2020 Mississippi State Shipping Regulations

2020 Mississippi state DOT shipping laws, rules, regulations and limitations for oversize and heavy-haul trucking permits. Pilot car requirements.

Mississippi

The great state of Mississippi official seal.

Please share your knowledge with other visitors below.

Pilot car, oversize and heavy-haul trucking permit quick links.

Locate oversize, heavy-haul trucking companies, pilot cars and permit providers:

Mississippi oversize, heavy-haul and pilot car companies for hire.
Mississippi pilot cars and truck escorts for hire.
Mississippi oversize and heavy-haul trucking permits.

Do I need a trucking permit? Legal load limits.

Mississippi maximum load limits until a trucking permit is required:

Length: The maximum length permitted by the Mississippi DOT is 53 feet for trailers and 99 feet overall including the power unit.
Width: The maximum allowed width is 8 feet 6 inch wide.
Height: The maximum height permitted to travel on Mississippi roads and highways is 13 feet 6 inches.
Weight: 80,000 pounds overall (GVW) and nor more than 12,000 pounds on your steer. Single axle limit is 20,000 pounds, tandem axle limit is 34,000 pounds, tridem axle limit is 42,000 pounds.
Overhang: You are permitted to have a maximum front overhang of 3 feet and a rear maximum overhang of 14 feet and 11 inches legally.
Notes:

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Mississippi:

Length: Overall trucking permit limits for length are up to 120 feet.
Width: You can now get routinely approved for up to 20 feet wide for some routes.
Height: 17 feet is the maximum routine limit for permits.
Weight: Steer: 12,000 pounds, single axle: 20,000 pounds, tandem axles: 48,000 pounds, tridum axle: 57,000 pounds, and up to 63,000 pounds if interstate only. Quadem axles: 64,000 or up to 72,000 pounds if on interstates only. Maximum gross weights on 5 axles: 113,000 pounds, 6 axles: 123,000 pounds, 7 axles: 128,000 pounds, 8 axles: 141,000 pounds. Over-weight dozers in most cases are allowed to be permitted with blade detached and included on trailer. IN many cases you for over-weight shipment a comprehensive, detailed review including drawings of the product, trailer and axle spacings as well as the route you prefer to travel will be required when filing for Mississippi heavy-haul trucking permits.

Overhang: Mississippi DOT has no set limitation for overhang for routine permits should not be a problem unless you intend on exceeding the law of 1/3 (no more than 1/3 of item being shipped overhangs).
Notes: If you are not sure about any routes in Mississippi you can use their route checker here to look up your limits. For more documentation see; Mississippi oversize and heavy-haul permit regulations.

Mississippi superloads.

Mississippi superload information: 

Length: When over 120 feet in length overall combined a superload permit will need to be filled.
Width: If the shipment is in excess of 20 feet in width a superload permit will be required.
Height: When in excess of 15 feet and 7 inches in height if you have a second dimension that is over the legal limit or depending on your desired route you may be required to file as a superload. 15 feet and 7 inches in height will require a route survey. Over 16 feet in height will reguire a route survey, letters from all pertinent utility companies and special approval from the MS DOT permitting department which may result in superload permit applications.
Weight: Whenever a shipment is in excess of 141,000 pounds it will qualify as a superload and must be permitted as a superload in order to ship.
Overhang: Overhang alone will more than likely not be a determining factor if superload permits are required.
Notes: Always work with Mississippi state DOT proactively. They’ll do their best to get the shipment in the proper category and correct permit issued. Excessive weights must meet bridge analysis specifications in order to be safely transported.

Lights, safety flags and warning signs for heavy haul and oversize loads.

Required safety markings, safety flags, warning lights for heavy haul and oversize loads:

All shipments that are oversize (and over 12 feet wide) being transported within the state of Mississippi are required to have signs. Sign dimensions will need to be at least 84 inches wide and 18 inches in height. All signs should have the words “OVERSIZE LOAD” on them and black letters that are at least 10 inches in height and 1 and 5/8 inches thick. All signs should have a yellow background with black letters. Red or orange fluorescent safety flags are required as well as and should be used on all four of the outer most extremities of the combination (front to rear) and mounted a minimum of 6 feet above pavement level. All safety flags should be minimum of 18 inches square in shape. If the shipment is in excess of 12 feet wide it is required to have flashing amber lights mounted on both sides of the rear extremities in all cases.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanies by a escort vehicle or pilot car if:

QUICK REFERENCE

Length:

  • If in excess of 95 feet overall; 1 pilot car/escort vehicle will be required. Some routes will require 2.
  • If in excess of 105 feet overall: 1 pilot car and 1 escort vehicle will be required..

Width:

  • If permitted to travel during night hours 1 escort vehicle will be required when 10 feet or more wide.
  • If in excess of 12 feet and 11 inches 1 pilot car or escort vehicle is required.
  • If in excess of 16 feet wide 1 pilot car and 1 escort vehicle will be required.

Height: Mississippi state DOT may require 1 pilot car vehicle equipped with a height pole on some routes if over 14 feet in height. A route survey may be mandatory for shipments in excess of 15 feet and 7 inches in height depending on desired route..
Overhang: If in excess of 15 feet in the front will require 1 front lead pilot car is required.  chase escort vehicle is required. Some routes require 1 lead pilot car rather than chase.

 DETAILED REFERENCE

Length:

Pilot cars or escort vehicles (front of rear depends on route and lanes) will be required whenever the overall combined length of the shipment exceeds 95 feet. If the shipment is in excess of 105 feet overall you may be required to have 1 front lead pilot car and 1 rear chase escort vehicle depending on route.
Width: Over 10 feet wide anytime night travel is permitted requires 1 pilot car or escort vehicle. Over 12 feet and 11 inches requires 1 pilot car/escort vehicle. Over 13 feet wide requires 1 front lead pilot car on 2-lane roads or 1 rear chase escort vehicle on 4-lane roads.
Height: 15 feet and 6 inches (over 15 feet and 7 inches requires a route survey) may require 1 lead pilot car depending on desired route. A lead pilot car equipped with a height pole will be required for shipments in excess of 16 feet in height.
Notes: In some cases a rear escort can be eliminated by attaching 2 (5 inch) amber lights mounted on the rear of the shipment. If you plan to implement this option note that you are also required to have a monitoring device in the truck cab that confirms both amber light bulbs are in operation.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

Mississippi law for pilot cars is very basic. We suggest you follow the federal pilot car and escort vehicle requirement guidelines but as of 2018 the requirements are as follows: A single motor vehicle equipped with a amber rotating or strobing light mounted at the top of the vehicle. Two red or range fluorescent safety flags mounted on the vehicle. A “OVERSIZE LOAD” mounted at either the top of the vehicle that does not obstruct view of the strobe/rotating amber light of a “OVERSIZE LOAD” sign mounted to the front when leading or rear when chasing (following) a oversized load. Signs must be covered when not in operation.

 

Legal travel times for oversize and heavy haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

Daylight hours are define as 1/2 hour after sunrise and 1/2 hour before sunset. Travel is permitted on Saturdays with no travel at all permitted on Sunday. If your shipment is in excess of 12′ wide you may not travel on Saturday. You may not travel on the following holidays: New Years day, Memorial day, Independence day, labor day, Thanksgiving day and Christmas day. You may not move any later than 12 noon on any day that comes before one of these holidays. For shipments that are in excess of 12′ in width you are strongly encouraged to route your shipment around high traffic density areas and may not travel in areas of high traffic from 7 AM – 8:30 AM and again from 4:30 – 5: 30 PM with the exception of I-10 ( travel during these hours is permitted).

747 in transport via CRS Pilot Car


DOT contact information and notes.

Mississippi state DOT office permit contact information:

Mississippi Department of Transportation Permit Division
Post office box: 1850
Jackson, MS 39215
Telephone: 601-359-1717 or Permits: 888-737-0061
Office hours: 7:30 AM until 4:30 PM
Website: https://www.expresspass.ms.gov/trucking/
E-mail: msdotpermits@mdot.ms.gov
Central Daylight Time
Notes:
To file for oversize or heavy-haul trucking permits online you must have a account already set up with MS state DOT. MS is a member of SASHTO.




Mississippi cities serviced.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Mississippi DOT Permits office before commencing movement.
Mississippi state regulations for oversize and overweight shipping.

Mississippi state flag.

2020 Arkansas State Shipping Regulations

2020 Arkansas state DOT shipping laws, rules, regulations and limitations for oversize and heavy-haul trucking permits. Pilot car requirements.

Please share your knowledge of Arkansas state DOT trucking regulations with others below.

Arkansas

Arkansas oversize permits, heavy-haul trucking companies and pilot cars.

Locate oversize, heavy haul trucking companies, pilot cars and permits:

Arkansas pilot cars and truck escorts for hire
Arkansas oversize and heavy-haul trucking companies for hire.
Arkansas oversize and heavy-haul trucking permits.


Do I need a trucking permit? Legal load limits.

Arkansas maximum load limits until a trucking permit is required:

Length: Maximum trailer length with a load is 53 feet and 6 inches long.
Width: 8 feet and 6 inches wide.
Height: 13 feet and 6 inches tall.
Weight: 80,000 pounds gross(GVW). Steer axle is whatever the manufacturer lists it as or no greater than 20,000 pounds. 20,000 pounds on any single axle , 34,000 pounds gross on any tandem axle, 54,000 pounds on any tridum axle.
Overhang: Arkansas is NOT clear on overhang which indicates they don’t like it. If you’re considering it call them and be sure to let our visitors know below.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Arkansas:

Length: No set maximums.
Width: Up to 18 feet on interstate and up to 20 feet on others.
Height: 17 feet maximum. If over 16 feet tall (no interstate travel) approval will be required depending on desired route.
Weight: Maximum gross weight is 180,000 pounds. Typically steer axle is 12,000 pounds (unless manufacture specs allow for more – contingent upon spacings). Single axle is 20,000 pounds, tandem axles is 46,000 pounds, tridum axles is 60,000 pounds and 68,000 pounds on quadem axles. Routine permits cap out at 180,000 pounds gross.
Overhang: Depending on what you are hauling: poles, manufactured homes it’s all over the board. For more info see: Arkansas permit laws.

Super load information for Arkansas.

Arkansas state DOT will classify any shipment in excess of the following as a super load:

Length: Depends on your route needs.
Width: Anything in excess of 20 feet will be classified as a super load. 
Height:
Over 17 feet in height will require bucket trucks and route survey – count it as a super load.
Weight: If over 180,000 pounds.
Overhang: Share with us your experience (below) as Arkansas is all over the board on overhang.

