles, tridem axles 60,000 pounds (no more than 21,000 on any single in combination), quad axles 72,000 pounds (no more than 19,000 pounds on any single axle configurations), 5 axles 104,000 pounds, 6 axles 120,000 pounds, 7 axles (config. 1-2-4) 130,000 pounds, 8 axles 160,000 pounds, 9 axles (config. 1-4-4) 156,000 pounds.
Overhang: Anything over 53 feet in length requires a permit. If you overhang or are in excess of 53 feet by a 1/2 inch you are required to obtain a permit.

Missouri superloads.

Requirements for extra-heavy or over-dimensional (superloads in MO):

All superload shipments are required to have a minimum of 2 million dollars in single limit combined liability insurance. For simplicity, a superload in Missouri is any shipment in excess of the above dimensions or weights listed above in “routine”. For complete details of state laws.

Missouri load long and heavy.

When a pilot car or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanied by an escort vehicle or pilot car if:

QUICK REFERENCE

Length: 90 feet overall length requires 1 rear/ chase pilot car or escort vehicle if the highway is not divided.
Width:

  • 12 feet and under requires no escort.
  • 12 feet and 4 inches will require 1 rear/chase escort vehicle. 1 escort vehicle and 1 pilot car are required on non-designated roads.

Height:

  • 15 feet 6 inches on 2 lane undivided roads requires a high pole pilot car.
  • 15 feet on divided highways requires 1 pilot car with a height pole. May need route survey and bucket trucks.

Overhang:

  • Anytime the length of the load exceeds 53 feet 1 pilot car is required. Over 90 feet overall may require 1 pilot car and 1 escort.

Notes: If the shipment consists of 2 dimensions being over the legal limits 1 pilot car and 1 escort vehicle are required.

Pilot car and escort vehicle requirements, certifications.

In order to operate a pilot car or escort vehicle in the state of Missouri you are required to have a minimum of the following:

Missouri state laws say pilot car/escort vehicles must be a standard size and have unrestricted vision in the front and rear. The vehicle must be in safe operating condition. “Oversize Load” signs must be displayed towards the front or rear, whichever is applicable. Signs must not be visible when not in service. Signs must be a minimum of 5 feet in length and 1 foot in height. Signs must have a yellow background color with thick (1-inch minimum) black clear, professional print quality lettering. All escort vehicles must be equipped with safety-colored red or orange fluorescent flags that can be mounted on both sides of the front of lead pilot car vehicles or both rear sides of chase escort vehicles. All vehicles involved in shipment must have 2-way radio capabilities. Insurance requirements must be a minimum of $50,000 for personal injury per person. $200,000 for accident/property damage and/or combined single limit liability of $250,000.

Note: Flaggers or any person directing or altering traffic is required to have a “flaggers certification” and be flagger certified.

Travel Restrictions.

Travel is restricted if over 12’ 4” wide in most areas to 6:30 am (or a half-hour after sunrise) until 9:00 am then resume at 3:30 pm until 6:00 pm (or a half-hour before sunset). If over 14’ wide no movement on Saturday or Sunday at all.  You may move Monday thru Friday but only. For now, consider this info as a basic guideline for estimates only. Please call the State of Missouri for exact laws. And always be sure to read the instructions on your permit(s).

Missouri DOT contact information.

Physical address and MDOT contact information:
Missouri Department of Transportation, Motor Carriers, Special Permit Office
PO Box 270, Jefferson City, MO 65102
Phone: 573-751-2871
Permit office hours: Monday thru Friday 7:30 am until 3:45 pm.
Missouri legal guidelines: Missouri oversize and heavy-haul regulation laws printed by the state.

Missouri oversize and heavy-haul shipping regulations, permits.

Missouri cities serviced.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Missouri State DOT Permits office before commencing movement.
[codepeople-post-map]

missouri-state

Missouri oversize, heavy haul trucking companies, and pilot car for hire:

Missouri pilot cars and trucking escorts.
Missouri oversize and heavy-haul trucking companies.

 

Manitoba shipping regulations

2021 Manitoba DOT shipping laws, regulations, and limitations, for oversize and heavy-haul trucking over the roads and highways of Manitoba Canada.

Please share your expertise of knowledge with our other visitors below.

Legal limits.

Length: The overall maximum length without a permit is 23 meters.
Width: The maximum width allowed without a permit is 2.6 meters.
Height: 4.15 meters is the maximum height allowed by Manitoba DOT without a permit.
Weight: 9,100 kg on steer (seems high to us so NOT a confirmed number –  use reference link below), tandem axles: 17,000 kgs, tridem: 17,000 kgs,  or 3 axle combination with proper spacing of a 23,700, quadem: 31,600 kgs, 5 axle: 39,500 kgs and 6 axles: 46,500 kgs. Let me refer you to our reference on this for clarification from Manitoba DOT as there are different weight classes.
Overhang: 3′ 3″ (1 meter) in front or rear.

Routine heavy-haul and oversize trucking permits.

Length: 30 meters in length is about all you are going to get.
Width: 5 meters wide for routine permits depending on routing.
Height: Depending on routing as Manitoba DOT has designated routes the maximum height is 4.8 meters.
Weight: We were unable to get a solid figure. Manitoba DOT has different zones for weight restrictions so it all depends on which zone you need to travel in. See Manitoba DOT zone map.
Overhang: Manitoba is overhang laws with permits.

Travel times and restrictions.