Lights, safety flags and warning signs for heavy haul and oversize loads.

Required safety markings, safety flags, warning lights for heavy haul and oversize loads:

Any combination or shipment in excess of the legal dimensions must be properly marked. Signs stating “OVERSIZE LOAD” are required to be displayed on the front of the combination as well as the rear of the load. In addition red or orange colored safety flags that are 18 inches square must be placed on the front of the power unit and rear corners of the load. Typically night movement is not permitted however, always refer to your permit for any special lighting requirements. Heavy haul shipments may not be required to display signs but again refer to your permit.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanies by a escort vehicle or pilot car if:

For a vehicle to qualify; all pilot car/escort vehicles must have a gross weight over over 2,000 pounds but also have a manufacturers gross weight rating of less than 26,000 pounds.
Length: If load is 75′ to 95′ on a 2 load road you will need one rear pilot car (escort).
Width: 10′ 6″ to 12′ wide on a 2 lane road requires 1 front pilot car. On a 4 lane road up to 12′ wide requires no escorts. When load is 12′ 1″ to 14′ wide 1 front and 1 rear pilot car (escort) is required on all 2 lane roads and 1 rear on all 4 lane roads. For loads 14′ 1″ – 15′ wide 1 front and 1 rear pilot car (escort) is required. 15′ 1″ to 16′ wide on 2 lane requires 2 front pilot cars (escorts) and 1 rear pilot car (escort). On 4 all lane roads 1 front and 2 rear pilot cars (escorts) are required. If you do have a permit for weekend travel you will be required to have a police escort. Districts and Parkways may require additional escorts as well. Vehicles traveling with a width of over 14′ wide will not be allowed to travel on Fridays except on Parkway. Maximum width allowed on the Parkway is 16′ and must be accompanied by police escort if over 15′.
Height: If height of load exceeds 15′ a front high pole car is required.
Weight: Check with the State of to see if your weight class will require a pilot car/escort.
Overhang: If front over hang is over 10′ on 2 or 4 lane roads 1 front pilot car (escort) is required. If rear overhang exceeds 10′ on a 2 or 4 lane road one rear escort is required.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

All pilot cars/escort vehicles must display a bumper or roof mounted “OVERSIZE LOAD” sign visible from both the front and rear of the vehicle. Sign must be at least 5′ long and 12″ in height, yellow in color with black letters no less than 10″ tall and 1 1/2″ in width. Vehicle must have 2 safety flags red or orange in color and be a minimum of 18″ of length and/or height mounted at a 40 to 70 degree angle on all 4 corners of the vehicle. Company identification signs must be placed on both sides of the pilot car (escort vehicle) displaying the name of the company, phone number and be placed on both the left and right hand sides of the vehicle. These signs must be no less that 8″ tall x 12″ wide and identity writing must be plainly legible. Vehicle must be equipped with a horizontally mounted rotating (or strobe) amber colored flashing light which must be visible from a 360 degree angle from a minimum of 500 feet. Vehicles must be equipped with a CB radio or 2-way communication device, 2 – 5 pound fire extinguishers type A, B and C, a sign with the word “STOP” on one side and “SLOW” on the other with dimensions of no less than 18″ in diameter with a minimum of 6″ letters. A red safety colored flag with handle no less than 18″ square, 3 reflective emergency road triangles or 18″ traffic cones, 2 OVERSIZE LOAD banners (yellow with black lettering) and a safety colored (red, orange, yellow or lime green) vest, jacket or shirt (used while directing traffic).

Legal travel times for oversize and heavy haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

Most travel is restricted to daylight hours only in Arkansas. Continuous travel may be permitted for heavy haul loads that are not oversize. It is possible under some circumstances to obtain weekend travel permission for some routes/smaller dimensions upon request (when filing). No travel is permitted when visibility is obstructed or inclement weather exists which can include but not limited to: snow, hail, rain, wind, etc. Always follow instructions on your permit as well as travel advisories for more information. CURFEWS: Little Rock area from 7 AM until 9 AM and 4 PM until 6 PM and also including I-30, mile marker 137 to 143, I-40 from mile marker 151 to 155 and all of Interstate 630. Holiday travel is restricted when the holiday is on a Monday or Friday (no weekend travel permitted) on New Years Day, Memorial Day, Independence Day, Labor Day, Thanksgiving Day and Christmas Day. However, you may travel on Martin Luther King Day, Robert E. Lee’s Birthday, George Washington’s Birthday and on Veterans Day.

Arkansas DOT contact information and notes.

Arkansas DOT office and permit contact information:

Physical address:
Arkansas State Highway and Transportation Department
10324 Interstate 30
Little Rock, AR 72203
Telephone: 501-569-2381 order permits by phone from 6 am to 4:30 pm M-F.
Hours: 6 AM until 4:30 PM Monday thru Friday.
Central Time Zone
Arkansas is a member of the SASHTO.
Arkansas State DOT website for additional info.

Arkansas cities serviced:

Recent Posts

  • Alaska state rules and regulations.
    Alaska Shipping Regulations
    2020 Alaska DOT shipping laws, regulations, rules, limitations for oversize and heavy-haul trucking permits for pilot cars and trucking companies. Share your knowledge with others below.! Heavy haul trucking, pilot cars and permits. Locate heavy haul, oversize equipment shipping companies, pilot cars and ordering trucking permits in...
  • Illinois State Shipping Regulations for oversize and heavy haul.
    Illinois State Shipping Regulations for oversize and heavy haul.
    Shipping laws, regulations, limitations and rules for shipping oversize and over-weight loads over the roads and highways in the state of Illinois. Please share your expertise or knowledge of Illinois state shipping regulations with other visitors below. Trucking and pilot car location system: Locate trucking companies and...
  • Frost/thaw damages to surface.
    2020 Frost winter frost laws, thaw laws and weight restrictions.
    2020-2021 Frost laws, thaw laws and seasonal weight restrictions. Learn the details of the winter frost laws, spring thaw laws and seasonal weight restrictions. Details for the USA and Canada by State/Province. Many areas incorporate temporary special weight limits and restrictions (frost or thaw laws) during the...
  • COVID-19 Response. Logistics supply.
    COVID-19 Response. Logistics supply.
    COVID-19 response – logistics supply chain. As the world continues to change on an hourly basis due to the outbreak of the Corona-19 virus, we are hoping that all our customers and clients are well and taking every precaution to stay well. We acknowledge the severity  of...
  • 2020 Mississippi State Shipping Regulations
    2020 Mississippi State Shipping Regulations
    2020 Mississippi state DOT shipping laws, rules, regulations and limitations for oversize and heavy-haul trucking permits. Pilot car requirements. Please share your knowledge with other visitors below. Pilot car, oversize and heavy-haul trucking permit quick links. Locate oversize, heavy-haul trucking companies, pilot cars and permit providers: Mississippi...

Arkansas road & highway conditions.
Federal bridge formula.
Frost laws.

arkansas-state

Michigan State Shipping Regulations

2020 Michigan state DOT shipping laws, rules, regulations and limitations for oversize and heavy-haul trucking.

Michigan

The great state of Michigan official seal.

Help others by sharing your knowledge of Michigan state regulations below.

Michigan oversize permits, heavy-haul trucking companies and pilot cars.

Locate oversize, heavy-haul trucking companies and pilot cars:

Michigan oversize, heavy-haul and pilot car companies for hire.
Michigan oversize and heavy-haul trucking companies for hire.
Michigan oversize and heavy-haul trucking permits.

Do I need a trucking permit? Legal load limits.

Michigan maximum load limits until a trucking permit is required:

Length: Overall no longer than 75 feet on designated highways.  Trailer length maximum is 50 feet on non-designated and 53 feet on designated.
Width:  96 inches on non designated highways and 102 inches (8 feet 6 inches.) on designated.
Height: 13 feet 6 inches tall.
Weight: 80,000 pounds GVW, 20,000 pounds on single axles (not steer), 34,000 pounds on tandem axles.
Overhang: 3 feet in the front and anything over 4 feet in the rear must be red flagged in the day and have a red light at night.
Notes: There’s no restriction on maximum length of combination of truck-tractor and semitrailer with or without load

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Michigan:

Length: Under 150 feet in length.  Anything over 150 feet is classified as a superload (105 feet maximum for mobile homes).
Width: Figure up to 16 feet as a routine permit.  Anything over is going to looked at seriously and they may even classify you as superload.
Height: Up to 15 feet is routine.  If you are over 15 feet high count on needing a route survey.
Weight:  All weights in excess of 80,000 pounds over all are decided on a case by case basis. Anything over 150,000 lbs is subject to a bridge weight study.
Overhang: Any shipment in excess of 4 feet of overhang is permitted on a case by case basis only.
Notes: Maximum speed for any permitted shipment is 45 MPH. Permits for heavy shipments may take more than 10 days to process.

Michigan superloads.

Information about shipping superloads in the state of Michigan.

If your shipment is in excess of any of the following weights or dimensions it may be classified as a superload.

Length: Anything over 150 feet.
Width: 16 feet or over.
Height: 15 feet and over is classified as a superload. Some limited routes may vary.
Notes: We have no weight maximums to report. Height may be on a case by case basis.

Lights, safety flags and warning signs for heavy haul and oversize loads.

Required safety markings, safety flags, warning lights for heavy haul and oversize loads:

All oversize load shipments will be required to display 2 “Oversize Load” signs. On must be mounted to the bumper of the truck and the other to the rear of the trailer. Signs must be a minimum of 7 feet in width and 18 inches in height with 10 inch black letters on a yellow background. Flags are required on all 4 corners of the combination and be safety red or orange in color and be 18 inches square. If the item being shipped has dimensions extending beyond the trailer then the extremities must be flagged as well. Headlights must be on at all times. A minimum of 2 flashing of strobing lights must be mounted to the rear portion of the load.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanies by a escort vehicle or pilot car if:

Length: 90 feet to 100 feet one on the rear. Over 100 feet requires a rear pilot car or “chase” escort vehicle.
Width: Loads over 12 wide on 4 lane is required one rear escort/pilot car. A lead or front pilot car is required for loads on 2 lane highway over 12 feet wide.  Front and rear pilot cars/escorts are required for loads over 14 feet wide.
Height: Over 14 feet and 5 inches is required to have a pilot car equipped with a height pole. Over 15 feet in height will require a rear chase escort vehicle in addition to 1 lead pilot car equipped with a height pole.
Overhang: If over 15 feet 1 rear escort is required.
Weight: If truck can maintain minimum speeds no pilot cars are required unless excessive or superload.
Note: Allow 1 to 10 days for permits to be approved. Distance for pilot car to lead/chase load 500′ unless otherwise stated on permit. This is the distance between lead/chase and the truck/trailer. Maximum speeds of 45 MPH if 4 or more lanes, 35 MPH is under 4 lanes. Also read travel restrictions below.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

In order to qualify as a pilot car vehicle in the state of Michigan you must either have a pickup truck or a passenger car with at least one rotating or flashing amber light mounted on the top of the vehicle. Pilot cars and escort vehicles must also display one oversize load sign that is 5′ x 1′ tall and have black letters no less than 8 inches tall on a yellow background. All flashing, stroking or rotating amber lights must be visible from a distance of no less than 500 feet. In addition to this we strongly suggest pilot cars and escort vehicles have the minimum of federally suggested equipment.