Daylight travel times are defined as from sunrise to sunset in Manitoba. No travel is permitted after 3 PM on Fridays during the summer months for shipments in excess of 3.4 meters (11′ 2″) wide on seasonal restricted roads. In the spring shipments in excess of 4.6 meters (15′) in width are not allowed to travel on roads during the spring restriction times. On routes that are not seasonally restricted you may proceed (multiple lane roads) until 3 PM as long as you are no wider than 3.7 meters in width (12′ 2″) on Friday and resume travel on Saturday at sunrise however if you are in excess of 25 meters in length (82′) you are not permitted to travel after 3 PM on Fridays during the summer months if you are on a seasonally restricted highway and resume on Saturday at sunrise – you are allowed however to travel on holidays. Sunday travel is permitted for loads up to 3.85 meters (12′ 7″) in width on all roads that have no seasonal restrictions. On a single lane highway on holidays you can not exceed 3.4 meters (11′ 2″) in order to travel. On multiple lane roads, you can travel only if you are less than 3.7 meters (12′ 2″). This is very confusing so always refer to your permit for final verification but to help the matter lets go over the restricted routes:

  • Highway 1 from Falcon Lake to the Manitoba/Ontario border.
  • Highway 6, 8, 9, 15, 16, 44, 307, 313, 317.
  • Highway 10 from the US border to Riding Mountain National Park.
  • Highway 11 but only north of highway 44.
  • Highway 12 but only north of highway 15.
  • Highway 59 from the west boundary line of Brokenhead to Grand Beach and the South perimeter of St. Malo

Here is the Manitoba link for spring road restrictions with zones to help you with interpretation. Holidays observed are New years day, Provincial day, Good Friday, Victoria day, Canada day, Family day, Labor Day, Thanksgiving Day, Remembrance Day, Christmas Day, and Boxing day.

Superload information.

We will do more research on superloads in Manitoba in the future. The Manitoba DOT documentation does not cover or mention much about them so we will need to speak with someone on the phone. We are able to see that they are well versed in shipping superloads as they mention in their online documentation that there will make arrangements to remove roadside signs and replace them for shipments that are in excess of the road width. We will get back to this section soon but in the meantime appreciate any comments you may be able to leave for other visitors below.

Pilot car are escort vehicle information.

Manitoba DOT requires you to have a pilot car if your shipment is in excess of any of the following regulated limits:

Length: Shipments that are in excess of 30 meters (98′ 5″) long require 1 pilot car/escort vehicle on the rear of the shipment on all roads. For shipments that include a booster of a jeep that is over 31 meters (101′ 9″), you are required to have 1 rear pilot car vehicle on all roads.
Width: If your shipment is in excess of 4.6 meters (15′) wide then you are required to have 1 front pilot car on single lane roads and 1 rear pilot car/escort on multiple lane roads. If your load is in excess of 3.66 meters (12′) but less than 4.55 meters ( 14′ 7″) then you are permitted to travel at night as long as you have 1 front and 1 read pilot car/escort vehicle on all roads and highways. Mobile homes can travel at night on multiple lane roads as long as it does not exceed 5 meters wide (16′ 4″) but are required to have 1 pilot car on the rear.
Height: If you are approved for a shipment that is over the legal limits Manitoba DOT has designated routes and you are not required to have a pilot car.
Weight: As long as your shipment is able to maintain the minimum speed requirements you will more than likely not be required to have a pilot car as long as your shipment is overweight only.
Overhang: Overhang is approved on a case-by-case basis. Check with the Manitoba DOT for further information to see if your shipment will require a pilot car due to excessive overhang.

Pilot car and escort vehicle requirements.

Pilot car/escort vehicle operators are required to take a Manitoba DOT certification course in order to operate in this province. The certification program is recognized by all US jurisdictions that require PEVO except for New York state. Your vehicle is required to have a lighted sign box that is a minimum of 180 cm x 35 cm x 10 cm (72″ x 14″ x 4″), 2 – 175 mm (7″) diameter flashing lights mounted on the top of the sign-box on each side with 2 amber strobing or rotating lights a minimum of 203 mm (8″) mounted between the flashing lights on top of the box as well. The sign-box must light up and be visible from a minimum distance of 200 meters (656′). The sign-box must have either a red and white D sign or a yellow with black lettering stating “OVERSIZE LOAD”, “WIDE LOAD”,  OR “LONG LOAD”. If you have the “D” sign your letter must be no less than 20 cm (8″) in height with a 4 cm (1 5/8″) line thickness. If you have the yellow sign your lettering must be no less than 20 cm (8″) with a 4 cm (1 5/8″) line thickness. The sign-box must be mounted on the top of the vehicle and covered when not in operation. You are also expected to have the following items inside of the vehicle: CB radio or high powered 2-way radio, first aid kit, fire extinguisher type A, B & C of at least 2 liters, 3 reflective road triangles, 3 traffic cones, reflective vest (worn while working), slow/stop sign, 3 red or orange safety colored flags no less than 40 x 40 cm (16″ x 16″), nose cone flashlight and a hard hat.

To operate in Manitoba you must obtain a light permit. More information is available by calling: 204-985-0920

Shipment, truck, and trailer markings.

Truck, trailer, and shipment required signs, banners, and flags in Manitoba:

All trucks that are hauling oversize or overweight loads must have a strobing, flashing or rotating amber light mounted to the roof that is visible from 360 degrees at a minimum distance of 200 meters (656′). All 4 outermost corners of the overall shipment and any obtrusive points must have flags mounted to them that are safety red or orange in color no less than 40 cm x 40 cm (16″ x 16″) and have the flags exchanged for lighting if moving during the night. A sign stating the nature of the load; “OVERSIZE LOAD”, “WIDE LOAD” or “LONG LOAD” must be mounted to the front and rear of the overall shipment. Signs must be a minimum of 12′ in height and 6′ in width with a yellow background and black letting with lettering thickness no less than 4 cm (1 5/8″) thick.

Manitoba DOT contact and other information.

Manitoba DOT – Central Permit Office
Telephone help line, Winnipeg; 877-812-0009 or 204-945-3961 (compliance: 204-945-3890)
Fax line: 204-945-3961
Hours of service: 7:30 AM until 6 PM Monday thru Friday – CENTRAL TIME ZONE.
Manitoba DOT oversize and overweight trucking permits website.
Manitoba spring thaw road restrictions information.
Manitoba DOT axle and axle group weight definitions and restrictions.
Manitoba province current road conditions and closure information.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Manitoba Province DOT Permits office before commencing movement.
[codepeople-post-map]

See also:

Manitoba frost and thaw laws.
Frost law introduction.
Manitoba road closures and reports.
How to start a pilot car company.
Manitoba heavy-haul trucking companies.
Manitoba pilot cars and truck escorts.

manitobacoatofa

Nebraska State Shipping Regulations

Nebraska State Shipping Regulations

2021 Nebraska state shipping laws, rules, regulations, limitations for oversize and heavy-haul trucking permits.

Nebraska oversize, heavy-haul trucking permits.

Nebraska oversize and heavy-haul trucking companies for hire.
Nebraska pilot car companies for hire.
Nebraska oversize and heavy-haul permits.

Do I need a trucking permit? Legal load limits.

Nebraska maximum load limits until a trucking permit are required.

Length: Overall no longer than 85 feet on designated highways.  The trailer length maximum is 53 feet.
Weight: 80,000 pounds GVW, 20,000 pounds on a single axle, 34,000 pounds on tandem axles.
Width:  8 feet and 6 inches.
Height: 13 feet and 6 inches
Overhang: No set rules, case-by-case.  We figure 3 feet of front or rear should be safe but by no means is that policy. For clarification be sure to refer to your permit.
Notes: For documentation refer to Nebraska legal limitations for transport.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Texas:

Length: Up to 120 feet long is routine. Anything over will be assessed but limits are relaxed.
Weight: They do not use the federal bridge formula. 20,000 pounds per axle is the maximum. Anything over 110,000 pounds combined overall is going to be a superload. 20,000 pounds on a single axle, 40,000 pounds on tandem axles, 60,000 pounds on tridum axles, 80,000 pounds on quadem axles.  A Dummy axle must carry a minimum of 8,000 pounds or 8% of the gross total weight.
Width: Figure up to 14 feet as a routine permit.  They are strict on width and over 14 feet wide is going to be looked at as superload unless it’s a light load. Case-by-case but if you are heavy you may need approval from Lincoln, NE (up to 5 days processing times).
Height: Up to 14 feet and  6 inches is considered routine and some routes may require a high pole. If you are over 16’ feet a high pole is mandatory.

Nebraska superloads.

Requirements for extra-heavy or over-dimensional (superloads in NE):

For the purpose of this reading, you can figure superload dimensions are anything that is in excess of the dimensions or weights mentioned above in “routine”. If you are close then it will be up to the state to determine if you must file for your permit as a superload or not. See actual Nebraska state oversize and heavy haul trucking laws.

Legal travel times for oversize and heavy-haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

Travel time is a half-hour before sunrise and a half-hour after sunset leniency rule.  Weekend travel is permitted but they do have travel time restrictions around Lincoln, NE, and Omaha, NE during both weekdays and weekends.  Travel is prohibited on most all holidays and the day after Thanksgiving.

Lights, safety flags, and warning signs for heavy haul and oversize loads.

Required marking, safety flags, warning signs for heavy haul and oversize loads:

All loads being shipped in Nebraska must be marked with oversize load signs shipments are also required to have square red or orange fluorescent flags on all four corners to include the power unit and must be 18 inches. Pilot cars or escort vehicles that are used during the shipment must have flags in the front if leading or the rear if chasing. One revolving amber light must be on the top of the power unit as well as on the top of the pilot car. All signs must be yellow and background with black letters no less than 10 inches in height. For nighttime moves on shipments that are in excess of 12 feet wide a light bar attachment is required to be mounted on the rear of the load at a height that is clearly visible by motorists approaching from the rear.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanied by an escort vehicle or pilot car if:

Length: 90’ one on the rear. Over 100’ needs a rear and a chase pilot car.
Width: They can impose a required pilot car for anything over 8’ 6”.  In some cases, a lightbar can be used in lieu of a pilot car. Loads over 12 wide on 4 lanes are required one rear escort. A front is required for loads on 2 lane highway over 12’ wide. Front and rear are required for loads over 14’ wide. Front escort with a height pole is required for 14’ 6” and over.
Height: Over 14’ 6” needs a pilot car, may need height pole depending on the route.
Overhang: If over 15’ one rear escort is needed.
Note: Allow 1 to 10 days for permits to be approved. Maximum speeds of 45 MPH if 4 or more lanes, 35 MPH is under 4 lanes. Also, read travel restrictions below.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

All escort vehicles or pilot cars must be equipped with an amber light or light bar and must have a left and right side flashing or Rotary amber or yellow light of sufficient size that will be visible 360° from a distance of no less than 800 feet. Lights must be a minimum of 50 candle power bulbs. Lights must be no less than 6 inches in diameter.

Heavy lift being shipped in Nebraska.

Nebraska DOT contact information and notes.

Nebraska DOT office and permit contact information:

Physical and mailing address:
Nebraska Department of Roads
1400 NE Highway 2, Permit Office, Room 123
Lincoln, NE  68509
Telephone: 402-471-0034
Hours: Monday – Friday 7:30 AM – 5:00 PM

Central Daylight Time

Nebraska cities serviced.

 

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Nebraska State DOT Permits office before commencing movement.

 [codepeople-post-map]

nebraska-state

 

New Mexico State Shipping Regulations

2021 New Mexico DOT shipping regulations for oversize and overweight trucking.

New mexico shipping rules and regulations.

The great state of New Mexico official seal.

Please share your expertise or knowledge with other visitors below.

Trucking company & pilot car directory.

Locate trucking & pilot car companies located in New Mexico state:

New Mexico heavy haul trucking company directory.
New Mexico pilot car company directory.

Legal load limits.

Length: 65’on non-designated highways and 57′ 6″ max trailer length for all other areas.
Height: 14′
Width: 8′ 6″ or 102″ depending on route.
Weight: 80,000 lbs. on interstate roads and 80,640 lbs. on all others.
Overhang: We do not have any information on the legal overhang limits. If you have information please share it with others below.

Routine trucking permits.