See: Pilot_Car_Escort_Best_Practices_Guidelines_508CLN

Legal travel times for oversize and heavy haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

Travel time is sunrise to sunset daylight only with the half hour before sunrise and a half hour after sunset leniency rule.  No weekend travel.  No holiday travel or the day after Christmas or Thanksgiving. They have rush hours rules from 7:00 AM to 9:00 AM and 3:00 PM to 6:00 PM in a whole list of counties (look on permit). Wind restrictions if over 24 MPH you can’t run. Frost and thaw laws in effect from Feb. until April on weight. You can view holiday restrictions.Lindemeyer, Transport, LLC.

Michigan DOT contact information, notes and resources.

Michigan DOT contact information:

Physical address:
Michigan Department of Transportation – DOT, Permits Unit
425 West Ottowa Street
Lansing, MI  48909
Email: click here for e-mail contact form on state website.
Telephone: 517-241-8999
Hours: Monday thru Friday 7:30 AM – 4:30 PM (closed from 12 until 1:00 PM)
Eastern Standard Time
Michigan is a member of MVCSHTO.

Very helpful documents:
Michigan Farmer’s Transportation Guide
Shipping mobile homes in Michigan
Michigan superloads – route surveys
Oversize-weight-permits-maximums
Michigan maximum dimensions

Michigan full breakdown of laws:

Michigan cities we service:

Helpful information

  • Alaska state rules and regulations.
    Alaska Shipping Regulations
    2020 Alaska DOT shipping laws, regulations, rules, limitations for oversize and heavy-haul trucking permits for pilot cars and trucking companies. Share your knowledge with others below.! Heavy haul trucking, pilot cars and permits. Locate heavy haul, oversize equipment shipping companies, pilot cars and ordering trucking permits in Alaska: Alaska heavy...
  • Illinois State Shipping Regulations for oversize and heavy haul.
    Illinois State Shipping Regulations for oversize and heavy haul.
    Shipping laws, regulations, limitations and rules for shipping oversize and over-weight loads over the roads and highways in the state of Illinois. Please share your expertise or knowledge of Illinois state shipping regulations with other visitors below. Trucking and pilot car location system: Locate trucking companies and pilot cars in...
  • Frost/thaw damages to surface.
    2020 Frost winter frost laws, thaw laws and weight restrictions.
    2020-2021 Frost laws, thaw laws and seasonal weight restrictions. Learn the details of the winter frost laws, spring thaw laws and seasonal weight restrictions. Details for the USA and Canada by State/Province. Many areas incorporate temporary special weight limits and restrictions (frost or thaw laws) during the winter and spring...
  • COVID-19 Response. Logistics supply.
    COVID-19 Response. Logistics supply.
    COVID-19 response – logistics supply chain. As the world continues to change on an hourly basis due to the outbreak of the Corona-19 virus, we are hoping that all our customers and clients are well and taking every precaution to stay well. We acknowledge the severity  of this situation and...
The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Michigan State DOT Permits office before commencing movement.
Michigan state DOT regulations for heavy haul and oversize loads.

Michigan state flag.

2020 Nevada State Shipping Regulations

2020 Nevada state shipping laws, regulations, rules, limitations for oversize and heavy-haul trucking permits.

Nevada

The great state of Nevada state seal.

Please share your knowledge of Nevada state shipping regulations with other visitors below.

Locate oversize, heavy-haul trucking companies and pilot cars.

Nevada oversize, heavy-haul trucking companies and pilot cars for hire:

Nevada pilot cars and truck escorts.
Nevada oversize and heavy-haul trucking companies.


Do I need a trucking permit? Legal load limits.

Nevada maximum load limits until a trucking permit is required:

Length: 75 feet maximum overall. Maximum trailer length is 53 feet.
Width: 8 feet 6 inches.
Height: 14 feet.
Weight: GVW 80,000 pounds. Single axle 20,000 pounds, tandem axles 34,000 pounds, tridem axles 42,000 pounds. Steer axle maximums require some math obviously. Here’s what the NVDOT says about it: “The maximum weight per tire, measured by pounds per inch of tire width, is 600 pounds per inch for the steering axle and 500 pounds per inch for all other axles, not to exceed the axle rating”. We say good luck with that, 12,400 pounds average???
Overhang: The maximum overhang allowed is 10 feet which overall must NOT exceed the maximum length of 75 feet.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in NV:

Length: There really isn’t any routine maximum length. It all depends on proposed route and the state. After 105 feet in length it can get complicated.
Width: 17 feet. However some routes are restricted, see notes below;
Height: 16 feet.
Weight: Single axles 20,000 pounds, tandem axles 46,725 pounds, tridem axles 58,000 (to 59,000 see below) pounds. Determined by bridge formula, desired route, tire size and axle spacings especially for singles, tandems, tridums and quadem axles. Gross weights are: 5 axles 92,000 pounds with 70 feet minimum axle spacings, 6 axles 96,000 pounds with 70 feet minimum of axle spacings, 7 axles 101,000 pounds with 70 feet minimum of axles spacings, 8 axles 106,000 pounds with 70 feet minimum of axles spacings.
Overhang: No more than 15’ combined total but you want to check with them to make absolute sure as routing can effect this limit.
Notes: For weight restrictions Nevada has different routes marked. Choose the map you need for the entire state, western, eastern and southern restricted areas. You can also view a list. For purple, orange and green areas. Also, restrictions for width and weight are in effect on the following routes: route map, route list. Also note to get the extra 1,000 pounds as noted above (59,000 pounds on tridem configurations) you are allowed to use up to 2 tridem configurations only. Any additional tridem axle configurations will max out at 51,000 pounds. If you have tridem configurations on your tractor that will be counted as 1 of the 2. However, the distance between the steer axle and the center tridum axle must be a minimum of 18 feet. It is possible to to exceed this within reason but is reviewed case by case by the NVDOT permitting office.

Nevada superloads.

Requirements for extra-heavy or over-dimensional (superloads) in NV:

Nevada is picky about weights and heights. Rather than attempting to illustrate a list of items that may not apply we suggest if your shipment does not fall within the set maximums listed above it’s more than likely going to be considered a superload by NVDOT. The permitting process for superloads is different than the normal oversize or over-weight trucking permits in Nevada and must be fully drafted by the company or person requesting the permit. For instructions for the format your super-load application must be in see: Nevada-superloads.

NOTE: any special purpose or special needs loads that are outside of the normal permitting parameters will classify as a superload.

Legal travel times for oversize and heavy-haul loads.

Travel times and restrictions:

Remember to refer to your actual permit for travel times and restrictions. For Nevada daylight travel hours are defined as one half hour before sunrise to one half hour after sunset with some restrictions;  under 12 feet wide, 110 feet long or 15 feet tall may also travel during night hours and on weekends as long as you are not on I-80 between Sparks, NV and the CA state border or on I-15 between Las Vegas and the CA state border. There are no weekday curfews for any cities and if your load is under 12 feet wide, 100 feet long or 15 feet tall you may travel on holiday. However, if your load is in excess of these dimensions  holiday travel restrictions are on the following days: New Years day, Memorial day, Independence day, Labor day, Thanksgiving day and Christmas day. If a large event is predicted to create dense traffic they may restrict that date as well, ie: state fairs, etc.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanied by a escort vehicle or pilot car if:

QUICK REFERENCE

Length:

  • over 105 feet in length requires on escort. This applies to both 2 lane and 4 lanes roads.

Width:

2 lane roads:

  • 12 feet requires 1 pilot car or escort.
  • 14 feet requires 1 pilot car and 1 escort.
  • 16 feet requires 3 total pilot cars and escort vehicles.
  • 17 feet will require a review which will probably require 1 pilot car and 1 escort and 1 police escort.

4 lane roads:

  • 14 feet requires 1 pilot car or escort.
  • 16 feet requires 1 pilot car and 1 escort.
  • 17 feet requires 1 pilot car and 1 escort and 1 police escort.

Height:

  • if over 16 feet and 6 inches in height you will be required to have 1 pilot car equipped with a height pole.

DETAILED REFERENCE

Length: If shipment is over 110 feet in length you are required to have 1 pilot car behind the shipment.
Width: If your shipment is over 12′ wide on up to a 3 lane road you are required to have 1 escort vehicle in the front of your shipment. If over 14′ wide on up to a 3 lane road you are required to have 1 escort in the front and 1 pilot car in the rear of the load.  If over 14′ wide on a 4 lane road you are required to have 1 rear escort. If over 16′ you are required to have 1 front pilot car and 1 rear escort on 4 lane and all other roads.
Height: Loads that are in excess of 15′ 6″ are required to have a front high pole pilot car at all times.
Weight: Pilot cars and escorts are usually not required on shipments over weight that are able to maintain the minimum posted speed requirements. If you are not able to maintain minimum speeds you will be required to have a minimum of a rear escort vehicle if travelling in urban and some rural areas.
Overhang: If in excess of 25 feet you will be required to have a minimum of 1 pilot car.
Notes: Some routes are completely restricot car.ted. If in the Hoover dam vicinity shipments are not permitted for anything over 10 feet in width but if 10 feet will require 1 pilot car and 1 escort.

Pilot car and escort vehicle requirements, certifications.

In order to operate a pilot car or escort vehicle in the state of Nevada you are required to have a minimum of the following:

First of all the state of Nevada requires that all pilot and escort vehicles be certified. If you are officially certified by another state then this is recognized by the state of Nevada as valid certification and you may operate within the state however, in order to have an amber light mounted to ANY vehicle you must first obtain a permit from the state which costs $2.00 per vehicle, per year. You can do that online by clicking here.
A pilot car or an escort vehicle is required to be equipped with a strobing or flashing amber light that is visible from a distance of no less than 500′ in daylight and from all 360 degree angles, mounted to the roof and above signs. The light must be a minimum of 50 candle power and if it is a rotating light must have a lens of no less than 5″ in diameter with a flash count or not less than 50 per minute. Any vehicle used for this purpose must be no less than 60″ in width, with a wheelbase of a minimum of 95″ with no more than 2 axles and a manufacturer’s gross weight of no more than 16,000 pounds.
Each vehicle must be equipped with a two way radio that is in constant contact with/to all parties involved in the shipment, 5 pound (minimum) fire extinguisher, 3 bi-directional 18″ road triangles, 1 stop/slow sign with 5′ pole handle, 1 hard hat, 1 reflective safety vest, a copy of the ANSI/ISEA manual which can be ordered online here for $30. Drivers must be a minimum of 18 years of age, have a valid drivers license, and must be flagger/flagman “capable or carrying out flagging responsibilities” (we strongly suggest a flagger safety class) of controlling traffic, wearing a approved safety yellow-green safety jacket or vest and equipped with a red flag and a stop/slow paddle of no less than 18″. Each vehicle should be equipped with proper signs that specify “oversize”,  “oversize load” or “wideload” as well as “long load” with black letters a minimum of 10″ in height with a letter thickness of no less than 1 5/8″ on a yellow background which are removed or covered while not in work transit mode. Pilot car and escort vehicles must have a placard on each side of the vehicle with the companies name and phone number clearly visible from a distance of no less than 50′.
Operators of pilot cars and escort vehicles will maintain a reasonable distance from the shipment which all depends on weather, traffic, road conditions and the speed you are travelling with reasonable distance defined by how much time it takes for the shipment driver to recognize your indications to stop, slow or pass as necessary.

Shipment, truck and trailer markings.

Truck, trailer and shipment required signs, banners and flags:

All trucking companies that are hauling oversize and overweight shipments must have a amber colored strobing or flashing light affixed to the top of the tractor trailer cab that is visible 360 degrees from a minimum distance of 500′. Signs that state the nature of the shipment; “oversize load” or “wideload” signs in the overall front and rear of the shipment. Signs will be no less than 7′ in width and 18″ in height with black lettering no less than 10″ in height with a lettering thickness of no less than 1 5/8″ thick on a yellow background. Signs must be mounted securely and free of any dirt or debris. Warning flags are to be used only in daylight hours and must be florescent orange in color with a minimum size distance of 18″ from one corner to the next corner and be placed at the outer most corners of the shipment as well as on any protrusions. IF the shipment is permitted to travel during night hours must have 2 constant display amber lights placed at the very most front extreme of the shipment,  two amber steady burning lights on the outer (side) center of the shipment and two red steady lit lights on the outer most rear of the shipment. THIS INCLUDES OVER-WEIGHT LOADS MOVING AT NIGHT.

Frost laws and restrictions for Nevada state.

Frost and thaw laws for Nevada:

Nevada is fairly elusive on frost and thaw law travel restrictions. They do provide a map but there is not much detail on it as far as the exact roads that must be travelled. You can view the frost law map or view this thaw law material published by the state DOT which does reference it as well. Then they also have some basic shipment route information that references it as well for the state of Nevada.

Nevada DOT and permit contact information.

Physical address and contact information:
Nevada Department of Transportation
1263 South Stewart Street. Room 102
Carson City, NV  89712
Telephone help line: 775-888-7410 or 800-552-2127
Permit office hours: 7:30 AM – 4:45 PM (no permits after 4 PM) Pacific Time Zone
E-mail: overdimensionalpermitsoffice@dot.state.nv.us

Resources:
Order Nevada heavy haul and oversize trucking permits.
Nevada oversize and heavy-haul trucking laws.

Nevada oversize and heavy-haul shipment.

Nevada cities serviced.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Nevada State DOT Permits office before commencing movement.

nevada-state

2020 Minnesota State Shipping Regulations

2020 Minnesota state DOT shipping laws, regulations, rules, limitations for oversize and heavy-haul trucking permits.

Minnesota

Heavy-haul trucking and pilot car regulations.

Minnesota oversize, heavy-haul and pilot car companies for hire:

Minnesota pilot cars and truck escorts for hire
Minnesota oversize and heavy-haul trucking companies for hire.
Minnesota oversize and heavy-haul trucking permits.

Do I need a trucking permit? Legal load limits.

Minnesota maximum load limits until a trucking permit is required.

Length: Trailers no longer than 53 feet on designated highways.  All other roads 53 feet.
Width: 8 feet and 6 inches.
Height: 13 feet and 6 inches.
Weight: 80,000 pounds GVW, 20,000 pounds on a single axle, 23,000 pounds on tandem axles with spread limited to 20,000 pounds, 20,000 pounds on tridem axles, quadem axles is 18,000 pounds maximum.
Overhang: 3 feet in the front and anything over 4 feet in the rear must be red flagged in the day and red light at night.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Minnesota:

Length: Combinations overall length over 75 feet requires a permit. Single vehicles that exceed 45 feet require a permit. Anything under 130 feet long is considered routine.
Weight: Single axle 20,000 pounds, 40,000 pounds on tandem axles (46,000 pounds with a bridge check), tridem axles 60,000 pounds, quadem axles 72,000 pounds,  trunion axles 60,000 pounds. Gross weights: 5 axles 92,000 pounds, 6 axles 112,000 pounds, 7 axles 132,000 pounds, 8 axles 144,000 pounds. Over 150,000 pounds is a superload.
Width: Figure up to 14 feet to 16 feet as a routine permit. Anything over 16 feet wide man have routing issues and require a route survey.
Height: Over 13 feet and 6 inches requires a permit. Up to 14 feet is easy, then at 15 feet and 6 inches route restrictions start to apply. If over 15 feet and 6 inches you have the pleasure of paying for a route survey unless it’s an easy short run then you may wiggle out of it.
Notes: Farm equipment operating at less than 30 miles per hour may be exempt. Utility poles may be exempt. Heavy-haul loads have to deal with frost laws. Visibility from inclement weather can side-line you as well.

Minnesota superloads.

What constitutes a superload in Nebraska:

Superloads in the state of Nebraska are defined as any shipment in excess of the above weights or dimensions described above in “routine”.  Also see: Laws for Minnesota state oversize and heavy-haul.

Legal travel times for oversize and heavy-haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

Travel times are primarily from 2 AM until 10 PM except for holidays.  Some areas have rush hour restrictions 7:30 AM to 8:30 AM and 4:00 PM to 5:30 PM so check your permit as any applicable restrictions will be listed on it. For heavy-haul loads there are spring restrictions that start usually late in February and usually end and the end of May. Night time travel is simply defined as local times of sunrise and sunset. The state of Minnesota observe Central standard Time.

Lights, safety flags and warning signs for heavy haul and oversize loads.

Required marking, safety flags, warning signs for heavy haul and oversize loads:

Signs: Oversize load signs will need to meet the following requirements: be constructed of a rigid material or mounted on a flat surface that ensures the sign will remain flat and clearly legible to all approaching traffic. Warning signs must be a minimum size of 18 inches tall and 84 inches wide. The background of all signs must be yellow in color with the letters OVERSIZE LOAD”printed on them with a clear font that is no less than 10 inches tall and 1 and 3/8ths of an inch thick and black in color. The sign panel shall be lighted when ever use during night time transport. Whenever lighting a sign it must be an a manner that illuminates it well enough to be seen from a distance of no less than 500 feet. Any oversize load that is in excess of 12 feet wide requires oversize load signs. Oversize load signs are required on all vehicles and shipments that exceed 95 feet in length. All signs will need to be legible, clean and in good condition whenever used. The appropriate and applicable sign will need to be mounted on the roof of the escort vehicle (not on the bumpers) whenever a escort vehicle or pilot car is required. Oversize load signs will need to be mounted on the cab of the truck that is towing the shipment and on the rear of the trailer that is hauling the shipment and installed no less than 5 feet above the pavement. Signs will need to be displayed when escorting or moving a oversize load. The oversize load sign shall be required on any oversized loads with multiple dimensions. “WIDELOAD” and “LONG LOAD)” signs must be used on escort vehicles, whichever is applicable. Signs will not be permitted to extend beyond the width of the fenders of the vehicle more than 6 inches to the left or the right of pilot car vehicles. The Minnesota DOT may even require additional signs if they determine that it is necessary.
Flags: Flags are required to be used on any projection(s) that extend more than 3 feet beyond the front bumper or 4 feet beyond the rear of the truck bed of any semi-trucks or when any loads exceeds 9 feet wide and or 65 feet long. Flags must be either safety fluorescent red, yellow or orange and be no less than 18 inches square. They must be securely attached to all extremities of overhang whether on the front the rear and at the corners at the widest point so they are clearly visible to approaching motorists.
Warning lights: warning lights are required when traveling during night hours and must be visible from a distance of no less than 500 feet on a clear day. Simultaneously flashing warning lights will need to be spaced as far apart from each other as possible and are required on the front and rear of the shipment and have a flash rate somewhere between 60 and 90 flashes permit. Lenses on all warning lights must be a minimum of 4 inches in diameter or have a minimum lense surface area of 12 and 1/2 inches. Instead of a pair of warning lights that flash simultaneously either one or more strobe lights or rotating lights may be permitted.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanies by a escort vehicle or pilot car if:

Length: 95 feet to 110 feet 1 pilot car or escort vehicle on the rear. Over 110 feet requires 1 front escort and 1 chase pilot car.
Width: Loads over 12 feet and 6 inches most of state roads requires one (but not all), 14 feet and 6 inches to 16 feet require 1 front pilot car and 1 rear escort on non-divided highways but only 1 rear on divided highways.  Over 16 feet wide and they will require 1 lead pilot car and a Police/LPA on the rear. On less than 4 lane roads 1 front pilot car is required and on 4 lanes 1 rear escort is required.  Up to 15 feet wide at which point a second escort is required. 18 feet or wider requires a police escort.
Height: If over 14 feet and 6 inches in height you may be required to have a high pole depending on route..
Note: Permits will state on them if they are valid for either 3 or 5 days.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

The state of Minnesota has two different types of pilot cars/escorts.

“Civilian” escorts/pilot cars and “Peace Officer” escorts/pilot cars. Let’s learn about the two types first.