Length:  There is no clarification on length. We do know that over 190′ is classified as a superload. Routing would be the issue. Please share your expertise below.
Height: 14′
Width: Routine limits on width is another bloodstone.  Routing (mainly sub-routing) is complicated in this state.
Weight: These are the routine weights that are allowed on the Interstates in New Mexico. Still routing is the determining factor. Single axle; 23,000 lbs, tandem axles; 46,000 lbs, tridum axles; 60,000 lbs, quadem axles; 68,000 lbs. Roads other than the Interstate all depend on your axle spacings. Gross weights are: 5 axles; 105,000 lbs, 6 axles; 119,000 lbs, 7 axles; 127,000 lbs, 8 axles; 150,000 lbs. Of course, all of this is totally dependent on the New Mexico DOT so do not assume anything as it seems they want to review any shipments that are pushing the upper limits as they hold back information so it’s “pending approval”.
Overhang: We do not have any information on the legal overhang. If you can help please comment below.

Superload information.

Length: anything over 190′ long.
Width: 20′ wide for sure. Possibly less on sub-routes.
Height: We have no number yet.  The maximum routine is 14′ but that is pretty low. We would think that 17′ would be superload height based on the information we have on this state but routing is everything when it comes to height.
Weight: 200,000 pounds and you are a superload.

Travel times & restrictions.

The sunrise to sunset rule applies in the state of New Mexico. Sunday travel is not allowed and holiday restrictions apply (if overweight interstate travels only with a pilot car). If the holiday is on a Friday then you can only travel until sunset on Thursday. If the holiday is on a Saturday you can not travel past Friday at sunset.  Resuming travel. If the holiday falls on a Saturday you can’t resume travel until Tuesday. Travel is not permitted on the following holidays: New Year’s Day, Memorial Day, Independence Day, Labor Day, Christmas Day, and Thanksgiving day.

Note: In the cities of Albuquerque, Espanola and Santa Fe you can not travel from the hours of 7 – 9 AM and 4 – 6 PM as high traffic density is the worst during this time.

When pilot cars are required in New Mexico.

Pilot cars (escort vehicles) are required for and shipments that exceed 14′ in width and can be even lower depending on the route you wish to travel.  Pilot cars (escorts) are required for loads exceeding 14′ 6″ on any of the restricted highways, see the pilot car (escort vehicle) map developed by the New Mexico DOT which will furnish all pilot cars (escort vehicles) a complimentary map if you ask. Over-length shipments may require a pilot car (escort) for shipments in excess of  90′ in length overall. If you are over 110′ overall you will be required to have 2 pilot cars (1 front & 1 rear). If the width of the load exceeds 20′ wide you will be required to have a police escort and flag person that is certified to control traffic. The maximum height is 16′. If you are over this height you will be required to have a high pole pilot car (escort vehicle).

Pilot car certifications required.

At the New Mexico DOT port of entry, your pilot car (escort vehicle) will be required to undergo an inspection for certification by the New Mexico DOT while operating in their state. The driver will be required to show all of the following equipment and documentation in/on the vehicle for inspection purposes:

  • Condition of vehicle tires must be excellent and a wheelbase of the vehicle must be a minimum of 100″ and have a rated capacity of no more than 1 and 1/2 ton vehicle.
  • Two-way radio or CB radio units that are capable of transporting well over 10 miles minimum.
  • 2 amber flashing or strobing lights on the two most outer edges of the vehicle that are visible 360 degrees from a distance of no less than 500′. Headlamps are required to be turned on as well when working.
  • At least 1 “OVERSIZE LOAD” sign must be displayed on the vehicle. This sign must have a yellow background with minimum dimensions of 5′ in width and 12″ in height with black letter thickness no less than 1″ thick. Best if mounted on top but can be mounted to the rear if chasing or front if leading.
  • A minimum of 2 florescent orange-colored safety flags no less than 12″ in length on any side.
  • Fire extinguisher with type A, B, and C rating and a minimum of 2 1/2 pounds (5 or larger is suggested).
  • 3 reflective road triangles and 8 ignitable road flares.
  • Safety-colored vest or jacket.
  • The vehicle must display company name, address, and contact information on both sides of the vehicle. New Mexico does not allow any logo shapes that resemble law enforcement/vehicles.
  • Certificate of insurance meeting the minimum requirements for New Mexico DOT which is $50,000, $100,000, and $25,000.

The New Mexico DOT inspections are annual inspections and the duration of validity is determined by the expiration date on the insurance certificate or 1 year, whichever is first.

Shipment truck & trailer markings.

Truck, trailer, and shipment required signs, banners & flags:

Signs must be yellow and black detailed and specific stating; ‘OVERSIZE LOAD”, “OVER HEIGHT LOAD”, “OVER LENGTH LOAD” OR “WIDELOAD”. These signs/banners must be a minimum of 5’ in width, 12″ in height and have letters a minimum of 1″ thick and 10″ in height. Flags must be used at all times with over-dimensional loads. Flags must be safety flags in fluorescent colors of orange or red. and be placed on the 4 outermost corners of the overall shipment (front of truck and rear of trailer).

New Mexico DOT permits & information.

Contact:
New Mexico Motor Transportation Division DOT Permit Office
PO Box 1028
Santa Fe, NM 87504-1028

Helpline phone: 505-827-0665 or 505-827-0376; Fax: 505-827-0071 Also see: Click on Port of Entry. and click on “Port of Entry” link.
Office Hours: 7:30 AM – 5:00 AM

Mountain Time Zone

New Mexico state DOT single trip permit application here.
New Mexico motor transportation police here.
New Mexico road and highway conditions, closures, etc. here.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the New Mexico DOT Permits office before commencing movement.
[codepeople-post-map]

 

New Mexico state flag and DOT permits regulations.

New Mexico State flag.

Louisiana State Shipping Regulations

2021 Louisiana state DOT shipping regulations, limitations, rules and laws for heavy-haul and oversize trucking.

Louisiana state seal.

 



 

Legal Loads.

Length: 65’ on non-designated routes (50’ trailer) 59’ 6” on designated truck routes.
Overhang:  8’ rear and 4’ front.
Weight: GVW 80,000 lbs.
Width: 8’ on non-designated roads. 8’ 6” on designated roads.
Height: 13’6”

Routine oversize shipping, trucking, and transport permits.