Civilian escorts/pilot cars: A civilian escort is an individual with a valid drivers license and a valid certification from Minnesota state DOT which has reciprocal agreement (MVCSHTO) with the following states: Colorado, Florida, North Carolina, Oklahoma, Utah and Washington state. Operators must be a minimum of 18 years old and in a properly equipped automobile or pickup truck. This agreement allows other civilian escorts (pilot car operators) certified in participating states to operate in each other.
Peace officer escorts: A peace officer escort is a Minnesota state licensed peace officer using a state authorized emergency vehicle displaying red and/or blue lights. A peace officer escort is the only type of escort permitted that has the ability to require on-coming traffic to yield to the right of way whenever an oncoming wide load encroaches over a 2 lane road center-line. A peace officer escort or pilot car will be required whenever a loaded trucks width extends over the roadway center-line and into on-coming traffic or whenever a loaded truck dimensions require the truck to travel in the wrong lane of the roadway. The Minnesota DOT has determined if extreme hazards exist a peace officer escort or pilot car is the most reasonable solution to maintain road safety for motorists. The carrier must arrange for peace officer escorts or pilot cars whenever they are required whether it is specified on the permit or not. Any time a shipment may potentially cross over the center-line a peace officer escort or pilot car is required.
Civilian escorts/pilot cars continued: Pilot car and escort vehicles can be either a pickup truck, SUV, van, or a passenger vehicle that is in good operating condition and is properly equipped. The driver of a pilot car or escort vehicle must be a minimum of 18 years of age and have a valid drivers license. No pilot car or escort vehicle is permitted to tow any type of trailer or other vehicle when operating in the capacity of a escort or pilot car driver. A pilot car or escort vehicle operator is not permitted to perform any other duties other than operating the vehicle. If a rear steer is needed or a remote is being utilized the operator of the pilot car or escort vehicle is not permitted to take part in any of these operations. All escort vehicles and pilot cars are required to be equipped with a wide load or long load sign that shall be displayed on the top of the vehicle. This sign must be clean clear and visible to all traffic. Rotating strobe being or flashing amber lights are required to be installed in the center of the roof of the vehicle and not be obstructed by any other signage. Multiple lights may be used provided they are not obstructed by anything and should be placed on the far right and left hand sides of the upper portion of the vehicle. A pilot car operating in the capacity of a lead vehicle will need to proceed the shipment by a minimum distance of 300 feet and no more than 700 feet. Rear escort vehicles or chase vehicles must follow the shipment at a close safe distance that clearly identifies it as part of the escorted shipment. Convoys are not permitted unless specifically authorized by the Minnesota state DOT.

Long load.


Minnesota DOT contact information and notes.

Minnesota DOT office and permit contact information:

Minnesota Administrative Truck Center
395 John Ireland Boulevard
St. Paul, MN 55155
Telephone line: 651-296-6000
Hours: Monday – Friday 8:30 AM – 3:00 PM (closed from Noon until 1 PM).
Website: www.dot.mn.gov
Central Standard Time
Notes:
Minnesota is a member of the MVCSHTO agreement.

Minnesota cities serviced.

 

 

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Minnesota State DOT Permits office before commencing movement.

 

 

minnesota-state

 

2020 British Columbia shipping regulations

2020 British Columbia DOT shipping regulations. Laws, regulations, rules and limitations for oversize or heavy-haul trucking.

British Columbia DOT regulations for oversize shipping.

British Columbia. The official Coat of Arms.

Please share your knowledge with our other visitors below.

Heavy-haul trucking & pilot car directory.
Locate trucking companies and pilot cars in British Columbia:

British Columbia heavy-haul trucking company directory.
British Columbia pilot car/truck escort company directory.

 

Legal load limits.
British Columbia legal load limits:

Length: 14.65 meters (48.06′) from the kingpin to the rear most portion of the trailer. No combinations in length over 23 meters (75.45′) overall without a permit. A 53 foot semi-trailer is allowed provided the lift axle is raised.
Width: No shipment may travel if in excess of 2.6 meters in width (without a permit) unless it is a shipment of hay which is limited to 3.1 meters (122″) or rear view mirrors which are limited to 30 cm (11.81 inches)on each side, additional auxiliary devices are allowed 30 cm (11.81 inches) and tires are allowed an additional 10 cm.
Height: No shipment may travel if larger than 4.15 meters (163″) in height without a permit.
Weight: Single axle: 9,100 kg (20,062 lbs) and the same for tandem and tridum axles. A tridem pole trailer: gross weight on any two adjacent axles in a tridum axle group must not exceed 17,000 kg (37,478 lbs). The maximum licensed gross vehicle weight of a vehicle or combination of vehicles must not exceed 63,500 kg* (139,994 lbs) without a permit (see; en B.C Regulation 95/2006, s. 3.)* THIS AMOUNT SEEMS EXCESSIVE. THIS IS THE NUMBER OUR RESEARCH PRODUCED. See; reference link below in “notes” under “maximum gross weight”. See also “comments” at bottom.
Notes: Not matter what a permit states if there is a sign posted on a highway or road that contradicts your permit the sign will take precedence over the permit so you must immediately stop traveling and get clarification. Section reference: Copyright Queens Printer Victoria, British Columbia, Canada.
Overhang: 1m in front and .061 – which seems a little odd to us as the rear maximum seems short. Please contact the BC DOT to verify.

Routine trucking permits.
Oversize and overweight trucking permits that are routinely issued by the British Columbia DOT routinely:

Length: 27.5 meters (90 feet, 2 and 43/64 fourths on an inch) in the maximum length for a routine permit in B. C.
Width: 4.4 meters (14 feet, 5 and 15/64 fourths of an inch) is the maximum with you will get from BC DOT on a routine permit.
Height: There is no number provided. The British Columbia DOT permit office wants to assess every load that is over height based on intended routing.
Weight: This is the same as height. They will not give you a solid number for routine. We are going to suggest 63,500 kg (134,994 lbs) since we had trouble locating what we feel was a reasonable maximum limit above for “legal loads limits”. we sure welcome your comments below.
Overhang: 6.5 meters (21 feet, 3 and 29/32 seconds of an inch) for routine permits for overhang.

NOTES: If your shipment is oversize AND overweight you will be required to have two separate permits. Oversize loads are required to have safety flags no less than 16″ x 16″ (46.64 cm) square and be red in color.

Superload information- extraordinary loads.
British Columbia superload information:

Superloads in British Columbia or “extraordinary loads” are defined by the DOT any shipment that is in excess of 85,000 kilograms GVW in weight, 4.4 meters (14 feet, 5 and 15/64ths of an inch) in width, 4.88 meters (16 feet and 1/8th inches) in overall height. Depending on your route you may not be classified as a “Superload” as the British Columbia DOT has  pre-approved designated routes. You can find more (limited) information on super or extraordinary loads here.

Permitted travel times & restrictions.
British Columbia DOT travel times and restrictions for oversize and overweight trucking:

The rule of daylight is defined as 1/2 hour before sunrise to 1/2 hour after sunset in B. C. No travel is allowed after 2 PM on Friday until 12:01 AM on Monday for any load in excess of 3.8 meters (12′ 6″) in width. If your shipment is over 3.5 meters (11′ 6″) in width you are only allowed to travel during daylight hours only with the exception of the Peace River region. For holiday travel restrictions you may not travel after 2 PM on the day before the holiday and after 12:01 on the day after the holiday. Holidays are New Years day, Provincial day, Good Friday, Victoria day, Canada day, Family day, Labour day, Thanksgiving day, Remembrance day, Christmas day and Boxing day.

When pilot cars are required.
British Columbia DOT requires a pilot car (escort vehicle) to accompany your shipment if you are in excess of any of the following dimensions or weights:

Length: For shipments in excess of 27.5 meters (90′) in length you will be required to have 1 rear pilot car (escort vehicle) on all roads. For shipments over 27.5 meters (90′) in length 1 front pilot car/escort and 1 rear pilot car/escort is required.
Width: Shipments in excess of 3.5 meters (11′ 6″) wide you will be required to have 1 front pilot car on two lane roads or 1 rear pilot car/escort on multiple lane roads. In some cases a beacon light may be substituted. In many cases night travel is granted at 304.8 cm (10′ wide). If granted night travel you may be required to have 1 pilot car/escort in the front if your shipment is over 3.2 meters (10′ 5 and 63/64 fourths of an inch”) in width. Shipments that are over 3.5 meters (11′ 5 and 51/64 fourths of an inch”) wide up to 4.4 meters (14′ 5 and 15/64 fourths of an inch) require 1 front pilot car/escort vehicle. Shipments that are over 3.5 meters (11′ 5 and 51/64 fourths of an inch”) wide are permitted to travel at night only.
Height: Depending on your route the BC DOT permit office will determine if you are required to have a pilot car/escort vehicle.
Weight: Weight is on a case by case basis. As long as your shipment can maintain the minimum required speed limit you will probably not be required to have a pilot car/escort by the British Columbia DOT permits office.
Overhang: If you are have more than 6.5 meters (21′ 3 and 29/32 seconds of an inch) of overhang you will be required to have 1 rear pilot car/escort.

Pilot car certifications.
Pilot car (escort vehicle) certifications and requirements for operating in British Columbia:

Pilot car/escort vehicle operators at this time are only required to: 1.) have a valid drivers license and 2.) be over 18 years of age.  We are getting reports that a certification program is in the works but at the time of this update (March 2, 2014) these above 3 requirements are all that is needed to operate a “pilot car” or “escort vehicle” within the Province of British Columbia (see comments below for more information). Also see; British Columbia Pilot Cars laws. Your vehicle is required to have a lighted sign box that is a minimum of 180 cm x 35 cm x 10 cm (72″ x 14″ x 4″),  have 2 – flashing lights mounted on the top of the sign box on each side with 2 amber strobe or rotating lights a minimum of 203 mm (8″) mounted between the flashing lights on top of the box as well.

The minimum acceptable size for a rotating amber light is 15 cm in diameter and for strobe lights 11 cm in diameter. Either type of lamp must emit light flashes in 360 degrees.

The sign box must light up and be visible from a minimum distance of 200 meters. The sign box must have either a red and white D sign or a yellow with black lettering stating “OVERSIZE LOAD”, “WIDE LOAD”,  OR “LONG LOAD”. If you have the “D” sign your letter must be no less than 20 cm (8″) in height with a 4 cm (1 5/8″) line thickness. If you have the yellow sign your lettering must be no less than 20 cm (8″) with a 4 cm (1 5/8″) line thickness. The sign box must be mounted on the top of the vehicle and covered when not in operation. You are also expected to have the following items inside of the vehicle: CB radio or high powered 2-way radio, first aid kit, fire extinguisher type A, B & C of at least a 2 liters, 3 reflective road triangles, 3 traffic cones, reflective vest (worn while working), slow/stop sign, 3 red or orange safety colored flags no less than 40 x 40 cm (16″ x 16″), nose cone flashlight and a hard hat.