Length: No set limits – determined on a case by case basis
Weight: 5 Axles 108,000 lbs., 6 Axles 120,000 lbs., 7 Axles: 132,000 lbs., 8 Axles 152,000 lbs.
Width: 18’ (14’ on interstates)
Height: 14’8”

How to apply for trucking permits.

You will be required to use a permit service as the state will not take applications from individuals. Information at 225-343-2345 or 800-654-1433. The basic Fee is $10 per day plus the cost of the permit service.

Pilot car – escort car requirements.

Length: On 4 lane roads from 12’ to 14’ wide requires 1 rear escort car. Over 90’ requires 1 rear escort car. Over 125’ requires state police escort.
Width: 12’ to 14’ requires 1 front escort car
Height: No specific height – depends on the route.

Travel Restrictions.

Travel is permitted from ½ hour after sunrise to ½ hour before sunset, Monday through Saturday.  If less than 12’ wide, 90’ long and 100,000 lbs. you may travel Sunday until 1:00 pm.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Louisiana DOT Permits office before commencing movement.

Indiana State Shipping Regulations

2021 Indiana state shipping regulations, limitations, rules, and laws for oversize and overweight loads in the state of Indiana.

 

Indiana

The great state of Indiana official seal.



 

Indiana State Trucking Permit Regulations – oversize trucking and transport.

Indiana State Trucking information website is: http://www.in.gov/dot/business/permits/superl.html

Legal loads.

Length: 60′ (53′ trailers only)
Overhang: 3′ in front and unlimited in back as long as it does not exceed 60′ overall.
Weight: GVW 80,000 lbs., Single axle: 20,000 lbs., Steer: 20,000 lbs., Tandem: 34,000 lbs., Tridem: 42,000 lbs.
Width: 8′ 6″
Height: 13′ 6″

Indiana

Routine oversize shipping, trucking, and transport permits.

Length: 110′
Width: up to 18 feet depending on proposed route..
Overhang: 3′ in front and unlimited in the rear as long as it does not exceed 60′ overall.
Weight: 120,000 lbs. GVW, Single: 28,000 lbs., Steer: 28,000 lbs., Tandem: 48,000 lbs., Tridem: 60,000 lbs.

Pilot cars. Escort vehicle requirements.

Width: 2 lanes and over 12′ 4″ needs one pilot car or escort vehicle in the front.  4 lanes and over 12′ 4″ need one pilot care or escort vehicle in the rear.
Height: 2 lanes over 14′ 6″ need one pilot car or escort vehicle in the front.  4 lanes over 14′ 6″ need one pilot car or escort vehicle in the rear.
Length: 2 lanes over 85′ needs one pilot car or escort vehicle in front. 4 lanes over 85′ needs one pilot car or escort vehicle in the rear.

Travel restrictions.

Travel permitted 1/2 hour before sunrise to 1/2 hour after sunset. You can travel on weekends if less than 10′ wide.  If 10′ wide or over, you can travel until noon on Saturday.

How to apply for trucking permits.

Motor Carrier Services Division
5252 Decatur Blvd., Suite R
Indianapolis, IN 46241

317-615-7200 Voice

Permits are valid for 14 days from the date of issue.

 

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Indiana State DOT Permits office before commencing movement.

 

 

indiana-state

 

Alaska Shipping Regulations. Heavy-haul and oversize trucking.

2021 Alaska DOT shipping laws, rules, regulations for oversize and heavy-haul trucking.

Alaska shipping regulations for oversize and overweight trucking and DOT permit information.

The great state of Alaska official seal.

Share your knowledge with others below.!

Heavy haul trucking, pilot cars and permits.

Locate heavy haul, oversize equipment shipping companies, pilot cars and ordering trucking permits in Alaska:

 

Legal load limits.

Length:  53’ Trailer Length
Width:  8’6”
Height: 14’
Weight: Depending on route 80,000 lbs GVW.
Overhang: 3’ in the front, 4’ in the rear.

Kenworth double trailers in compliance with 80,000 pounds GVW laws.

Alaska requires any shipment over the weight of 80,000 pounds to have a special trip permit.

Routine trucking permits.

Trucking oversize and overweight permit limits:

Length: Shipping varies due to routing and season.
Width: Shipping rules vary depending on route and seaason.
Height: Over 14′ and once again everything varies depending on routing and season.
Weight: Single; 30,000 lbs, tandem; 56,000 lbs, tridem; 70,000 lbs, quadem 80,000 lbs, gross weight; 150,000 lbs. Depends on the route you wish to travel, distance and the bridges you intend on crossing.
Overhang:  20′ is a safe number but once again everything up here is seasonal as roads are closed or combined with weight frost laws may be in effect and limit you.  For the most part there is no such thing as a “routing” shipment in Alaska.

Notes:  When between the months of October 1 and March 31 for 1, 2 & 3 drive axle groups on truck tractors intending to travel the Dalton, Elliott or Steese highways between Fairbanks and Prudhoe Bay you can shift your legal axle weights to make them legal. The following weights on these routes apply: single; 22,000 lbs with 8′ 1″ minimum spacing between axles, tandem; 42,000 lbs, tridem; 48,000 lbs maximum.

When a pilot car is required.

Pilot car (escort vehicle) requirements:

Length: if overall length exceeds 85′ you are required to have 1 pilot car (escort). If overall length exceeds 100′ you are required to have 1 front and 1 read pilot car (escort).

Width: If 10′ to 12′ wide you will be required to have 1 pilot car (escort vehicle). If width exceeds 12′ and up to 14′ you are required to have 1 front and 1 rear pilot car (escort vehicle). From 14′ to 18′ in width you will be required to have 3 pilot cars. 2 front on 4 lane and 2 rear on 2 lane roads with the additional at either end. 18′ up to 22′ in width will require 4 pilot cars (escorts); 2 in front and 2 on the rear. If over 22′ in width you will be required to “close and roll” (closing the road as you move) requiring you to have 5 pilot cars as well as a minimum of 1 police escort.

Weight: You may be required to have a pilot car/cars if you are not able to maintain the minimum speed limit and on some designated bridge crossings depending on your weight class.

Overhang: If overhang is greater than 20′ you will be required to have 1 pilot car vehicle. If over 35′ you will be required to have 1 front and 1 rear pilot car.