Shipment, truck & trailer markings.
Truck, trailer and shipment required signs, banners and flags:

All trucks that are hauling oversize or overweight loads must have a strobe, flashing or rotating amber light mounted to the roof that is visible from 360 degrees at a minimum distance of 200 meters (656′). All 4 outermost corners of the overall shipment and any obtrusive points must have flags mounted to them that are safety red or orange in color no less than 40 cm x 40 cm (16″ x 16″) and have the flags exchanged for lighting if moving during the night. A sign stating the nature of the load; “OVERSIZE LOAD”, “WIDE LOAD” or “LONG LOAD” must be mounted to the front and rear of the overall shipment. Signs must be a minimum of 12″ in height and 6″ in width with a yellow background and black letting with lettering thickness no less than 4 cm (1 5/8″) thick.

British Columbia DOT & other information.
British Columbia DOT contact and other useful information:

British Columbia DOT – Central Permit Office
Telephone help line: 800-559-9688 or the have districts so click on area for phone and info.
Hours: 6 AM until 10 PM including (MOUNTAIN TIME ZONE). These offices are closed on Christmas, News Years Day and Boxing Day.

British Columbia DOT oversize and overweight permit applications online.
British Columbia DOT oversize and overweight permits manuals.
British Columbia Province road conditions and closures.
British Columbia HOS or hours of service rules and regulations
 -.pdf document.
British Columbia DOT spring thaw and frost laws.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the British Columbia Province DOT Permits office before commencing movement.

See also:

Frost and thaw law introduction.
British Columbia frost laws.
How to start a pilot car company.
Pilot car company certification.
British Columbia road closures – traffic reports.

2020 Washington State Shipping Regulations

2020 Washington state DOT

oversize and heavy-haul trucking laws, regulations, rules, limitations.

Washington state DOT rules and regulations for oversize and overweight trucking.

The great state of Washington official seal.

Please share your knowledge of Washington state shipping regulations with other visitors at the bottom of this page.

Washington trucking company and pilot car directory:

Washington State trucking company directory.
Washington State pilot cars and truck escorts.
Washington heavy-haul and oversize trucking permits.

Legal load limits.

Washington DOT legal load size & weight limitations: 

Length: The maximum overall length allowed legally is 75′.
Width: 8’ 6” wide.
Height: 14’ tall.
Weight: 80,000 lbs.
Overhang: 3′ in the front measured from the manufacturers front bumper and 15′ rear is the maximum and measured from the center of the rear axle.

Routine trucking permits.

Routine heavy haul, oversize shipping, trucking and transport permits:

Length: No set limits other than travel times. Case by case basis for routine maximums.
Width: 2 lane, 14′ or less, multi-lane roads with barrier strip 16′
Height:  16′ (note anything over 14′ will be required a pilot car w/height pole).
Weight: Single axle 22,000 lbs, tandem 34,000 lbs, tridum 55,000 lbs, quadem 70,000 lbs, gross weight on 5 axles 99,200 lbs, 6 axles 108,200 lbs, 8 axles 156,000 lbs.  These weights are limitations and totally dependent upon federal bridge formula.  Superload is 200,000 lbs. Also tire weight on all axles – 600 pounds per inch tire width.
Overhang: 3′ in the front and 15′ in the rear – also read in “legal loads” above.

NOTE: Non-divisible loads can not be made smaller or lighter. Exception: Dozers have have blade detached and sitting on trailer. No multiple blades. Loaders may have bucket detached as long as it is a pertinent piece for the loader being transported. No multiple buckets allowed.

Superload information.

Information on superloads for the state of Washington:

Superloads are classified as vehicles or loads that are non-divisible (or a combination of the two) that weigh in excess of 200,000 lbs or over 16′ in height or over 16′ in width in Washington state. A superload application must be submitted 30 days prior if your shipment exceeds the weight maximum or 7 days if exceeding the height or width maximums. You will need to document why it is in the best interest of the people of Washington state to grant you permission to perform the move, show that it can not be reduced in any way reasonable, have a mechanical drawing of the truck, trailer and shipment showing all of the axle positions, why you can’t perform the shipment via water, have an iron clad route in mind, a detailed plan for controlling traffic, how you plan to use your pilot cars, show that you are aware of all railroad route time tables if performing any crossings, and have a way to prove that any kind of emergency vehicle at any time can easily get past you. If you have all of this together then the Washington DOT will take a look at it and may even charge you for their time. Superloads in Washington should be completely handled by a professional or you may loose time and money. If you need assistance please see our consultation section as we have staff that specialize in superload shipments.

Legal truck travel times.

Travel times and restrictions in Washington:

7 days a week.  One half hour before sunrise and one half hour after sunset is permitted.  No movement after 3 pm on Fridays, Sunday and only travel until 12 noon.  Holiday travel is not permitted on the following holidays: New Years day, Memorial day, Labor day, Thanksgiving, Independence day and Christmas day.   If the holiday is on a Saturday or a Sunday there will be no Friday or Monday travel permitted.  The Washington State permit office is closed on the above holidays in addition to Martin Luther Kings day, Presidents day and Veterans day however travel is not restricted on these holidays as well as Columbus day and George Washington’s birthday.  Night travel is permitted for shipments that are under 12′ wide, 14′ 6″ in height and 105′ overall in length.  Overweight only loads that do NOT exceed any of the legal maximums in width, height or length are permitted to travel 24/7 as long as the tractor can maintain the minimum rated speed limit for that particular road or highway.

Notes:  There are travel restriction times during heavy traffic hours for Seattle, Tacoma, Spokane, Everett and Vancouver.  Please call the main number above for exact times or refer to the documentation on the permit that is issued.

When are pilot cars required.

Pilot car and escort vehicle information:

Length: If load is over 105′ in length you will be required to have 1 rear pilot car (escort).
Width: If over 11′ in width you will be required to have 1 front and 1 rear pilot car (escort).
Height: If height of load exceeds 14′ 6″ a front high pole pilot car (escort vehicle) is required.
Weight: If this is your only exceeded limit NO pilot car/escort vehicle is required as long as tractor can maintain minimum road speeds.
Overhang: No set limits, case by case basis.

Required pilot car and escort vehicle certifications.

Pilot car and escort vehicle certification and equipment requirements:

Pilot car or escort vehicles may be a car, truck of SUV as long as it has a gross vehicle maximum rating at least 14,000 pounds and a wheelbase of at least 60″ in width. Headlights must be on at all times while escorting shipment. Each vehicle must be equipped with 2 amber lights on top of the vehicle and horizontally mounted rotating (or strobe) amber colored flashing light which must be visible from a 360 degree angle from a minimum of 500 feet.  Company identification signs must be placed on both sides of the pilot car (escort vehicle) displaying the name of the company, phone number and be placed on both the left and right hand sides of the vehicle. These signs must be no less that 8″ tall x 12″ wide and identity writing must be plainly legible. Vehicles must be equipped with a CB radio or 2-way communication device, a 5 pound fire extinguishers type A, B and C.  A sign hand help sign with the word “STOP” on one side and “SLOW” on the other with dimensions of no less than 18″ in diameter with a minimum of 6″ letters. 3 bi-directional road safety triangles.  While operating the vehicle the driver will is required to wear a reflective safety vest, jacket or shirt.  A orange hard hard and a first aid kit must be kept in the vehicle.  A non-conductive height measuring device that is to be used while escorting loads with any height in excess of 14′ 6″ and should be set at a length of no more than 6″ above the actual height of the load and no less than 3″.  Pilot car (escort vehicle) operators are NOT allowed to carry passengers other than co-workers. Washington state escort drivers are required by law to be state certified and have a copy of their Washington State Certification ID in the vehicle at all times.  Some programs in other states may qualify the driver to operate in Washington State but you will want to verify this by calling the main office number above.    Pilot cars (escort vehicles) must keep a distance of no less than 1/2 mile from the shipment they are escorting.  If at any time ANY vehicle either the actual shipment or escorting vehicle is delayed from each other said vehicle MUST pull over and wait for the other to resume position.  All pilot cars/escort vehicles must display a roof mounted “OVERSIZE LOAD” sign visible from both the front and rear of the vehicle.  Sign must be at least 5′ long and 12″ in height, yellow in color with black letters no less than 10″ tall and 1 1/2″ in width.  Sign must be a minimum of 5′ above the pavement.  Vehicle should  have 2 safety flags red or orange in color and be a minimum of 18″ of length and/or height mounted at a 40 to 70 degree angle on all 4 corners of the vehicle but this (the flags) are NOT mandatory at the time of this publishing.

Very heavy load being shipped.

Washington DOT information.

Contact information for Washington state DOT office:

Physical address:
State Department of Transportation
921 Lakeridge Way
PO Box 47367
Olympia, WA  98504-6340

Ports of entry:
The ports do NOT issue permits in the State of Washington.
Bow Hill: (I-5 S) 360-766-6196, Plymouth: (I-82 N) 509-734-7043, Ridgefield: (I-5 N) 360-887-8231, Spokane: (I-90 W) 509-226-3366

Email: if you know of a good one please leave it below.
Help telephone line: 360-704-6340
Fax: 360-704-6350
Hours: Monday – Friday 7:00 am – 5:o0 pm
Pacific Time Zone

Click here for the State DOT Website for oversize and over-weight hauling permits.
Click here for Washington State road & highway conditions.

Washington cities serviced.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Washington State DOT Permits office before commencing movement.

 

2020 Alabama State Shipping Regulations

Alabama DOT oversize and over weight trucking permit laws.

The great state of Alabama official seal.

2020 Alabama state DOT oversize and heavy haul trucking shipping laws, rules, regulations and limitations for oversize and heavy haul trucking permits. Pilot car requirements.

Please share your knowledge of Alabama DOT regulations with others below.

Alabama oversize permits, heavy-haul trucking companies and pilot cars.

Locate oversize, heavy-haul trucking companies and pilot cars:

Alabama pilot cars and truck escorts for hire.
Alabama oversize and heavy-haul trucking companies for hire.
Alabama oversize and heavy-haul trucking permits.

Do I need a trucking permit? Legal load limits.

Alabama maximum load limits until a trucking permit is required:

Length: Trailer length maximum allowed is 57 feet (17.37 meters) including combinations.
Width: 8 feet and 6 inches (2.59 meters) wide for most roads, 8 feet (2.43 meters) for roads under 12 feet (3.65 meters) in width.
Height: 13 feet and 6 inches (4.11 meters) tall.
Weight: 80,000 pounds (36287.39 kilograms) gross (GVW).
Overhang: 4 feet (1.21 meters) off of the rear and 5 feet from the front of trailer.

Routine oversize and heavy-haul trucking permits.

These maximum dimensions/weights are considered routine oversize or heavy-haul trucking permits in Alabama:

Length: 150 feet (45.72 meters) maximum length overall.
Width: 16 feet (4.87 meters) if shipment is over 16 feet in width you are not permitted use the interstate system.
Height: 16 feet (4.87 meters) in total height.
Weight: on a single axle; 22,000 pounds (9979 kg), tandem axles: 44,000 pounds (19958 kg), tridum axles: 66,000 pounds (29937 kg), quadem axles: 88,000 pounds (39916 kg), 5 axles: 102,000 pounds (46266 kg), 6 axles: 124,000 pounds (56245 kg), 7 axles: 146,000 pounds (66224 kg), 8 axles: 168,000 pounds (76203 kg).
Overhang: 20 feet (6.09 meters) maximum.
Notes: Alabama state permitting department no longer uses the metric system. On shipments in excess of any of the above dimensions or 180,000 pounds proceed to the super load section below for more information. Loads with weight restrictions are subject to a bridge analysis.

Super load information for Alabama.

Alabama state DOT will classify any shipment in excess of the following as a super load:

Defined as shipments in excess of any of the following dimensions/weights; over 250,000 pounds (113398.0 kilograms) of gross weight, over 16 feet (4.87 meters) in width, over 16 feet in height, over 150 feet (45.72 meters) long. Anything of this nature will require special ALDOT approval. Detailed drawings will be required and need to include shop drawings of the item being shipped, the truck and trailer axle weights and spacings for both truck tractor and trailer. A letter from the manufacturer is required certifying the shipment is reduced to the lowest possible size and weight configuration as well as an explanation of why it can not be shipped by other means such as by barge or port. Loads exceeding 150,000 pounds (68038.8 kilograms)are subject to a full scale structural bridge analysis if bridges are in the route. A special weight authorization (SWA) is required from the permit office to initiate the necessary bridge rating section investigation as well. Night travel (9PM – 6AM) may be required with a state trooper or police escort (minimum of 2 when travelling). A route survey will probably be required. The Alabama State Troopers Association handles all of the scheduling of police/trooper escorts after your super load permit has been issued. A lighting system configured from strobe warning lights must be placed on each extremity of the shipment in addition to basic requirements such as flags and oversize load signs. All rail road crossings must be identified and railroad must be notified in advance of your intent to cross as well as date and time. ALDOT will more than likely verify this with the railroad and not issue a super load permit until verified. It is the carriers responsibility to notify the railroad of each intended crossing. At each rail crossing you will find a small plaque with a phone number and a “crossing number” that identifies each crossing for submitting cross requests. A bucket truck is required to accompany loads that exceed 16 feet and 5 inches (5.0 meters) in height and it is the carriers responsibility to show proof of “utility notification” for shipments in excess of 16 feet and 6 inches (5.02 meters) in height. City or county approval is required for Alabama super loads as well, please see the Alabama list of county engineers for contact details. For information published by the state you can read more Alabama super load information.

Lights, safety flags and warning signs for heavy haul and oversize loads.

Required safety markings, safety flags, warning lights for heavy haul and oversize loads:

A sign will need to be mounted on the front and rear of any over width or over length truck and trailer or combinations. Banners/signs need to be a minimum of 7 feet (2.13 meters) in width, 18 inches (45.7 centimeters) in height and be marked with black letters of no less than 10 inches (25.4 centimeters) in height, with a minimum of a 1-5/8 inch (4.12 centimeters) line thickness on a yellow or orange background. The actual words required are exactly as follows: “OVERSIZE LOAD”. Red flags must be a minimum of 18 inches (45.7 centimeters) square and be placed at all 4 outer most corners of all over-dimensional shipments.

When pilot cars or escort vehicles are required.

Heavy-haul or oversize loads may be required to be accompanies by a escort vehicle or pilot car if:

1 front pilot car (escort vehicle) is required for all loads over 15 feet and 6 inches (4.72 meters) in height with a height pole will be required adjusted 4-6 inches (10.16 – 12.7 centimeters) higher than the actual shipment. On some routes a high pole pilot (escort) may be required for even less heights. Two front and one rear pilot car (escort vehicle) is required for any shipment in excess of 12 feet (3.65 meters) wide. Rear pilot cars (escort vehicles) for mobile home shipments may be replaced with two 5 inch (12.7 centimeters) flashing, stobing or rotating amber lights. 1 rear pilot car (escort) is required for shipments over 85 feet (25.90 meters) in length. 1 front and 1 rear pilot car (escort vehicle) is required for shipments over 105 feet (32.0 meters) in length. 1 rear pilot car (escort) is required if overhang exceeds 10 feet (3.04 meters) from the front of the trailer or 5 feet (1.52 meters) off of the rear of the trailer. There are special escort requirements for bulldozers, scrapers, loaders and other construction equipment being transported with a blade or bucket intact. However on some routes that are 2 lane roads may require 1 front pilot car and on some 4 lane roads 1 rear escort.

Pilot cars/escort vehicle certifications and requirements.

Pilot car or escort vehicle mandatory operator certifications and vehicle requirements:

A pilot car vehicle must be classified as an actual passenger vehicle to qualify, ie; car, truck, van, etc. A pilot car vehicle must be equipped with a strobing, flashing or rotating amber light. The pilot car must be able to communicate with and be in constant contact with all parties working in relation to the shipment by CB or 2-way radio. Also see federal requirements for pilot cars and escort vehicles. Signs mounted on pilot car vehicles must moderately fit the vehicle and not be obtrusive in any manner.

Legal travel times for oversize and heavy haul loads.

Travel times and restrictions for heavy-haul and oversize loads:

One half hour before sunrise to one-half hour after sunset. Travel is allowed all day Saturday with NO SUNDAY TRAVEL PERMITTED. Shipments 120 feet (36.57 meters) to 150 feet (45.72 meters) in length are restricted from moving from 9:00 AM – 3:00 PM Mondays through Fridays. Travel is NO permitted on the following holidays: New Year’s Day, Memorial Day, Independence Day, Labor Day, Thanksgiving Day, and Christmas Day. The Alabama DOT state permit office is closed on these holidays as well as on Martin Luther King Day, Washington’s Birthday, Columbus Day, Confederate Memorial Day, Jefferson Davis’ Birthday and on Veteran’s Day. More information on DOT permit office closure is available here. Travel is NOT restricted on these days.

Alabama DOT contact information and notes.

Alabama DOT office and permit contact information:

Alabama Department of Transportation – Oversize Permits
1409 Coliseum Boulevard Montgomery, Alabama 36110

Phone: 334-834-1092 or toll free: 800-499-2782 – option 4.
FAX: 334-832-9084 – if this number has changed please let us know below.
Alabama DOT: Main page of the Alabama state trucking permits website. Alabama laws direct.
E-mail trucking permits:  alabamapermits@dot.state.al.us
Current routing detours: Here is the current ALDOT closures memo (if link is down visit main site).
Misc: Alabama DOT trucking Alabama permits manual – has a lot of good information. Escrow account customers may replenish escrow by credit card.  Contact: Mechelle @ 1-800-499-2782 and press option 4. Note: Alabama DOT requires you to sign their permit with red ink only.
DOT permit office Hours: 7:00 AM – 4:45 – PM
CENTRAL TIME ZONE
Alabama is a member of SASHTO.

List of Alabama cities serviced:

Additional information:

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Alabama State DOT Permits office before commencing movement.

2020 Manitoba shipping regulations

2020 Manitoba DOT shipping laws, regulations, rules and limitations, for oversize and heavy-haul the trucking  over the roads and highways of Manitoba Canada.

Please share your expertise of knowledge with our other visitors below.manitobacoatofa

Trucking & pilot car directory.

Locate trucking companies and pilot car companies in Manitoba, Canada.

Manitoba heavy-haul trucking companies.
Manitoba pilot cars and truck escorts.

Legal limits.

Legal load limits:

Length: The overall maximum length without a permit is 23 meters.
Width: The maximum width allowed without a permit is 2.6 meters.
Height: 4.15 meters is the maximum height allowed by Manitoba DOT without a permit.
Weight: 9,100 kg on steer (seems high to us so NOT a confirmed number –  use reference link below), tandem axles: 17,000 kgs, tridem: 17,000 kgs,  or 3 axle combination with proper spacing of a 23,700, quadem: 31,600 kgs, 5 axle: 39,500 kgs and 6 axles: 46,500 kgs. Let me refer you to our reference on this for clarification from Manitoba DOT as there are different weight classes.
Overhang: Our researchers are unable to find any information on maximum allowed legal overhang. We did find the pilot car requirements of 25 meters. We will call and update at a later time or you can call Debra Martin at: 204-326-8292 M-F 8-4 – if you do please comment below as this author is writing on a Sat. and they are closed. Thank you!

Routine oversize and heavy haul trucking permits.

Oversize and overweight trucking permits that are issued routinely by Manitoba province:

Length: 30 meters on length is about all you are going to get.
Width: 5 meters wide for routine permits depending on routing.
Height: Depending on routing as Manitoba DOT has designated routes the maximum height is 4.8 meters.
Weight: We were unable to get a solid figure. Manitoba DOT has different zones for weight restrictions so it all depends on which zone you need to travel in. See Manitoba DOT zone map.
Overhang: Based on the comment they made on 25 meters of rear overhang we are going to say that up to this amount is routine. If you need to speak to them call the number located above in “legal load limits” in the “overhang” section.

Superload information.

Manitoba DOT information on suplerloads or extra ordinary loads:

We will do more research on superloads in Manitoba in the future. The Manitoba DOT documentation does not cover or mention much about them so we will need to speak with someone on the phone. We are able to  see that they are well versed in shipping superloads as they mention in their online documentation that there will make arrangements to remove road side signs and replace them for shipments that are in excess of the road width. We will get back to this section soon but in the meantime appreciate any comments you may be able to leave for other visitors below.

Permitted travel times for oversize and heavy-haul loads – restrictions.