Required shipment markings & flags.

Truck, trailer and shipment required signs, banners & flags:

For loads that are over 8′ 6″ in width you will be required to have a “OVERSIZE LOAD” banner on the front or your truck and on the rear of your truck or load, whichever is most practical. Flags must be a minimum length of 16″ and be safety orange or red in color.

Pilot car certifications & requirements.

Pilot car (escort vehicle) certifications & requirements:

A pilot car must be manufactured  as a passenger vehicle (car, truck, van, etc.) with a manufacturers weight of less than 10,000 lbs. All pilot car drivers must be wearing a safety colored vest, jacket or shirt. All pilot cars must be equipped with a rotating, strobe or flashing amber light visible from 360 degrees from a distance of no less than 500′. Vehicle must have a regulations sized hand help SLOW – STOP sign, safety colored flags of no less than 18″ in either direction, 8 road safety flares, 3 reflective road triangles, a 2-way communication device capable of transmitting at least 10 miles and a type A, B and C fire extinguisher.

Travel times and restrictions.

Travel times and restrictions:

Approved permits are valid for 3-5 days unless otherwise stated. Travel times are from Monday through Saturday at noon during daylight hours – the one half hour before sunrise to one half hour after sunset rule applies. However, vehicles not exceeding 85′ in length, 16’in width or 16′ in height can travel Monday through Sunday during daylight hours only. Travel is NOT permitted on the following holiday weekends: New Year’s Day, Memorial Day, Fourth of July, Labor Day, Thanksgiving Day and Christmas Day.

Areas of high traffic densities are restricted from 7:00-8 AM and 4:30-6:00 PM in certain areas (refer to your permit for documentation). Movement is NOT permitted on Kalifornsky Beach Rd, Kenai Spur highway or the Sterling highway from 6:45-9:00 AM and 2:15-4:30 PM during the school months for shipments in excess of 14′ in width. Ketchikan has restricted movement from 7:00 AM to 8:00 AM and from 12 noon – 1 PM and from 4:30 PM to 6:00 PM.  Glenn and Parks Highways to Palmer and Wasilla between the hours of 6:00-8:00 AM and from 11:30-1:00 PM and from 4:30 until 6:00 PM if over 14′ in width.

Frost and thaw laws.

Frost and thaw laws:

Frost and thaw laws are in effect usually from March 1 until mid June on major routes, southern central and the interior. There are so many roads that have different regulations on thaw laws and frost laws. You absolutely will want to call the Alaska State DOT office at the number below for more information. Example: A particular highway may have a set of regulations until you reach a certain mile post, then after that has a whole different set of regulations. There are hundreds of them similar.

Alaska DOT & information.

Alaska state DOT trucking permit contact information:

Division of Measurement Standards Phones:  907-365-1200 or below within Alaska.
Commercial Vehicle Customer Service Center: 800-478-7636
Huffman Business Park
11900 Industrial Way
Anchorage, AK  99515

Phone help line: 907-365-1200
Toll free within Alaska: 800-478-7636
Fax: 907-365-1204
Permit office hours: 8 AM – 5 PM
PACIFIC STANDARD TIME

Alaska state DOT website with all kinds of permit info, forms, manuals, etc here. Alaska heavy-haul and oversize trucking laws.
Road closures and highway conditions here.
Alaska road closure information.