Manitoba DOT permitted travel times and restrictions:

Daylight travel times are defined as from sunrise to sunset in Manitoba. No travel is permitted after 3 PM on Fridays during the summer months for shipments in excess of 3.4 meters (11′ 2″) wide on seasonal restricted roads. In the spring shipments in excess of 4.6 meters (15′) in width are not allowed to travel on roads during the spring restriction times. On routes that are not seasonally restricted you may proceed (multiple lane roads) until 3 PM as long as you are no wider than 3.7 meters in width (12′ 2″) on Friday and resume travel on Saturday at sunrise however if you are in excess of 25 meters in length (82′) you are not permitted to travel after 3 PM on Fridays during the summer months if you are on a seasonally restricted highway and resume on Saturday at sunrise – you are allowed however to travel on holidays. Sunday travel is permitted for loads up to 3.85 meters (12′ 7″) in width on all roads that have no seasonal restrictions. On a single lane highway on holidays you can not exceed 3.4 meters (11′ 2″) in order to travel. On multiple lane roads you can travel only if you are less than 3.7 meters (12′ 2″). This is very confusing so always refer to your permit for final verification but to help the matter lets go over the restricted routes:

  • Highway 1 from Falcon lake to the Manitoba/Ontario border.
  • Highway 6, 8, 9, 15, 16, 44, 307, 313, 317.
  • Highway 10 from the US border to Riding Mountain National Park.
  • Highway 11 but only north of highway 44.
  • Highway 12 but only north of highway 15.
  • Highway 59 from the west boundary line of Brokenhead to Grand Beach and the South perimeter of St. Malo

Here is the Manitoba link for spring road restrictions with zones to help you with interpretation. Holidays observed are: New years day, Provincial day, Good Friday, Victoria day, Canada day, Family day, Labor day, Thanksgiving day, Remembrance day, Christmas day and on Boxing day.

When pilot cars are required.

Manitoba DOT requires you to have a pilot car if your shipment is in excess of any of the following regulated limits:

Length: Shipments that are in excess of 30 meters (98′ 5″) long require 1 pilot car/escort vehicle on the rear of the shipment on all roads. For shipments that include a booster of a jeep that are over 31 meters (101′ 9″) you are required to have 1 rear pilot car vehicle on all roads.
Width: If your shipment is in excess of 4.6 meters (15′) wide then you are required to have 1 front pilot car on single lane roads and 1 rear pilot car/escort on multiple lane roads. If your load is in excess of 3.66 meters (12′) but less than 4.55 meters ( 14′ 7″) then you are permitted to travel at night as long as you have 1 front and 1 read pilot car/escort vehicle on all roads and highways. Mobile homes can travel at night on multiple lane roads as long as it does not exceed 5 meters wide (16′ 4″) but are required to have 1 pilot car on the rear.
Height: If you are approved for a shipment that is over the legal limits Manitoba DOT has designated routes and you are not required to have a pilot car.
Weight: As long as your shipment is able to maintain the minimum speed requirements you will more than likely not be required to have a pilot car as long as your shipment is overweight only.
Overhang: Overhang is approved on a case by case basis. Check with the Manitoba DOT for further information to see if your shipment will require a pilot car due to excessive overhang.

Pilot car certifications.

Manitoba DOT certifications and requirements of pilot cars (escort vehicles):

Pilot car/escort vehicle operators are required to take a Manitoba DOT certification course in order to operate in this province. The certification program is recognized by all US jurisdictions that require PEVO except for New York state. Your vehicle is required to have a lighted sign box that is a minimum of 180 cm x 35 cm x 10 cm (72″ x 14″ x 4″), 2 – 175 mm (7″) diameter flashing lights mounted on the top of the sign box on each side with 2 amber strobing or rotating lights a minimum of 203 mm (8″) mounted between the flashing lights on top of the box as well. The sign box must light up and be visible from a minimum distance of 200 meters (656′). The sign box must have either a red and white D sign or a yellow with black lettering stating “OVERSIZE LOAD”, “WIDE LOAD”,  OR “LONG LOAD”. If you have the “D” sign your letter must be no less than 20 cm (8″) in height with a 4 cm (1 5/8″) line thickness. If you have the yellow sign your lettering must be no less than 20 cm (8″) with a 4 cm (1 5/8″) line thickness. The sign box must be mounted on the top of the vehicle and covered when not in operation. You are also expected to have the following items inside of the vehicle: CB radio or high powered 2-way radio, first aid kit, fire extinguisher type A, B & C of at least a 2 liters, 3 reflective road triangles, 3 traffic cones, reflective vest (worn while working), slow/stop sign, 3 red or orange safety colored flags no less than 40 x 40 cm (16″ x 16″), nose cone flashlight and a hard hat.

To operate in Manitoba you must obtain a light permit. More information is available by calling: 204-985-0920

Shipment, truck and trailer markings.

Truck, trailer and shipment required signs, banners and flags in Manitoba:

All trucks that are hauling oversize or overweight loads must have a strobing, flashing or rotating amber light mounted to the roof that is visible from 360 degrees at a minimum distance of 200 meters (656′). All 4 outermost corners corners of the overall shipment and any obtrusive points must have flags mounted to them that are safety red or orange in color no less than 40 cm x 40 cm (16″ x 16″) and have the flags exchanged for lighting if moving during the night. A sign stating the nature of the load; “OVERSIZE LOAD”, “WIDE LOAD” or “LONG LOAD” must be mounted to the front and rear of the overall shipment. Signs must be a minimum of 12′ in height and 6′ in width with a yellow background and black letting with lettering thickness no less than 4 cm (1 5/8″) thick.

Manitoba DOT contact and other information.

Manitoba DOT contact and other information:

Manitoba DOT – Central Permit Office
Telephone help line, Winnipeg; 877-812-0009 or 204-945-3961 (compliance: 204-945-3890)
Fax line: 204-945-3961
Hours of service: 7:30 AM until 6 PM Monday thru Friday – CENTRAL TIME ZONE.
Manitoba DOT oversize and overweight trucking permits website.
Manitoba spring thaw road restrictions information.
Manitoba DOT axle and axle group weight definitions and restrictions.
Manitoba province current road conditions and closure information.

The information contained in these pages is research information primarily for use by oversize and overweight trucking company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Manitoba Province DOT Permits office before commencing movement.

See also:

Manitoba frost and thaw laws.
Frost law introduction.
Manitoba road closures and reports.
How to start a pilot car company.

 

2020 Florida State Shipping Regulations

2020 Florida state shipping laws, regulations, rules and limitations, for oversize and heavy-haul trucking. Pilot car requirements.

If you have any additional knowledge please share it below.

Florida oversize permits, heavy-haul trucking companies and pilot cars.

Locate oversize, heavy haul trucking companies and pilot cars:

Florida oversize and heavyhaul trucking companies.
Florida pilot car and escort companies.
Florida heavy-haul and oversize trucking permits.

Legal load limits. Do I need a trucking permit?

Florida DOT legal load sizes and weight limitations:

Length: 75 feet overall. 48 feet semi-trailer. A 53 feet semi-trailer must have kingpin set 41 feet from the kingpin to the center of rear axle.
Width: 8 feet 6 inches (only 8 feet on some un-designated highways).
Height: 13 feet 6 inches (only 13 feet on some un-designated highways).
Weight: 80,000 pounds gross vehicle weight (GVW). 22,000 pounds on a single axle, 44,000 pounds on tandem axles and 66,000 pounds on tridem axles.
Overhang: 3 feet from the front or 3 feet from the rear of trailer maximum.

Routine oversize and heavy haul trucking permits.

Oversize and heavy haul trucking permits routinely issued Florida DOT:

Length: 150 feet overall maximum.
Width: 16 feet maximum.
Height: Up to 16 feet maximum.
Weight: Tandem 44,000 pounds,  Tridem 69,000 pounds, quadem axles must have a minimum of 10 feet between groupings. 5 axles 112,000 pounds, 6 axles 122,000 pounds, 7 axles 142,000 pounds, 8 axles 160,000 pounds, 9 axles 195,000 pounds, 10 axles 197,000 pounds, 11 axles 199,000 pounds. You may be able to add an additional 1,000 pounds (up to 5,000) to each additional foot of outer bridge but this does not apply to all configurations. Heavy haul loads that are over a GVW of 160,000 (overall) or less must have a minimum of 10 feet between groupings as mentioned above.
Overehang: No set limitation on overhang. All shipments with overhang are looked at individually.
Notes:

Travel times and restrictions.

Permitted travel times withing the state of Florida:

Travel is permitted 1/2 hour before sunrise to 1/2 after sunset.  Travel permitted on Saturday (possibly on Sunday) is permitted 1/2 hour before sunrise only until 12 noon if under 14 feet wide and under 14 feet 6 inches tall but you must request “weekend travel” when applying for your permit. Weekend travel is not permitted on New Years Day, Memorial Day, Independence Day, Labor Day, Thanksgiving or Christmas. Days before and after these holiday days may be restricted as well especially when 4 or 3 day weekends are observed. Heavy haul shipments that do not require escorts or pilot cars may travel continuously. Military shipments (MOBCON)will fall under different guidelines as noted on the permit. Be sure to clarify any discrepancies with the permit office before moving. Always follow the instructions on your permit.

Do I need a pilot car or escort vehicle with my shipment?

Am I required to have a escort vehicle or pilot car?

Length: If shipment is over 95 feet long 1 rear pilot car is required. If you have in excess of 20 feet of overhang see below.
Width: If over 12 feet wide you will be required to have 1 pilot car or escort vehicle. Some routes may require 2 pilot cars or escort vehicles. If shipment is in excess of 14 feet wide 2 pilot cars or escort vehicles will be required. If shipment is in excess of 15 feet you may be required to have a police escort in addition to a minimum of 2 pilot cars of escort vehicles.
Height: If shipment is in excess of 14 feet and 6 inches you will be required to have one escort vehicle. Over 16 feet in height needs two pilot cars or escort vehicles. Any shipment in excess of 15 feet in height will be required to have a written route survey.
Overhang: Rear overhang up to 20 feet past the center of the rear axle (or dolly) may require 1 pilot car or escort vehicle.

Pilot car and escort vehicle requirements.

Pilot car certification programs that are accepted within the state of Florida are the following: Arizona, Colorado, Georgia, Minnesota, North Carolina, Oklahoma, Virginia, Washington and Wisconsin. A “escort vehicle” or “pilot car” must be a vehicle weighing more than 2,000 pounds with a gross vehicle rating of less than 26,000 pounds. The operator of the vehicle must be certified by the state of Florida or one of the above mentioned states.

Florida oversize trucking.

How to apply for oversize and heavy haul trucking permits.

Florida Department of Transportation
605 Swannee St., MS-62
Tallahassee, Florida 32399
Phone: 850-410-5777
Hours: 7:30 AM until 5:30 PM Eastern Time

You can visit the Florida DOT website for more information on oversize and over weight transport restrictions.
You can print up a single trip permit from the Florida DOT site and learn more about filing your own permits in this state by using our DIY trucking permits guide.

Florida cities serviced.

Additional information.

The information contained in these pages is research information primarily for use by oversize and heavy-haul trucking permit company drivers, dispatchers and pilot car companies. While every effort is put into maintaining the accuracy of this information you must absolutely verify this information with the Florida State DOT Permits office before commencing movement.

 

florida-state

Florida state flag.