Cities in Alaska: Adak, Akhiok, Akiachak, Akiak, Akutan, Alakanuk, Alatna, Alcan Border, Aleknagik, Aleneva, Allakaket, Alpine, Ambler, Anaktuvuk Pass, Anchorage municipality, Anchor Point, Anderson, Angoon, Aniak, Anvik, Arctic Village, Atka, Atmautluak, Atqasuk, Attu Station, Barrow, Bear Creek, Beaver, Beluga, Bethel, Bettles, Big Delta, Big Lake, Birch Creek, Brevig Mission, Buckland, Buffalo Soapstone, Butte, Cantwell, Central, Chalkyitsik, Chase, Chefornak, Chenega, Chevak, Chickaloon, Chicken, Chignik, Chignik Lagoon, Chignik Lake, Chiniak, Chisana, Chistochina, Chitina, Chuathbaluk, Circle, Clam Gulch, Clark’s Point, Coffman Cove, Cohoe, Cold Bay, Coldfoot, College, Cooper Landing, Copper Center, Copperville, Cordova, Covenant Life, Craig, Crooked Creek, Crown Point, Cube Cove, Deering, Delta Junction, Deltana, Diamond Ridge, Dillingham, Diomede, Dot Lake, Dot Lake Village, Dry Creek, Eagle, Eagle Village, Edna Bay, Eek, Egegik, Eielson AFB, Ekwok, Elfin Cove, Elim, Emmonak, Ester, Evansville, Excursion Inlet, Fairbanks, False Pass, Farm Loop, Ferry, Fishhook, Flat, Fort Greely, Fort Yukon, Four Mile Road, Fox, Fox River, Fritz Creek, Funny River, Gakona, Galena, Gambell, Game Creek, Gateway, Glacier View, Glennallen, Golovin, Goodnews Bay, Grayling, Gulkana, Gustavus, Haines, Halibut Cove, Happy Valley, Harding-Birch Lakes, Healy, Healy Lake, Hobart Bay, Hollis, Holy Cross, Homer, Hoonah, Hooper Bay, Hope, Houston, Hughes, Huslia, Hydaburg, Hyder, Igiugig, Iliamna, Ivanof Bay, Juneau city and borough, Kachemak, Kake, Kaktovik, Kalifornsky, Kaltag, Karluk, Kasaan, Kasigluk, Kasilof, Kenai, Kenny Lake, Ketchikan, Kiana, King Cove, King Salmon, Kipnuk, Kivalina, Klawock, Klukwan, Knik-Fairview, Knik River, Kobuk, Kodiak, Kodiak Station, Kokhanok, Koliganek, Kongiganak, Kotlik, Kotzebue, Koyuk, Koyukuk, Kupreanof, Kwethluk, Kwigillingok, Lake Louise, Lake Minchumina, Lakes, Larsen Bay, Lazy Mountain, Levelock, Lime Village, Livengood, Lowell Point, Lower Kalskag, Lutak, McCarthy, McGrath, McKinley Park, Manley Hot Springs, Manokotak, Marshall, Meadow Lakes, Mekoryuk, Mendeltna, Mentasta Lake, Metlakatla, Meyers Chuck, Miller Landing, Minto, Moose Creek, Moose Pass, Mosquito Lake, Mountain Village, Mud Bay, Naknek, Nanwalek, Napakiak, Napaskiak, Naukati Bay, Nelchina, Nelson Lagoon, Nenana, New Allakaket, Newhalen, New Stuyahok, Newtok, Nightmute, Nikiski, Nikolaevsk, Nikolai, Nikolski, Ninilchik, Noatak, Nome, Nondalton, Noorvik, North Pole, Northway, Northway Junction, Northway Village, Nuiqsut, Nulato, Nunapitchuk, Old Harbor, Oscarville, Ouzinkie, Palmer, Paxson, Pedro Bay, Pelican, Perryville, Petersburg, Petersville, Pilot Point, Pilot Station, Pitkas Point, Platinum, Pleasant Valley, Point Baker, Point Hope, Point Lay, Point MacKenzie, Pope-Vannoy Landing, Portage Creek, Port Alexander, Port Alsworth, Port Clarence, Port Graham, Port Heiden, Port Lions, Port Protection, Primrose, Prudhoe Bay, Quinhagak, Rampart, Red Devil, Red Dog Mine, Ridgeway, Ruby, Russian Mission, St. George, St. Mary’s, St. Michael, St. Paul, Salamatof, Salcha, Sand Point, Savoonga, Saxman, Scammon Bay, Selawik, Seldovia, Seldovia Village, Seward, Shageluk, Shaktoolik, Sheldon Point (Nunam Iqua), Shishmaref, Shungnak, Silver Springs, Sitka city and borough, Skagway, Skwentna, Slana, Sleetmute, Soldotna, South Naknek, Stebbins, Sterling, Stevens Village, Stony River, Sunrise, Susitna, Sutton-Alpine, Takotna, Talkeetna, Tanacross, Tanaina, Tanana, Tatitlek, Tazlina, Teller, Tenakee Springs, Tetlin, Thoms Place, Thorne Bay, Togiak, Tok, Toksook Bay, Tolsona, Tonsina, Trapper Creek, Tuluksak, Tuntutuliak, Tununak, Twin Hills, Two Rivers, Tyonek, Ugashik, Unalakleet, Unalaska, Upper Kalskag, Valdez, Venetie, Wainwright, Wales, Wasilla, Whale Pass, White Mountain, Whitestone Logging Camp, Whittier, Willow, Willow Creek, Wiseman, Womens Bay, Wrangell, Y, Yakutat.

Additional information:

Heavy haul and oversize trucking permit limitations.

Maximum weights; on a single axle with dual tires 30,000 pounds. With tandem axles 56,000 pounds, with tridem axles 70,000 pounds, with quadem axles 80,000 pounds. Gross maximum is 150,000 pounds. All of this depends entirely on the route you choose to travel as well as distance and any bridges that you intend to cross. It also depends upon the length, height and width of the shipment. Between the months of October 1st and March 31st for one, two and three drive axle groupings on trucks and truck tractors traveling the Elliott, Steese and Dalton highways between Fairbanks and Prudhoe Bay you can shift legal axle weights in the following weights on these routes in applicable: single axles 22,000 pounds (with 8’1″ minimum axle spacing). Tandem axles 42,000 pounds, tridem axles 48,000 pounds. The maximum height allowed is 15’3″. Shipments over 14 feet wide or 150 feet long or 16’6″ in height must supply to the permitting department the exact route they wish to travel.

Heavy haul and oversize truck signs and flags.

A standard oversize load sign is required on the front of the tractor and the rear of the shipment if it exceeds 8’6″ and width. The sign must be yellow and have a minimum of 48 inches in width with black letters that are 10 inches tall and 2 inches wide. Acceptable signs when specified shall read “oversize”, “oversize load” or “wide load” for over width vehicles and/or shipments “oversize”, “oversize load” or “long load” for over length vehicles must be affixed to the rear of shipment when overall load exceeds 60 feet in length. Vehicles and loads with rear overhang exceeding 10 feet are subject to the following: must have “oversize” or “oversize load” signs and a amber high intensity rotating, flashing, oscillating or strobe type beacon which must be visible for a minimum of 500 feet from the end of the shipment. You must have either an extended light-bar or a rear pilot car or escort vehicle. All flags must be a minimum of 16” square and must be red. Flags are required to be on vehicles with loads wider than 10 feet and if overhang exceeds the legal limits in any direction.

Pilot car and escort vehicle requirements.

If the width of the shipment is over 10’6″ and up to 12 feet one pilot car or escort vehicle is required. For lengths over 85 feet and up to 100 feet one pilot car is required. If overhang is greater than 10 feet but less than 20 feet one pilot car or escort vehicle may be used. It is possible to use an extended lightbar and place of a rear pilot car. Heavy haul or overweight shipments with special bridge conditions are required to have two pilot cars if the width is 12 feet up to 14 feet to pilot cars or escort vehicles are required if the length is greater than 100 feet to escort vehicles or pilot cars are required. If the overhang exceeds 20 feet unless the rear is greater than 35 feet or the front greater than 60 feet one pilot car is required. For widths over 14 feet three pilot car vehicles or escort’s are required: two in the front and one in the rear. If you have overhang from the rear that is greater than 35 feet to pilot cars are required and for widths up to 18 feet but not more than 22 feet 4 pilot cars or escort vehicles are required. If road closures exist and you are an excess of 22 feet wide then you will be required to have 5 escorts or pilot cars. You may be permitted to use an extended light-bar when up to 20 feet of rear overhang and lieu of a rear pilot car.

Pilot car and escort vehicle requirements.

Pilot cars and escort vehicles may be passenger trucks and cars as long is they are under 10,000 pounds in total weight. Pilot cars and escort vehicles must carry commercial vehicle insurance. Pilot cars and escort vehicles will not carry any passengers. Pilot cars and escort vehicles will not act as a steer man or a tiller man for any load. Oversize load signs and beacons: all escort vehicles and pilot cars are required to be equipped with the appropriate signage. Depending upon the shipment you are working with this might be oversize, wide load or long load and the sign must be roof mounted with a high intensity rotating flashing oscillating or strobe type amber beacon light which must be visible from a minimum of 500 feet in any direction. When a pilot car or in escort vehicle is required to lead any oversize load the appropriate sign must be faced towards the front of the pilot car or escort vehicle when the pilot car or escort is chasing a load the appropriate sign must be faced towards the rear of the vehicle. Pilot car companies and escort vehicle drivers shall carry the following items and equipment at all times when escorting heavy haul and oversize loads: a 24 inch stop slow paddle sign, three bidirectional emergency reflective triangles, 15 pound rated B and C fire extinguisher, a reflector rise orange vest shirt or jacket, a first aid kit, a flashlight with extra batteries, a red cone and be equipped with a red hand flag.

Flag men or flag persons.

The state of Alaska does not require a pilot car or escort vehicle operator to have certification to perform flagging functions flaggers and or pilot car or escort vehicles operators shall complete the state approved flagging test as well is any necessary training prior to working in the capacity of a flagger. There is a fee for the online class. Flag persons shall not be less than 18 years of age and must be capable of carrying out flagging responsibilities in accordance with the Alaska state traffic manual regulations flaggers must be wearing high visibility or florescent orange jackets and vest as well as equipped with a slow stop paddle and a red hand flag these items must be utilized by the pilot car company or escort vehicle operator in the event that it becomes necessary. If required pilot car and escort vehicle operators will need to pull over and Park in order to stop or control Highway traffic. At no time shall the slow stop paddle or red flags be displayed out of the window of a moving vehicle.

Travel time for heavy haul and oversize loads.

Heavy haul permits and oversize trucking permits are valid for 3 to 5 days unless otherwise specified. Travel is permitted from Monday through Saturday at noon during daylight hours. One half hour before sunrise to one half hour after sunset. However, vehicles that are not exceeding 10’6″ wide or 16 feet tall or 85 feet and linked total may travel Monday through Saturday during daylight hours. Oversize vehicles are allowed to operate during hours of darkness under special lighting and taping requirements. Travel is permitted on the following holiday weekends memorial day for for July and Labor Day. Urban areas do restrict travel during peak hours be sure to refer to your permit for specific travel times especially in urban areas.

Spring weight and frost laws.

Weight restrictions and frost laws usually occur on all major routes in South, Central as well as interior Alaska. Typical months are from March 1st until the 1st July.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Alaska State DOT Permits office before commencing movement.
Alaska DOT

Alaska DOT

 

Alaska state rules and regulations.

2019 Alaska state shipping regulations.

 

Delaware State Shipping Regulations

2021 Delaware state shipping laws, regulations, rules, and limitations for oversize and heavy-haul trucking.

Delaware

The great state of Delaware official seal.

 

 

 

 

Delaware Oversize Shipping Trucking & Transport.


Legal Loads.

Length: 60’ (53’ trailer)
Overhang: 3’ front; 6’ rear (included in legal allowable length)
Weight: GVW  80,000 lbs., or 20,000 lbs. per axle.

Delaware

Routine trucking & transport permits.

Length: 100’
Overhang: over 5’ must be permitted
Weight: GVW 120,000
Width:  14’
Height: 15’

How to apply for oversize and heavy-haul trucking permits.

Delaware Department of Transportation
DMV DELDOT Hauling Permits Section
PO Drawer E, Room 208
Dover, DE  19903

Phone: 302-744-2700
Hours: 8 AM until 4:30 PM
Website: www.osow.deldot.gov
E-mail: haulpermit@state.de.us

Basic Oversize permit is valid for 5 days and costs $10

Pilot Car – Escort Car Requirements.

Width over 12’ requires 1 escort car, over 14’ requires 2 escort cars, over 15’ requires State Police escort.
Length over 100’ requires 1 car, over 110’ requires 2 cars, over 120’ requires State Police escort.
Height: None unless specified on the permit after obtained.

Travel times and restrictions.

Travel is permitted from sunrise to sunset with no weekend travel permitted. Travel is also prohibited on the following holidays: New Years Day, Martin Luther King Day, Presidents Day, Good Friday, Memorial Day, Independence Day, Labor Day, Election Day, Columbus Day, Veterans Day, Thanksgiving Day, and Christmas Day. On days preceding a holiday, day movement must stop at 12 noon. Movement may continue the day following the holiday after 12 noon. Be certain to refer to your oversize or heavy-haul trucking permit for any other instructions.

Cities in Delaware: Arden village, Ardencroft village, Ardentown village, Bear, Bellefonte, Bethany Beach, Bethel, Blades, Bowers, Bridgeville, Brookside, Camden, Cheswold, Claymont, Clayton, Dagsboro, Delaware City, Delmar, Dewey Beach, Dover, Dover Base Housing, Edgemoor, Ellendale, Elsmere, Farmington, Felton, Fenwick Island, Frankford, Frederica, Georgetown, Glasgow, Greenville, Greenwood, Harrington, Hartly, Henlopen Acres, Highland Acres, Hockessin, Houston, Kent Acres, Kenton, Laurel, Leipsic, Lewes, Little Creek, Long Neck, Magnolia, Middletown, Milford, Millsboro, Millville, Milton, Newark, New Castle, Newport, North Star, Ocean View, Odessa, Pike Creek, Rehoboth Beach, Rising Sun-Lebanon, Riverview, Rodney Village, Seaford, Selbyville, Slaughter Beach, Smyrna, South Bethany, Townsend, Viola, Wilmington, Wilmington Manor, Woodside, Woodside East, Wyoming.

 

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers, and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Delaware State DOT Permits office before commencing movement.
delaware-state

Delaware state flag.